Professional Documents
Culture Documents
F-15 Plan and Parts
F-15 Plan and Parts
F-15 Plan and Parts
Specs:
Copyright © 2004 3DFoamy.com. All hinging for control surfaces can be packing
3D Foamy
All rights reserved.
Designed and Drawn by: Cut a "V" groove tape or actual hinges. I prefer robart hinge
Steve Shumate & Levi Jordan in foam for points epoxied in place for the added longivity
Updated: 0/19/2004
spars. Pull spar and control freeness. CA hinges work well also.
Weight 14-18 oz. through groove
to make round
Thrust 14-24 oz.
Radio 4-5 Chanel
Area 289.7 in2
Loading 6.5-8.6 oz/ft2 CG INFO
WWW.3DFOAMY.COM Start with the recomended
CG range. You can adjust it
further back as you become
more familiar with the jet.
HS-56HB
Laser cut 1/4" birch motor block.
Epoxy into plane. DO NOT use
www.3DFoamy.com CA on the moutor mount.
F-15 Park Jet
Specs:
Copyright © 2004 3DFoamy.com.
3D Foamy
All rights reserved.
Designed and Drawn by:
Steve Shumate & Levi Jordan
Updated: 0/19/2004
t r ia n g le
balsa
3/8"
6 F-2
Fwd Fuselage Sides (make 2) F-4
Top fwd F-1 F-3
fuselage (trim to
fit)
Dashed green lines indicate where
to attach balsa triangle stock
3/8" balsa triangle
4
Glue 3/8" x 7" strip of foam here to support fuselage top piece
{Nosecone\P(make 11 with
6 mm Depron\P(13 if .75" x .75" 1/64" ply
BlueCore) and \Plaminate Aft Fuselage Sides with Vertical doublers on inboard
Bulkhead F-2 side (drill 3/16" hole for
together)} Tails (make 2)
2 (make 1) pivot bearing tubes)
0 2 4 6
Bottom (make 1)
.75" x .75" 1/64" ply
(make 2 from 3 mm
recommended if your model comes out
rounded shape) These are OPTIONAL
tail heavy
Aft Fuselage
Top (make 1)
Cut notch to fit
laminate together)
motor used
(make 2 and
Motor mount
Wing (1 ea.)
{Forward inlet
Inboard Inlet (2 ea.) tops\P(make 2)}