Professional Documents
Culture Documents
Liebert Iton: I S I S
Liebert Iton: I S I S
SETUP
10B
USB interface
RJ-11 jacks (2)
LED 3 LED 1 (green AC mains inlet
Network surge Input breaker
(red=fault) =Normal mode)
protection
On/Off button
Battery backup Battery backup
outlets outlets
(2 x Schuko) (2 x IEC C13)
TROUBLESHOOTING
9B
If the UPS malfunctions during operation, check the following chart for proper adjustment. For further assistance, please contact your local
Emerson Network Power representative.
Problem Possible Causes Solutions
Utility is normal, but LED is not Battery capacity may be low. Recharge the UPS at least 6 hours.
illuminated. The UPS battery reached end of life. Properly trained and qualified service personnel
replace the battery with the same type of
battery ,do not attempt to replace the battery
yourself.
The UPS may not be turned on. Press the On/Off button to turn on the UPS.
Alarm buzzer beeps continuously The UPS may be overloaded. Disconnect some equipment from the UPS.
although utility power is normal.
UPS does not provide expected The UPS may be overloaded Disconnect some equipment from the UPS.
backup time. Battery voltage may be low. Recharge the UPS at least 6 hours.
The UPS battery reached end of life. Properly trained and qualified service personnel
replace the battery with the same type of
battery ,do not attempt to replace the battery
yourself.
Utility is normal, but LED flashes. The power cord may not be Connect the power cord securely into a wall
connected properly. outlet.
SPECIFICATIONS
3B
*Battery run time may vary depending on load. ** Depending of output load.
Emerson and Business-Critical Continuity are trademarks of Emerson Electric Co. or one of its affiliated companies.
©2005 Emerson Electric Co.