Professional Documents
Culture Documents
Configure Microphone and Setting Speaker Levels For Measurements in Dirac Live 2
Configure Microphone and Setting Speaker Levels For Measurements in Dirac Live 2
... if you find the content on this page helpful and want to give back. Thanks!
Requirements
AVR with Dirac Live 2 room correction (e.g. NAD T758v3), Mac or PC capable of running Dirac Live 2.5 or
later.
Getting started
1. Connect the measurement microphone to your computer or AVR/AVP (if supported).
2. Place microphone at the main listening position using a mic stand. Mic pointing up towards the ceiling.
Mic tip exactly at ear height in the center where your head would be.
3. Start Dirac Live 2
4. Select your AVR/AVP
https://mehlau.net/audio/dirac-live-2-mic-speaker-levels/ 1/4
6/5/2020 Configure microphone and setting speaker levels for measurements in Dirac Live 2
Volume Calibration
Preparation
https://mehlau.net/audio/dirac-live-2-mic-speaker-levels/ 2/4
6/5/2020 Configure microphone and setting speaker levels for measurements in Dirac Live 2
Level speakers
https://mehlau.net/audio/dirac-live-2-mic-speaker-levels/ 3/4
6/5/2020 Configure microphone and setting speaker levels for measurements in Dirac Live 2
2. Move "Master output" slider up until level of the softest speaker is roughly in the middle of the green
zone.
3. Click "Play" button for the left speaker and reduce its level to roughly the middle of the green zone.
4. Repeat step 3 for all other speakers except the subwoofer.
5. Click "Play" button for the subwoofer.
6. Turn level/gain knob on your subwoofer up until the level is also roughly in the middle of the green zone.
You're now ready to proceed to the "Select Arrangement" tab and do the actual measurements.
... if you find the content on this page helpful and want to give back. Thanks!
https://mehlau.net/audio/dirac-live-2-mic-speaker-levels/ 4/4