This document summarizes calculations for anchor design in concrete. It evaluates concrete breakout strength and pryout strength in shear for a group of anchors and single anchor. It finds that the design strength due to tension and shear does not meet the required interaction criteria of being greater than 1.2.
This document summarizes calculations for anchor design in concrete. It evaluates concrete breakout strength and pryout strength in shear for a group of anchors and single anchor. It finds that the design strength due to tension and shear does not meet the required interaction criteria of being greater than 1.2.
This document summarizes calculations for anchor design in concrete. It evaluates concrete breakout strength and pryout strength in shear for a group of anchors and single anchor. It finds that the design strength due to tension and shear does not meet the required interaction criteria of being greater than 1.2.
ca1 150 mm Basic concrete breakout strength in shear of a single anchor Vb 33 kN Projected area for a single anchor Avc0 101250 mm2 Avc 118125 mm2 Eccentricity of centroid of group for shear ev 0 mm Modification factor for eccentricity in shear Ψec,V 1 Modification factor for edge effect Ψed,V 1
For anchors in cracked concrete with no supplementary Ψc,V 1
reinforcement or edge reinforcement smaller than a No. 4 bar Design concrete breakout strength for group of anchors ΦvVcbg 27 kN Check ratio (Vzmax/Φ*Vcbg) 0.40 < 1 OK Design concrete breakout strength for a single anchor ΦvVcb 27 kN Check ratio (Vzmax/Φ*Vcbg) 0.40 < 1 OK 2) Concrete Pryout Strength of Anchor In Shear kcp 2 Nominal concrete pryout strength for group of anchors Vcpg 180 kN Design pryout strength for group of anchors ΦvVcpg 126 kN Check ratio (Vzmax/Φ*Vcpg) 0.09 < 1 OK Nominal concrete pryout strength for a single anchor Vcp 90 kN Design pryout strength for a single anchor ΦvVcp 126 kN Check ratio (Vzmax/Φ*Vcp) 0.087 < 1
D) INTERACTION OF TENSILE AND SHEAR FORCES
The lowest design strength due to tension ΦNng 63 kN The lowest design strength due to shear ΦVng 27 kN Check interaction 1.12 > 1.2 NOT OK The lowest design strength due to tension ΦNns 41 The lowest design strength due to shear ΦVns 27 Check interaction 1.50 > 1.2 NOT OK