Professional Documents
Culture Documents
Three County Fairgrounds, Northampton MA, Building Pemit For Three New Horse Barns
Three County Fairgrounds, Northampton MA, Building Pemit For Three New Horse Barns
Three County Fairgrounds, Northampton MA, Building Pemit For Three New Horse Barns
BP-2011-0613
COMMONWEALTH OF MASSACHUSETTS
Map;Block: 25C 251 CITY OF NORTHAMPTON
Pennit: Building
# BP-2011-0613
JS-2011-000976
Final: Final:
Rough Frame:
Intermediate Project: Site Plan AND/OR Special Permit With Site Plan
Major Project: Site Plan AND/OR Special Permit With Site Plan
____Demolition Delay
Note: Issuance of a Zoning permit does not relieve a applicant's burden to comply with all zoning
requirements and obtain all required permits from Board of Health, Conservation Commission, Department
of public works and other applicable permit granting authorities.
* Variances are granted only to those applicants who meet the strict standards ofMGL 40A. Contact Office of
Planning & Development for more information.
Version I. 7 Commercial Build'
..
City of Northampton
Building Department
APPLICATION TO CONSTRUCT, REPAIR, RENOVATE, CHANGE THE USE OR OCCUPANCY OF, OR DEMOLISH ANY BUILDING
54 Fair Street
Map Lot Unit
Northampton, MA 01060
Zone Overlay District
4. Mechanical (HVAC)
5. Fire Protection
. 6. Total;:: (1 + 2 + 3 + 4 + 5)
This Section For Official Use Onl
Building Permit Number Date
Issued
Signature:
Interior Alterations D Existing Wall Signs D Demolition D Repairs D Additions D Accessory Building D
Exterior Alteration D Existing Ground Sign D New Signs D ~
Roofing D
,,--" -- ,~~~-, ~~~-,
Change of Use D Other D
3~~
Brief Description
Of Proposed Work:
COMPLETE THIS SECTION IF EXISTING BUILDING UNDERGOING RENOVATIONS, ADDITIONS AND/OR CHANGE IN USE
I Existing Hazard Index 780 CMR 34): Proposed Hazard Index 780 CMR 34):
SECTION 6 BUILDING HEIGHT AND AREA
OFFICE USE ONLY
BUILDING AREA EXISTING
1st 18~7~Q.
nd
nd 2
2
3'd
3'd
4th
4th
7. Water Supply (M.G.L. c. 40, § 54) 7.1 FloodZone Information: 7.3 Sewage Disposal System:
Public IZl Private D Zone' A ~ ..~. Outside Flood ZoneD • Municipal III On site disposal system D
Version 1. 7 Commercial Building Permit May 15. 2000
8, NORTHAMPTON ZONING
Existing Proposed Required by Zoning
This column to be tilled in by
Building Department
L: ... R: .......
Rear
Fill:
(volume & Location)
B. Does the site contain a brook, body of water or wetlands? NO 0 DON'T KNOW 0 YES ®
IF YES, has a permit been or need to be obtained from the Conservation Commission?
Needs to be obtained
o Obtained
® , Date Issued: 04/05/2010
D. Are there any proposed changes to or additions of signs intended for the property? YES 0 NO ®
IF YES, describe size, type and location:
E. Will the construction activity disturb (clearing, grading, excavation, or filling) over 1 acre or is it part of a common plan
that will disturb over 1 acre? YES ® NO 0
IF YES, then a Northampton Storm Water Management Permit from the DPW is required.
Version!.7 Commercial Building Permit May 15,2000
SECTION 9- PROFESSIONAL DESIGN AND CONSTRUCTION SERVICES - FOR BUILDINGS AND STRUCTURES SUBJECT TO
CONSTRUCTION CONTROL PURSUANT TO 780 CMR 116 (CONTAINING MORE THAN 35,000 C.F. OF ENCLOSED SPACE)
9.1 Registered Architect:
81~-17 LL~_'~mm
!:~';i:-I &, J9
Expiration Date I
Telephone
. ~f!'\R¥- ~~~~I...:\)
Name Area of Responsibility
£Ie.J,-kc",-\
Name Area of Responsibility
MIICNA.tJi. <..•..c..
Area of Responsibility
'l8~l/o
Registration Number
Signatur,
goo/8k4>.~.4</.?f
T~lephone
I; .·..·~Z3·~/li
Expiration Date
568-0636 .
Version!.7 Commercial Building Permit May 15,2000
No
11 -
OWNERS AGENT OR CONTRACTOR APPLIES FOR BUILDING PERMIT
hereby '1 ze
Gene .Kurtz,
. _.... Kurtz Inc.
,.~~." _.~..... ... H ....... H~. . . . . . . . . . . . . . . . . . . . . .
_____ . to
act on my behalf, in all matters relative to work authorized by this building permit application:
Date
Agent hereby declare that the statements and information on the foregoing application are true and accurate, to the best of my knowledge
and belief.
Print Name
Date
'(~!~2.~§..~:0636
Telephone
Workers Compensation Insurance affidavit must be completed and submitted with this application, Failure to provide this affidavit will result
in the denial of the issuance of the buildinQ permit
ARCHITECTS
28 AMITY ST. . SUITE 28
AMHERST
MASSACHUSETTS 01002
413'259'1630
Louis Hasbrouck
Building Commissioner
Office of the Building Commissioner
Puchalski Municipal Building
212 Main Street
Northampton, MA 01060
Pursuant to Section 116.2 of the Massachusetts State Building Code, I certify that
Kuhn Riddle Architects, Inc. has prepared the drawings and specifications in compliance with all applicable
provisions of the Massachusetts State BUilding Code and that KRA will perform the necessary professional
services for the referenced project.
Sincerely,
Jonathan M. Salvon
Mass. Registration No. 9527
JOHN WOOD KUHN, AlA • CHARLES W. ROBERTS, AlA • JONATHAN M, SALVON, AlA
Tk~tJ#.eH~
lUf~J,P~~
~, ,.,,~ 0210g-1~1g
In accordance with the section 116.0-116.4.2 of the 7th edition Massachusetts State Building Code:
for the above named project and that to the best of my knowledge, such plans, computations and specifications meet
the applicable provisions of the Massachusetts State Building Code, all acceptable engineering practices and all
applicable laws for the proposed project.
Furthermore, I understand and AGREE that I shall perform the necessary professional services and be present on
the construction site on a regular and periodic basis to determine that the work is proceeding in accordance with the
documents approved by the building permit and shall be responsible for the following as specified in section 116.2.2:
1. Review of shop drawings, samples and other submittals of the contractor as required by the construction
contract documents as submitted for the building permit, and approval for the conformance to the design
concept.
2. Review and approval of the quality control procuedures for all code-required controlled materials.
3. Be present at intervals appropriate to the stage of construction to become generally familiar with the
progress and quality of the work and to determine, in general, if the work is being performed in a manner
consistent with the construction documents.
~~~
Tk~tJ#.e~~
Dl~J,1>~~
0.,." A~ ~Lut, R~ 1301
~, ~~ 0210g-1~1g
In accordance with the section 116.0-116.4.2 of the 7th edition Massachusetts State Building Code:
for the above named project and that to the best of my knowledge, such plans, computations and specifications meet
the applicable provisions of the Massachusetts State Building Code, all acceptable engineering practices and all
applicable laws for the proposed project.
Furthermore, I understand and AGREE that I shall perform the necessary professional services and be present on
the construction site on a regular and periodic basis to determine that the work is proceeding in accordance with the
documents approved by the building permit and shall be responsible for the following as specified in section 116.2.2:
l. Review of shop drawings, samples and other submittals of the contractor as required by the construction
contract documents as submitted for the building permit, and approval for the conformance to the design
concept.
2. Review and approval ofthe quality control procuedures for all code-required controlled materials.
3. Be present at intervals appropriate to the stage of construction to become generally familiar with the
progress and quality of the work and to determine, in general, if the work is being performed in a manner
consistent with the construction documents.
I shall submit periodically, in a form acceptable to the rogress report together with pertinent
comments. Upon completion of the work, I shall sub ial a final report as to the satisfactory
completion and readiness of the project occupancy. 'fI e.,
Office ofInvestigations
www.mass.govldia
7
Are you an employer? Check the appropriate box: Type of project (required):
1. ~ I am a employer with L\ 4. 0
I am a general contractor and I 6. ~ew construction
employees (full and/or part-time).* have hired the sub-contractors
2.0 I am a sole proprietor or partner- listed on the attached sheet. :;
7. 0 Remodeling
ship and have no employees
These sub-contractors have 8. 0 Demolition
working for me in any capacity.
workers' compo insurance. 9. 0 Building addition
[No workers' compo insurance 5. We are a 0
corporation and its
10.0 Electrical repairs or additions
required.] officers have exercised their
3.0 I am a homeowner doing all work right ofexemption per MGL 11.0 Plumbing repairs or additions
myself [No workers' compo C. 152, §J(4), and we have no 12.0 Roof repairs
insurance required.] t employees. [No workers'
compo insurance required.]
13.0 Other
"Any applicant that checks box #1 must also fill out the section below showing their workers' compensation policy infurmation.
't Homeowners who submit this affidavit indiCllting they are doing all work and then biTe outside contractors must submit a new affidavit indicating such,
tcontractors that check this box mnst attached an additional sheet showing the name ofthe sub-contractors and their workers' compo policy information.
I am an employer that is providing workers' compensation insurance for "U' employees. Below is the policy andjob site
information.
Insurance Company Name: A T M, (it 0") U f' L.. INS. to,
Policy # or Self-ins. Lic. #: \.OM 2- 6' 0 0 b 1 q g:> Expiration Date:~--IL,---il_ _,
Job Site Address: 5' 4 ~;+ LR.. &1:, City/State/Zip: fbo d-kA.M.ptO~l M/f. 01 D"O
Attach a copy oHile workers' compensation policy dectimrntion ~ge (snowing 1t!ble pOlley ~um!bel!" ii1lil!t1:i expiradm:n i1~1'[ef..
Failure to secure coverage as required under Section 25A ofMGL c. ;'52 can lead to the imposition ofcrimi"1al
fine up to $1,500.00 and/or one-year imprisonment, as well as civil penalties in the form of a STOP WORK ORDER aBO: a fin",
of up to $250.00 a day against the violator. Be advised that a copy of this statement may be forwarded to the Ofiice of
rtmlrieejt
[ ' R~y Ham>w . At Ph,mp. jo~~~ AgO"'Y. jo, """D, To, """' B~"'" Date: 211612010 10:49 AM Page: 1 of 1
COVERAGES
THE POUCIES OF INSURIINCE LISlED BELOW HAVE BEEN ISSUED TO THE INSURED NAMED ABOVE FOR THE POliCY PERIOD INDICAlED, NOTWITHSTANDING
ANY REQUIREMENT, TERM OR CONDITION OF ANY CONTRACT OR OTHER DOCUMENT WITH RESPECT TO WHICH THIS CERTIFICATE MAY BE ISSUED OR
MAY PERTAIN, THE INSURANCE AFFORDED BY THE POliCIES DESCRIBED HEREIN IS SUBJECT TO ALL THE TERW'oS, EXCLUSIONS AND CONDITIONS OF SUCH
POLICIES, AGGREGATE LIMITS SHOWN MAY HAVE BEEN REDUCED BY PAID CLAIMS,
LTR NsR~ TYPE OF INSURANCE POLICY NUMBER "'D'i~ (MMmoNyt "l5k¥E' (~tlIg<t~·w LIMrfS
o
i AUTOMOBILE LIABILrrY •
LIMIT
(Ea aCCident! $1,000,000
A ANY AUTO 4Z2596911 01/28/10 01/28/11
ALL OWNED AUTOS
BODIL Y INJURY
$
~~~~~
(Por person)
X 'HIRED AUTOS
BODIL Y INJURY
(Per aCCident) $
X NQN-OWNED AUTOS
! - PROPERTY DAMAGE
(Per aCCident) $
-Xl DEDUCTIBLE
RETENTION $10000
$
$
$
WORKERS COMPENSATION AND
EMPLOYERS' LIABILITY
ITO'R'y tiMI-rs I IU~fl"
B ANY PROPRIETORIPARTNERI::XECJTIVE
WMZ8006198 01/28/10 01/28/11 EL EACH ACCIDENT $ 1000000
OFFICERIMEMBER EXCLUDED?
EL DISEASE EA EMPLOYEE $ 1000000
If yes, describe under I
SPECIAL PROVISIONS below EL DISEASE - POLICY LlMIl ; $ 1000000
: OTHER
IMPOSE NO OBLIGATION OR LlABILrrY OF ANY KIND UPON THE INSURER. ITS AGENTS OR
To Provide Proof of Coverage
REPRESENTATIVES,
('n.
ACORD 25 (2001108)
., .....~
ReQistration: 100594
Type: Private Corporation
Expiration: 6/19/2012 Tr# 298516
KURTZ INCORPORATED
Eugene Kurtz - - - - - - - - - - - - - - - - .... ...- - -....
P.O. BOX 1597 ~
WESTFIELD, MA 01086
-.,....->...... ,.,,---:--"'--...,...,..""-~--- ,.,. ,,--------,--~ ... ~,""'y~ - - - - -.. ~--. -,~--- ...",.."
--.,... -'" ~~"~-,",,, ...... -,,"~ ., .."--,-~,,,,"""
EUGENE J KURTZ
396 PROSPECT ST
WESTFI Elf), MA 01085
~
{j/LESTER BUILDINGS Lester Buildings, Inc.
276 Woodbine Road. P.O. Box 129
Cleur Brook, VA 22624
Tel: 540.665'(lI82
Fax: 540.665.0109
www.lesterbuildings.com
Kurtz Incorporated
Gene Kurtz
810 Southampton Road; Suite 1
Westfield, Massachusetts 01085
Northampton, Massachusetts
Dear Gene,
This will address a couple of questions that were raised about the structural design of this building:
• The footings supporting the building columns are designed as structural plain concrete in
accordance with ACI-318 Chapter 22. There is no reinforcement.
• The building, including the roof trusses and purlins are designed for both uniform and unbalanced
snow loading in accordance with the 7th Edition of the Massachusetts State Building Code.
l
~\./v
Kevi 'rard C
. ~.
Kurtz, Inc. TRANSMITTAL
No. 19
810 Southampton Road Phone: (413) 568-0636
Westfield. MA 01085 Fax: (413) 568-5430
Northampton, MA 01060
JOB: 101101
ATTN: Louis Hasbrouck
CONTRACT/PO: 10043
REMARKS:
~~
Signed: Q -~
Charles Sereda
Date: 01/04/2011
September 29,2010
Building Design Criteria per Chapter 16, Massachusetts State Building Code, 7th Edition.
Sloped Roof Factor Cs = 1.0 - 5:12 pitch w/o slippery, unobstructed surfuce
Exposure B
Appendix § 120.G501.4 - Enclosed spaces below the BFE shall not be used for
human occupancy, except egress, incidental storage, etc. Fully enclosed
spaces shall be designed to automatically equalize hydrostatic forces by
allowing for entry and exit of floodwaters.
Seismic: §1614.1.2 - Agricultural buildings wi incidental human occupancy are exempt from
~ .t
~~l
!H~
§
i>orI'J
"
~~
~ ~lj -"0 ..:
n.l
.....s
:E = .
ti
1~ ~
11U
!H~ &~I~ .
It~~ ==
::I ::I
00
~
c·
.9Q,
tJlo!)o.
,.;.:.~
n.l .... tJlo
E5n.ln.l'-<
;::l
~
i! Ii§i
6~
I ••. Afd.li.
e1E & i!if&
U$.o
Q) OJ) E
os
IllOCJ
" ~. ~~ lIb ~:"&<i Q).:: .ct:.,
"l·~,
'< z§ 0: ~ll'ij $.0 ~ ;z:
·h", }lU
.~
I III ~!~j
]G~]
g'l 10::::
~~ ~f
:g h fU~ @!fj f~
~ . .. ,,~
..c:~
E-t
V3HV3dO~S030NVdX3-13SVHd
\
\
- 1\
r
\
"'NJ~MOHS
q';l.1. 'v'Jo,;J~
"'NJ~MOHS
. . q;l.1. 'v'-:JO,;J">t
. . ',. . . . .• >....,
I
---------1
i 001 00;; Q
L-_.__"""=~-----.---..........,."k___'
1
\
\
r
\
1\
II
I
L---t---li.,
.:r-i-·--.l
dg
'
,
_:
I i1! <
,-------1
\ i
I--:::=-:=~~,......._--J' L-----:t-:~:----------- __k___'