Professional Documents
Culture Documents
Sofiplus 2020: Interpolation of Cross Sections
Sofiplus 2020: Interpolation of Cross Sections
SOFiPLUS 2020
The interpolation of cross sections takes place automatically during the export from
SOFiPLUS(-X). Beside from the de�nition of the cross section, a requirement for the in-
terpolation includes the de�nition of a minimum of one beam or structural line with dif-
ferent start and end cross sections (type 1). For type 2 the de�nition of a master cross
section is required with appropriate references and variables, which have to be de�ned
at an axis.
Interpolated cross sections are created for all beam sections and intermediate nodes.
These are not editable in the Cross Section Editor (see Cooperation with the other
SOFiSTiK Modules).
2. Interpolation of the cross section geometry using reference points and variables
along the axis.
This option is available only for customers with a CABD license. For the interpolation
along an axis, only a master cross section is required. Variable points (reference points)
are de�ned in this section and can be assigned to corresponding variables/axes. In the
case of an interpolation with a master cross section, the numbers of the interpolated
cross sections can be in�uenced as follows:
E.g. if the master cross section receives the number 200, then the interpolated cross
sections start with number 201.
1 of 2 09/06/2020, 04:05
Interpolation of Cross Sections — SOFiPLUS 2020 https://www.sofistik.de/documentation/2020/en/s...
2 of 2 09/06/2020, 04:05