Professional Documents
Culture Documents
Exercise Design
Exercise Design
Using distortion-energy
method to determine the factor of safety. Given O(x) = -30 MPa, O(y) = -65 MPa
and t(xy) = 40 MPa.
3.20
3.25
3.30
3.35
2. Repeat Q1 with O(x) = -80 MPa, O(y) = 30 MPa and t(xy) = -10 MPa.
2.80
2.95
3.00
3.05
3. Determine the (a) principal stress (max and min) and (b) maximum principal
shear stress at point B.
2. Shaft 'a' in the figure has a power input of 75 kW at a speed of 1000 rev/min in
the counter-clockwise direction. The gears have a module of 5 mm and a 20degree
pressure angle. Gear 3 is an idler. Find the force F(3b) that gear 3 exerts against
shaft 'b'
20.53 kN
21.73 kN
18.73 kN
16.53 kN
A steel rotating-beam test specimen has an ultimate strength of 1600 MPa.
Estimate the life of the specimen if it is tested at a completely reversed stress
amplitude of 900 MPa.
30 000 cycles
46 400 cycles
36 500 cycles
48 600 cycles
Refer to the weldment figure. There are four welds. Find the safe bending force, F
if the allowable shear stress in the welds is t(allow). Given b = 50mm, c = 150mm,
d = 50mm, h = 5mm, t(allow) = 140MPa.
12.1 kN
11.1 kN
13.1 kN
14.1 kN