Technical Manual
Characteristics:
Adapter
Interfaces-
“USB < Serial RS 485 & RS 422,
Serial RS232 to RS 485 & RS 422
‘Automatic low controller Circuit RS485.
Protection Circuit against voltage
surges and over current,
‘8KVA input station,
-Dip switch settings:
> RS485,
>RSt22
> 120 Ohms termination resistor
Communication indication leds.
Led On = bit 0
Led = OFF bit 1
Maximum line lenght, 1000 meters.
Grades:
“The EF232-486-2 converters can feed
peripherals through the serial port pin
cof the DB9 with 5 volts, up to Amper.
“The £232-485-2 converters can be
powered by the serial port pin 9 of the
DB9 with 5 volls, eliminating the
external source.
Serial
D047
DIP switch
(ON=RS422 Enabled
(Cana eyo C7
eben TZ
$8 Comms rowers
TWe RSVES and RSW2D adapters | Shecis: 2 to 7
Type: Reference Technical Manual
Datoijun 29 2076] Review 026 | Eaion David
[Source wwnw=comm-combr technical supportTechnical Manual: Converters 485 and 422
Output Configuration:
Configuration dip switches define two
serial communication standards.
S435 2 wire Half duplex
wextcrtagoes
eee aur
system with A transmission protocol and
reception,
yOe7
RS485
‘Switch Position
R842 RS485
Switen Position Switch Position
RS422
‘Switch Position
(Cana eyo C7
eben TZ
Importante: importante:
This RS485 product works without ‘The mode activation switches operate in
communication protocol in pointto- ‘opposition to one another
Point, thanks to the automatic flow
control circuit, but with some
restrictions, as follows:
When you tum the keys of the RS485,
the RS422 mode switches must be on
turned off and vice versa.
‘During the transmission port does K ~
not receive data. ‘The key TERM 1 league teminagdo left TX TERM RX
pair on
‘The TERM 2 key alloy termination of the TT
12
right pai
YY)
R422
‘Switch Position
Rs485 RS422 RS485
Switch Position Switch Position ‘Switch Position
TERM 4 $8 Comms rowers
Terminator pair 485 “Texminator pair RX 422 ‘Terminator pair 485 “Tie: RS485 ond R5422 adapters | Sheets: 3 to 7
‘and Tx 422 ‘and TX 422 Type: Reference Technical Manual
Datoijun 29 2076] Review 026 | Eaion David
[Source wwnw=comm-combr technical supportTechnical Manual: Converters 485 and 422
RS 485 network: use of necessary communication protocol: ModBUS, FildBUS, ProfBUS
and others.
Master Slave 1 Slave 2 Slave 3
oT
ae
i
Attention:
— Connecting positive lines
Respect the polarization
of lines
Terminator Terminator Terminator Terminator Terminator
switched on switched off switched off switched off switched off
Position the two keys
Upto 1000 meters
[oft] Position the two keys
‘Aftent
£RS485 srial communication networks, the slaves any communicate with the maser port, watch the par
Bonding obeying platy
Connecting negative lines}
-Until Slave 34
Terminator
‘switched on
$8 Comms rowers
TWe RSVES and R422 adapters | Shecte: 4 bo 7
Type: Reference Technical Manual
Datoijun 29 2076] Review 026 | Eaion David
[Source www comm combr
Zechnieal supporéTechnical Manual: Converters 485 and 422
RS 422 network: use of necessary communication protocol: ModBUS, FildBUS, ProfBUS
and others.
Attention:
Respect the polarization
Connecting positive lines
of lines
Connecting negative lines}
Master Slave 1 Until Slave 31
Terminator Terminator Terminator Terminator Terminator Terminator
switched on switched off switched off switched off switched offo switched on
Position the two keys
Upto 1000 meters
[oft] Position the two keys
‘Aftent
Serial communication networks RS 422, the slaves only communicate with the master por, watch the pair
bonding to
$8 Comms rowers
1-pair TX master is connected to the RX (s) of the slaves obeying polarity.
TWe RSVES and R422 adapters | Shects: 5 to 7
‘-pair RX masier is connected tothe TX (s) of the slaves obeying polarity
Type: Reference Technical Manual
Datoijun 29 2076] Review 026 | Eaion David
[Source wwnw=comm-combr technical support: Converters 485 and 422 Attention: == Connecting positive lines
Respect the polarization
RS 485: does not require point to point communication protocol. of lines = Connecting negative lines
Technical Manual
Upto 1000 meters
2 ———arv—rvr—wW___>
Preece) =
De UO taal
Up to 1000 meters
Position the two keys
he RS232 adaptors for RS422 & 485, may exempt extemal source using the DB9 9 pin as
power input § Volts, the interface used to provide this condition. 38Comms nersoos
‘The Comms products with serial ports provides 5 volts on pin 9, on customer request. Tile RSVES and RGWZD adapters | Shea 6 to 7
‘The drive can also provide § volts on pin 8 by the source that accompanies il It should also be requested Tipe: Reference Technical Manual
by the customer, Datoijun 29 2076] Review 026 | Eaion David
[Source wwnw=comm-combr technical support1S-USB-485-2
Technical Manual: Converters 485 and 422
E-232-485-2 (winout an external source)
EF-232-485-2
$8 Comms rowers
Te SUES and ASAD adaptors | Shows 7 to 7
Tipe: Reference Techical Manual
Dain 29-2078] Revew_ 020 | Eaton Dovid
Keowee www-commS:conbr — technicl suppore