Professional Documents
Culture Documents
Nec Pasolink Training
Nec Pasolink Training
2.9K views 5 0
PASOLINK FAMILY
4/6GHz 7/8GHz 11GHz 13GHz 15GHz 18GHz 23GHz
SERIES/MODEL SYSTEM MODULATION INTERFACE 3.6-7.1 7.1-8.5 10.7-11.7 12.7-13.2 14.2-15.3 17.7-19.7 21.2-23.6
Sy s t em Ov
Ov er v i ew
NEC has developed the PASOLINK NEO, a narrow band point-to-point digital micro
relay system operating at radio frequency (RF) bands of
6/7/8/11/13/15/18/23/26/28/32/38/52
6/7/8/11/13/15/18/23/26/28/32/38/52 GHz
6/7/8/11/13/15/18/23/26/28/32/38/52 GHz..
The PASOLINK NEO system provides interface types of of PDH, SDH and LAN. The
transmission signals are 5 to 48 x E1, 1 to 2 x E3, 1 to 2 x STM -1, 2/4 x 10/100 Bas
and GbE signals.
The systems consist of antennas, outdoor unit (ODU) and Indoor unit (IDU) same as PASOLIN
They are connected through a coaxial cable for each radio channel. Available configurations ar
protected type (1+0) and protected type (1+1). The protected type is available for twin-path type
hot-standby type.
RELATED TITLES
2.9K views 5 0
System Composition
• 1- Indoor unit (IDU) ( Modulation-Demodulation unit)
• 2- Outdoor unit (ODU) ( Transmit – Receive unit)
• 3- IF cable and connectors ( To connect the IDU & ODU)
• 4- Antenna on the required microwave band
• 5- Hybrid ( coupler ) in case of 1+1 one antenna configuration
• 6- RF cable ( If the ODU is not direct mounted to the antenna)
System Configuration
A- Non protected system (1+0)
TX RX
IDU
ODU
( 1+0 ) RX TX ODU
System Configuration
C- Protected system (1+1) hot standby –Space diversity
Double antenna configuration
TX/RX RX TX
TX/RX
ODU-1
ODU-1
Modem-1 RX
TX
Switch
Rx only
Modem-2 Rx only
ODU-2
RX ODU-2
RX
PASOLINK NEO
RELATED TITLES
2.9K views 5 0
Equipment Features
1. Advanced Technologies and Superb Performance
• High System Gain achieved by each modulation with Forward Error Correction
(FEC) Technology and distortion canceling technique called linearizer.
• High spectrum efficiency achieved by QPSK to 128QAM selectable technology.
RELATED TITLES
2.9K views 5 0
Equipment Features
4. Frequency Agility and Easy Tuning
5. System Flexibility
Equipment Feature
7. Service Channels
SV Commonality
RELATED TITLES
2.9K views 5 0
5/10/16E1 + 2Ether
4Ether + 4E1
ODU
Bitrate Free
• 5/10/20/40/48E1
• STM-1 IDU
• STM-2(310MB)
Modulation Free Interface Board
• 4PSK,16/32/128QAM
RELATED TITLES
2.9K views 5 0
System Upgradeability
1+0
ODU
5E110E116E1
ODU
1+1
Upgrade Key New INTF ODU
+Upgrade Key
New MODEM New MODEM
New INTF ODU New ODU
+New ODU
+Upgrade Key
40E148E1
Upgrade Key New INTF
ODU ODU +Upgrade Key
ODU
RELATED TITLES
2.9K views 5 0
Memory Card
RELATED TITLES
2.9K views 5 0
OMT OMT
RELATED TITLES
2.9K views 5 0
Switchover Control
• Switchover Modes:
1. Automatic Switchover:
Switching is automatically initiated if any failure or abnormality was det
the online section.
Range 5.925-
5.925- 7.125-
7.125- 10.7-
10.7- 12.75-
12.75- 14.2-
14.2- 17.7-
17.7- 21.2-
21.2- 24.25-
24.25- 27.5-
27.5- 31.8-
31.8-
( GHz ) 7.125 8.5 11.7 13.25 15.35 19.7 23.6 27.0 29.5 33.4
N Type or N Type or
RF Remote Mount PDR 70 PDR 84
PDR100 PBR120 PBR140 PBR 220 PBR 220 PBR 260 PBR 320 PBR 320
Output Power,
+29 +25 +25 +23 +24 +24 +23 +23 +22
dBm
Power Control 0 to 30 dB 0 to 25 dB
Frequency
± 6 ppm
Stability
CS = 28 (27.5) MHz 113 108 108 106.5 107.5 107.5 106 106 103.5
14 (13.75) MHz 116 111 111 109.5 110.5 110.5 109 109 106.5
7 MHz 119 114 114 112.5 113.5 113.5 114 114 109.5
Maximum Input
-15 dBm (No Error)
Level dBm
RELATED TITLES
2.9K views 5 0
Range 5.925-
5.925- 7.125-
7.125- 10.7-
10.7- 12.75-
12.75- 14.2-
14.2- 17.7-
17.7- 21.2-
21.2- 24.25-
24.25- 27.5-
27.5- 31.8
( GHz ) 7.125 8.5 11.7 13.25 15.35 19.7 23.6 27.0 29.5 33.4
N Type or N Type or
RF Remote Mount PDR 70 PDR 84
PDR 100 PBR 120 PBR 140 PBR 220 PBR 220 PBR 260 PBR 320 PBR 3
Output Power, dBm +25 +21 +21 +21 +19 +19 +18 +18 +17
CS = 28 (27.5) MHz - 77 -76 -76 -76.5 -76.5 -76.5 -76 -76 -74.
RELATED TITLES
2.9K views 5 0
CS = 7 MHz 108 103 103.5 101.5 101.5 101.5 100 100 97.5
3.5 MHz 111 106 106.5 104.5 104.5 104.5 103 103 100.5
Maximum Input
-20 dBm for the BER less than 10 -3
Level dBm
Output Power,
+25 +21 +21 +21 +19 +19 +18 +18 +17
dBm
Power Control 0 to 30 dB
Frequency
± 6 ppm
Stability
CS = 28 (27.5) MHz -75.5 -74.5 -74.5 -75 -75 -75 -74.5 -74.5 -73
Range 5.925-
5.925- 7.125-
7.125- 10.7-
10.7- 12.75-
12.75- 14.2-
14.2- 17.7-
17.7- 21.2-
21.2- 24.25-
24.25- 27.5-
27.5- 31.8
( GHz ) 7.125 8.5 11.7 13.25 15.35 19.7 23.6 27.0 29.5 33.4
N Type or N Type or
RF Remote Mount PDR 70 PDR 84
PDR 100 PBR 120 PBR 140 PBR 220 PBR 220 PBR 260 PBR 320 PBR 3
Output Power, dBm +25 +25 +21 +21 +21 +19 +19 +18 +18 +17
CS = 28 (27.5) MHz - 69.5 -68.5 -68.5 -69 -69 -69 -68.5 -68.5
RELATED TITLES
2.9K views 5 0
PDH SDH LA
1 IDU Type 1+0 Expandable / 1+1
2 Modulation Type QPSK/16/32/QAM 128 QAM QPSK/16/3
3 Baseband Interface E1: E3: STM-1 : 10/100 Base
2.048 Mbps ± 50 34.368Mbps 155.52 Mbps ± 20 1000 Base-S
ppm
±20 ppm ppm 1000 Base-T
Channel Number 4/8/16/32/48 1/2 1/2 2/4
Total Capacity 8/16/32/64/96 34/68 Mbps 155/ 2x155 10/20/40/80
Mbps Mbps 100+50/, 75
4 Service Channels V.11(Contra/Co-directional) x 2 channels,RS-232 x 2 channels
RELATED TITLES
2.9K views 5 0
A l ar
Al armm o u t p u t It
Item
ems
s
Relay Alarm Output
No. Alarm Item on LCT/PNMT ALM Indication
RL1 RL2 RL3 RL4 RL5
1 MAINT MAINT
2 PS ALM PWR
3 IDU CPU ALM --
4 ODU ALM1 ODU
5 ODU ALM2
6 ODU CPU ALM1 ODU Blinking
7 ODU CPU ALM2
8 TX PWR ALM1 ODU
9 TX PWR ALM2
10 TX IN ALM1 ODU
11 TX IN ALM2
RELATED TITLES
2.9K views 5 0
Hou
ouse
se kee
keepi
ping
ng outp
ou tput
ut Items
Relay Alarm Output
No. Alarm Item on LCT/PNMT ALM Indication
RL1 RL2 RL3 RL4 RL5
1 HK OUT1 PNMT only
Hou
ouse
se kee
keepi
ping
ng Inp
nput
ut Items
Relay Alarm Output
No. Alarm Item on LCT/PNMT Event Indication
IN1 IN2 IN3 IN4 IN5
1 HK-IN1 PNMT only
IDU Composition
IDU Shelf :
RELATED TITLES
2.9K views 5 0
IDU Modules
H2930 MDP-150MB-1AA
No. UNIT/MODULE NAME Remarks
1+0 1+1
Expandable System
1 H2931 RACK
2 H2940 MODEM QPSK/16QAM/32QAM/128
H2940 MODEM
3
H3040 DC-DC CONV -20 to –60 VDC
H2960 STM-1 INTFC STM1-E/O-S-1.1/L-S-1.1
4 H2965 LAN/WS INTFC SDH 2-Port-LAN
H3021 GbE INTFC SDH-GbE
H2960 STM-1 INTFC STM1-E/O-S-1.1/L-S-1.1 fo
5
H2965 LAN/WS INTFC WS-SC-LAN/WS/SC-LAN
RELATED TITLES
2.9K views 5 0
Baseband Interface
RELATED TITLES
2.9K views 5 0
MODEM Unit
The MODEM provides the QPSK/16QAM/32QAM/128QAM Modulation and Demodulation for E1/E
10/100 base-T (LAN), or STM-1 (SDH) data transmission in addition to the following main functions
RELATED TITLES
2.9K views 5 0
Interfaces/Switches/Indications
XIF IN/XIF OUT Only used for XPIC system
IF Signal of opposite polarization.
IF Signal for opposite polarization output.
140 MHz
75 ohms
XPIC CTRL ( D-SUB 15 pins) Serial Port
Only used for XPIC system between two IDUs.
SEL V ( MOLEX M5557-4R, 4pins) , ( DC IN)
-48VDC(negative ) , + (positive, Ground)
G Ground Terminal( 5mm2 cable)
IF IN/OUT Tx Frequency: 340 MHz
Rx Frequency: 140 MHz
Impedance : 50 ohms
Connecting IF Cable length: 5D-FB: less than 150 m
10D-FB: less than 300 m
RELATED TITLES
2.9K views 5 0
Power Supply
RELATED TITLES
2.9K views 5 0
Power Supply
RELATED TITLES
2.9K views 5 0
To indicate the m
Condition.
The Memory card
LCT LCT and PNMT An event occur
occurr
Interface
USB 1.1 SC IN/OUT
AUX/ ALM
ALM D-
D-Sub F, 44 pins
Connector Type B EOW input 1 (+) 1 16 EOW input 1 (-
(-) 30 BUZZER input 1
DSC1 V.11 6
RELATED TITLES
2.9K views 5 0
Outdoor Unit
RELATED TITLES
2.9K views 5 0
Hybrid Combiner
NEC has developed Hybrid Combiner/Divider over the full range oof f microwave
microwave frequencies for PASOLINK Series digital
radio point-
point-to-
to- point fixed wireless systems. This Hybrid Combiner/Divider compr ises
ises directional coupler, antenna interfac
mounting interfaces and polarizers. The RF signal power received by the single polarized antenna is equally distributed andan
two outdoor units through the Hybrid Combiner/Divider for 1+1 pr otected
otected systems.
There are two types of NEC Hybrid Combiner/Divider, one is coaxial cable connection type for 6/7/8 GHz Bands and the
WG connection type for 11 – 52 GHz Bands. NEC Hybrid Hybrid Combiner/Divider
Combiner/Divider is
is suited
suited for
for Andrew
Andrew or RFS Antenna, and al
ODUs.
RELATED TITLES
2.9K views 5 0
10 Coupler
The RF signal power received by the single polarized antenna is unequally distributed to two outdoor un
the ratio of 9 to 1 through the 10 dB Coupler for 1+1 protected systems. Using this 10 dB Coupler, regu
side signal level could be kept higher than in using 3 dB equal Combiner/Divider.
There are two types of NEC 10 dB Coupler; one is coaxial cable c onnection type for 6/7/8 GHz bands
other is WG connection type for 11 - 38 GHz Bands. NEC 10 dB Coupler is suited for Andrew or RFS
Antenna, and all NEC ODUs.
RELATED TITLES
2.9K views 5 0
11 - 38 GHz Direct
Dual Pol. System
RELATED TITLES
2.9K views 5 0
PASOLINK MONITOR
•Meter – Indicates the Receive
level as a dc voltage
•OW Indicator – Lights when the
OW-ON/OFF switch is set to ON.
Under this condition if the indicator is
not lit replace the battery.
(d)
RELATED TITLES
2.9K views 5 0
1-INDOOR
1-INDOOR Unpackingof
Unpacking of Unpacking
Unpacking Unpackingof of
Unpacking
INSTALLATION Accessories
Accessories ofIDU
of IDU rack(if
(ifsuppli
suppl
INSTALLATION rack
IFConnector
IF Connector&&Power
Power
Connectortermination
termination Confirm 19" Rack L
Connector
& DC-Power So
19"rack
19" rackfixi
fix
FollowThe
Follow The
terminationProcedure
termination Procedure IDU
Mounting
RackEarthi
Rack Earth
Connectio
Connectio
Refer to the IDU fixing IFCable
IF Cable
RELATED TITLES
2.9K views 5 0
UNPACKING IDU
RELATED TITLES
2.9K views 5 0
IDU MOUNT
FRONT POSITION
More than one
rack unit
Power
Connector
Socket Contact
RELATED TITLES
2.9K views 5 0
2
2- Set the socket contact to the following
position onto the hand crimping tool
3- Squeeze the handle of the hand crimping tool, insert cable into so
contact
4- Cable should fit, so insulation and bare wire are arranged as show
RELATED TITLES
2.9K views 5 0
5-Squeeze the
handle of the hand
crimping tool until
ratchet Is released
1-OUTDOOR
1-OUTDOOR Unpackingof
Unpacking of Unpacking
Unpacking Unpack
INSTALLATION
INSTALLATION Accessories ofODU
ODU
Unpacki
Accessories of Ante
Anten
FLOWCHART
FLOW CHART
IFConnector
IF Connector Removethe
Remove theODU
ODU Antenna
cover,Confirm
cover, Confirmthe
the assem
Polarity
Polarity Confirm th
FollowThe
Follow The
terminationProcedure
termination Procedure ODU
Mounting Refer to the A
assembling
UNPACKING ODU
RELATED TITLES
2.9K views 5 0
V /H POLARIZATION (1+1)
V - POLARIZATION NEC Hybrid Quas
SCREWS
SCREWS
SCREWS
H - POLARIZATION ANTENNA
CONNECTION
UNIT
RELATED TITLES
2.9K views 5 0
USE OF O-RINGS
ODU MOUNT
RELATED TITLES
2.9K views 5 0
Hardware Requirement:
Software Requirement:
RELATED TITLES
2.9K views 5 0
LCT Operation
Connect to the USB port of IDU using the USB cable
Enter URL Address: http://172.17.254.253 of the IE and press the “Enter” key.
The login window will then enter your login information User ID and password in the entry field then
press login
RELATED TITLES
2.9K views 5 0
LCT Operation
Description of LCT Menu Convections
For QPSK
RELATED TITLES
2.9K views 5 0
Inventory
RELATED TITLES
2.9K views 5 0
Inventory
• Select “Open” or “Close” to apply to the output mode to apply for even
A pop-up men
To select whic
looped
RELATED TITLES
2.9K views 5 0
Maintenance
• Select ‘CTRL’ for IDU or ‘ODU’
No.2 and click the ‘execute butto
Maintenance
RELATED TITLES
2.9K views 5 0
Maintenance
RELATED TITLES
2.9K views 5 0
ATPC MODE
RELATED TITLES
2.9K views 5 0
Assignable
For RS-232C-1 or -2
Assignab
For V.11-
RELATED TITLES
2.9K views 5 0
Provisioning (4/4)
RELATED TITLES
2.9K views 5 0
Provisioning
Metering
RELATED TITLES
2.9K views 5 0
PMON (History)
RELATED TITLES
2.9K views 5 0
PMON (History)
RELATED TITLES
2.9K views 5 0
PMON (History)
RELATED TITLES
2.9K views 5 0
PMON (History)