Professional Documents
Culture Documents
3412E Crank Shaft Front Seal
3412E Crank Shaft Front Seal
3412E Crank Shaft Front Seal
Shutdown SIS
Previous Screen
SENR10630019
Start By:
https://s1.remotelab.space:501/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.js… 1/4
3/8/2020 3412E Industrial Engine 4CR00001-UP(SEBP2510 - 68) - Systems & Components
Typical Example
1. Use a punch or Tool (A) to put a hole in seal (1). Use Tool (A) to remove seal (1) from
the timing gear cover.
NOTE: When a replacement of the front seal is made, a replacement of the wear sleeve is
to be made also.
3. Install Tool (C) between Tool (B) and the wear sleeve. Turn Tool (C) until the edge of
the tool makes a flat place (crease) in the wear sleeve. Do this in two or more places until
the wear sleeve is loose.
https://s1.remotelab.space:501/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.js… 2/4
3/8/2020 3412E Industrial Engine 4CR00001-UP(SEBP2510 - 68) - Systems & Components
Typical Example
NOTE: The wear sleeve and seal must be installed at the same time.
1. Install the crankshaft front seal and wear sleeve with Tool (A) as follows:
a. Clean and make a preparation of the wear sleeve inside diameter and crankshaft outside
diameter with 6V-1541 Quick Cure Primer. Make an application of 9S-3265 Retaining
Compound to crankshaft outside diameter and wear sleeve inside diameter before the wear
sleeve is installed on the crankshaft.
b. Install locator (1) and the bolts on the front of the crankshaft.
c. The wear sleeve and seal come as a set with the seal already installed on the wear sleeve.
NOTE: Make sure the lip of the seal is toward the inside of the engine as shown and the
outside diameter bevel of the wear sleeve is toward the outside of the engine.
f. Put clean engine oil on the face of nut (3) and its contact area on installer (2). Install nut
(3) on stud of locator (1).
g. Tighten nut (3) until the inside surface of installer (2) comes in contact with locator (1).
h. Remove Tool (A) and check the wear sleeve and seal for correct installation.
End By:
Copyright 1993 - 2020 Caterpillar Inc. Sun Mar 08 2020 07:36:18 GMT+0200 (Eastern
All Rights Reserved. European Standard Time)
Private Network For SIS Licensees.
https://s1.remotelab.space:501/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.js… 4/4