Professional Documents
Culture Documents
Cpe SP2020 PDF
Cpe SP2020 PDF
The requirement of an IT university is to design a complete topology for its structure. Being network engineer you
are required to design the sample topology as per the following requirements:
✓ As an administrative, IT building can access the data and streaming of any department to keep checks and
to manage fault tolerance.
✓ Every building have a secured router and separate floor switches to maximize network reliability (lesser
down times in case of link failures), and it will also be able to avoid unauthorized access. The switch must
shut down the effected port, in case of unauthorized access.
✓ There will be no switching loops.
✓ Principal office will have special access to HR and accounts departmental data for monitoring.
✓ IT, Faculty and Student Facilitation Center must be secured against any Telnet request that comes from other
networks.
✓ The data from Principal office is encrypted and should provide maximum security services.
✓ You must use multi-area OSPF for routing between the network.
✓ The end host must be configured for IP addresses via DHCP server. All servers are placed in IT building
e.g. HTTP server and DNS server.
✓ Apply technique to avoid wastage of IPs in Student Facilitation Center, Auditorium and Faculty Building.
Design the network as per the requirements illustrated above using Cisco Packet Tracer.
COMSATS UNIVERSITY ISLAMABAD
Lahore Campus: Defence Road, Off Raiwind Road, Lahore
Department of Electrical and Computer Engineering
UAN: +92-42-111-001-007
Table 1
S. Recommended Submission
Deliverables
No. Pages Date
Design Proposal (PLO10-A3)
A Network Topology 1 Page
B Addressing Scheme 1 Page
3rd April,
1 C Routing Details 2 Pages 2020
D Server placements & Configurations 1 Page
E Access Restrictions Methodology 1 Page
F Flow chart 1 Page
30th April,
2 Progress Viva/Demo (PLO5-P4, PLO2-C4) Simulation File
2020
Final Demonstration (PLO5-P4, PLO2-C4) Simulation File TBD
Presentation (PLO5-P4, PLO2-C4) 5-6 slides TBD
Final Report (PLO10-A3)
A Table of Contents / List of Figures must be present
B Implementation Details with and without flow chart
As per
C Connectivity Verification Report requirement
3
D Servers' (HTTP, DNS, DHCP) operability report
TBD
E Challenges/Difficulties
F Suggestions for alternative implementation methods