Professional Documents
Culture Documents
WS23P003 01gb PDF
WS23P003 01gb PDF
WS23P003 01gb PDF
NOTICE
General The relay module RM-10 has been replaced by a new type, RM-11a. When
replacing the RM-10 with RM-11a the actions described below must be
observed.
WECS START
MCU STOP/SHUTDOWN
LOCAL STOP FUEL LIMITER + 12 VDC
Instructions On RM-11a the cable supervision circuits are using a 10 kohm end
resistor instead of 100 kohm resistor used by the RM10. These
resistors needs to be changed if cable supervision failure alarms
trigger when installed. See Fig 1 of typical connections on the RM for
the cable supervision resistors
R4 n.c.
Lube oil press, 1 1
10k
PSZ201
switch R5 1 PSZ201
3 P Lube oil pressure
R6 2 2x0,75 Cu
10k 2 2 switch
Optional R7
shutdown
switch R8
Wärtsilä Finland Oy P.O. Box 252 (Tarhaajantie 2) Telecop. +358 10 709 1847 Tel. +358 10 709 0000 Business ID 0773744-3
Services, Vaasa FIN-65101 Vaasa, Finland Telecop. +358 10 709 1380 Registered Office: Vaasa
Wärtsilä Finland Oy P.O. Box 50 (Stålarminkatu 45) Telecop. +358 10 709 3279 Tel. +358 10 709 0000
Services, Turku FIN-20811 Turku, Finland Telecop. +358 10 709 3410
Services, Wärtsilä Finland Oy Spare Parts Notice
Issue Document No. Page
01 WS23P003 2(2)
Fig 2. Typical cable supervision resistor connection for the emergency stop
button.
Ordering instructions Contact your closest Wärtsilä Service Network. When ordering please
specify the engine serial number and part number:
No part of this publication may be reproduced or copied in any form or by any means (electronic, mechanical, graphic, photocopying,
recording, taping or other information retrieval systems) without the prior written permission of the copyright holder. Wärtsilä Finland Oy
makes no representation, warranty (express or implied) in this publication and assumes no responsibility for the correctness, errors or
omissions for information contained herein. Information in this publication is subject to change without notice.
Unless otherwise expressly set forth, no recommendation contained in this document is to be construed as provided due to a
defect in the engine, but merely as an improvement of the engine and/or the maintenance procedures relating thereto. Any actions
by the owner/operator as a result of the recommendations are not covered under any warranty provided by Wärtsilä and such
actions will thus be at the owners/operators own cost and expense.
NO LIABILITY WHETHER DIRECT, INDIRECT, SPECIAL, INCIDENTAL OR CONSEQUENTIAL, IS ASSUMED WITH RESPECT TO THE
INFORMATION CONTAINED HEREIN. THIS PUBLICATION IS CONFIDENTIAL AND INTENDED FOR INFORMATION PURPOSES
ONLY.