Professional Documents
Culture Documents
Awits
Awits
Awits
Problem No. 1: The cantilever beam as shown in the Figure (a) has the cross section shown in the Figure
(b). If the allowable stresses are 10,000 psi shear and 16,000 psi tension and compression at point A
(just below the flange), determine the maximum allowable load P.
Problem No.2: A 4-in-diameter solid circular steel shaft is loaded and supported as shown in the figure.
If the maximum normal and shearing stresses at point A must be limited to 7500psi tension and 5000psi,
respectively, determine the maximum permissible value for the transverse load V.