This document contains three questions from a BCEE 344 engineering assignment from Winter 2018. Question 1 asks to select the lightest W-section that can carry a 500kN concentrated load at the midspan of an 8m simply supported girder with a laterally braced compression flange. Question 2 asks to determine the maximum uniformly distributed load a 10m I-section beam can carry, with lateral bracing only at supports, for an industrial roof. Question 3 asks to select the lightest channel section for a 6m simply supported purlin carrying 3 concentrated 50kN loads and laterally braced only at supports, made of ASTM A992 steel.
This document contains three questions from a BCEE 344 engineering assignment from Winter 2018. Question 1 asks to select the lightest W-section that can carry a 500kN concentrated load at the midspan of an 8m simply supported girder with a laterally braced compression flange. Question 2 asks to determine the maximum uniformly distributed load a 10m I-section beam can carry, with lateral bracing only at supports, for an industrial roof. Question 3 asks to select the lightest channel section for a 6m simply supported purlin carrying 3 concentrated 50kN loads and laterally braced only at supports, made of ASTM A992 steel.
This document contains three questions from a BCEE 344 engineering assignment from Winter 2018. Question 1 asks to select the lightest W-section that can carry a 500kN concentrated load at the midspan of an 8m simply supported girder with a laterally braced compression flange. Question 2 asks to determine the maximum uniformly distributed load a 10m I-section beam can carry, with lateral bracing only at supports, for an industrial roof. Question 3 asks to select the lightest channel section for a 6m simply supported purlin carrying 3 concentrated 50kN loads and laterally braced only at supports, made of ASTM A992 steel.
class; R. Tadayon Question 1 Select the lightest W section to carry a concentrated factored load 500kN applied at the midspan of an 8-m, simply supported girder. The compression flange of the section is laterally braced. As a roof member of a residential building, the girder supports finishes susceptible to cracking. Fy = 345 MPa. Question 2 Determine the maximum uniformly distributed factored load that a 10-m simply supported beam can carry. The beam section is I-shaped made of a 400x9 mm and two 200x13 mm plates welded. The beam is only laterally braced at two supports. The member supports inelastic roof covering in an industrial building. Fy = 345 MPa. Question 3 Select the lightest structural channel as a 6-m, simply supported purlin. The member carries three concentrated 50-kN loads applied at the middle and the quartile points. The purlin is made of ASTM A992 steel with Fy = 345 MPa. The member is only laterally braced at two supports.