Professional Documents
Culture Documents
Truss Hardstanding
Truss Hardstanding
Block of
Prepared by Checked by
JE(QS& C) SW
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
COST AS PER SSR2010= 1220653
Item No. 1
Surface excavation n.exc (not exceeding) 30 cm deep and averaging 15cm deep and getting out all around 3.00 meter fro
Item No. 2
Excavating in trenches, n exc 1.5 m wide and n exc 1.5 m in depth; for foundation, etc. or for shafts, wells,
cesspits, manholes, pier holes, etc. exc 10 sq m on plan and exc 1.5 m in depth and getting out ( soft /
disintegrated rock)
Item No. 3
Excavating in trenches, exc 1.5 m wide and n exc 1.5 m in depth; for foundation, etc. or for shafts, wells, cesspits,
manholes, pier holes, etc. exc 10 sq m on plan and exc 1.5 m in depth and getting out ( soft / disintegrated rock)
unit quantity SI
3006, SSR10 RATE MAR. RATE
cum 90.04 3007 520.30 1031.33
Item No. 4
Plain Cement concrete in foundatons, filling and mass concrete Type D-2 1:4:8 (40 mm graded aggregate) at below
footings of columns retaining wall ect. as lean concrete
Item No. 5
Formwork to sides of concrete foundations, footings, bases of columns, raft and raft beams, sides and soffits (if
any) of foundation and plinth beams; and similar work; vertical or to batter
Page 4 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 6
M,L & Treating the bottom and sides of excavation at the rate of 5 litres of emulsion per square metre of surface
area
Item No. 7
Treating the backfill in contact with foundation at the rate of 7.5 litres of emulsion per square metre of vertical
surface (Area of the sub structure in contact with backfill to be measured)
Page 5 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 8
M,L & Treating the top surface of filled earth at the rate of 5 litres of emulsion per square metre of surface
Item No. 9
RCC M-25 Foundations, including rafts, footings, foundation beams; plinth beams; bases for columns, etc.;
basement slabs, under-reamed piles and mass concrete- M-25 (20mm graded aggregates)
Item No. 10
RCC footing reinforcement as specified-TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips
Total = 440.00
For top and bottom Total = 880.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement used(m)= 0.00 0.00 0.00 1760.00 0.00 0.00
Item No. 11
Form work to side of column up to plinth beam
Item No. 12
RCC M-25 (20mm graded aggregate) in Columns, pillars, piers, posts and struts up to plinth beam
Item No. 13
Reinforcement in column up to plinth beam-TMT steel bars 10mm dia and over, cut to length, bent to shape
required, including cranking, bending spirally for hooping for columns, hooking ends and binding with and
including mild steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 180.00 0.00 0.00 264.60
Item No. 14
Page 8 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Formwork to sides of concrete foundations, footings, bases of columns, raft and raft beams, sides and soffits (if
any) of foundation and plinth beams; and similar work; vertical or to batter in plinth beam
Item No. 15
RCC Foundations, including rafts, footings, foundation beams; plinth beams; bases for columns, etc.; basement
slabs, under-reamed piles and mass concrete- M-25 (20mm graded aggregates) in plinth beam
Item No. 16
Reinforcement in to plinth beam-TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Page 9 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Reinforcement in to plinth beam-TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 259.00 370.35 0.00 0.00 811.76
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 639.73 585.15 0.00 0.00 320.65
Add 3% wastage 0.00 19.19 17.55 0.00 0.00 9.62
total Weight (kg) 0.00 658.92 602.71 0.00 0.00 330.26
Item No. 17
Returning, filling in, including spreading, levelling, watering and well ramming in layers not exc 25 cm.(soft / loose
soil)
Deduction (B)=
pcc 11.40
RCC footing 20.25
RCC column 2.94 total(B)= 45.78 cum
RCC Plinth beam 11.20
(A-B)= 74.46 cum
Bulking % 10.00 7.45 cum
Net Total= 67.01 cum
unit quantity SI SSR10 RATE MAR. RATE Ref M. Rate Analysis M. Folder
cum 67.01 3009 41.70 152.31 Item- 19
Page 10 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 18
sand filling below floors including spreading, levelling, watering and well ramming in layers not exc 25 cm.(soft /
loose soil)
Item No. 19
Walling of square rubble, uncoursed, well bonded built in CM 1:6 below plinth beam etc
Item No. 20
Formwork to sides of pillars, post, struts, piers, columns and stanchions- plinth level to Lintel Level
Page 11 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Formwork to sides of pillars, post, struts, piers, columns and stanchions- plinth level to Lintel Level
Item No. 21
RCC M-25 in RCC in Columns, pillars, piers, posts and struts-plinth level to Lintel Level
Item No. 22
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.Plinth Level to Lintel Level
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 23
Walling of AAC bricks as specified CM 1:6 from- Plinth Level to Lintel Level
Deduction (B)=
S.No. Nos height width length quantity
1 0 1.20 0.20 1.200 0.00 cum 6W2B
2 0 0.60 0.20 0.600 0.00 cum 6V-1C
3 0 1.20 0.20 2.100 0.00 cum RCC JALI
4 0 2.10 0.20 1.20 0.00 cum ALD-5B
5 0 2.10 0.20 0.900 0.00 cum FD-10B
6 0 2.10 0.20 0.70 0.00 cum D-7B
7 0 2.10 0.20 0.70 0.00 cum 0.00
8 0 2.10 0.20 0.80 0.00 cum 0.00
9 0 2.10 0.20 0.00 0.00 cum
Page 13 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 24
Providing precast cement concrete (type 1:2:4 using 16 mm graded aggregate) hollow block 10cm thick in mortar
1:4 complete as specified up Plinth level to Lintel Level
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.600 0.100 0.600 0.00 sqm 6V-1C
2 0 2.100 0.100 0.700 0.00 sqm D-7B
3 0 0.60 0.100 0.000 0.00 sqm
4 0 0.60 0.100 0.000 0.00 sqm
5 0 0.60 0.100 0.000 0.00 sqm
Item No. 25
Formwork to sides of pillars, post, struts, piers, columns and stanchions-Lintel level to Slab Level
Page 14 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 26
RCC M-25 in RCC in Columns, pillars, piers, posts and struts-Lintel level to Slab Level
Item No. 27
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.Lintel level to Slab Level
dia of rein. 25 20 16 12 10 8
Page 15 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 28
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.-Lintel Level to Ground Floor
Roof Level
Item No. 29
RCC M-25 in Beams, cantilevers, bressummers, lintels over 1.5m span-Lintel Level to Ground Floor Roof Level
Page 16 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 31
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays
Pagebetween
17 of 100floors and beams, etc.-in lintel beam at ground
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.-in lintel beam at ground
Item No. 32
RCC M-25 in lintel beam at ground,Beams, cantilevers, bressummers, lintels over 1.5m span
Item No. 33
Reinforcement in lintel beam TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia. Lintel Level to Ground
Floor Levelat ground
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
Page 19 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 34
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.
Item No. 35
RCC M-25 (20 mm graded aggregate) in Roof Slabs supported on walls, beams and columns in floors, roofs,
landings, balconies, canopies, deck slabs and in shelves and the like
Item No. 36
Reinforcement in Roof Slab TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 RS-1 0 8 0.160 8 0.180
long span short span Along short span Along long span beam width continue
4.00 1.85 8 0.160 8 0.180 0.30 0.92
nos short nos long len. Short len. Long total lnth 8 mm dia
26.00 12.00 2.91 5.06 0.00 M 9.61 extra
2 RS-1 0
long span short span Along short span Along long span beam width continue
0.00 0.00 8 0.160 8 0.180 0.30 0.05
nos short nos long len. Short len. Long total lnth 8 mm dia
1.00 1.00 0.62 0.62 0.00 M 0.00 extra
12MM 10MM 8 MM
TOTAL LENGTH 0.00 0.00 0.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 37
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.(Roof Projections)
Item No. 38
RCC M-25 in ground Floor RCC in Beams, cantilevers, bressummers, lintels over 1.5m span (roof projection)
Item No. 39
Reinforcement in Roof Projection- TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 FA1 0
long span short span Along short span Along long span beam width continue
20.20 0.75 10 0.13 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
163.00 5.00 1.46 20.91 0.00 M
total lnth 8 mm dia
0.00 M
2 FA2 0
long span short span Along short span Along long span beam width continue
17.80 0.75 10 0.13 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
144.00 5.00 1.46 18.51 0.00 M
total lnth 8 mm dia
0.00 M
Total
#10 #8
0.00 0.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Page 23 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 40
Formwork to chullah hoods, chajjas, troughs and similar items including edges ground Floor (projection at lintel)
Item No. 41
RCC M-25 with 20mm graded aggregate in chajjas at lintel
S.No. Name Nos thichness width length quantity
Page 24 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 42
Reinforcement in Chajjas at Lintel- TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 ch-1 0
long span short span Along short span Along long span beam width continue
1.50 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
13.00 4.00 1.16 2.21 0.00 M
total lnth 8 mm dia
0.00 M
2 ch-2 0
long span short span Along short span Along long span beam width continue
0.90 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
9.00 4.00 1.16 1.61 0.00 M
total lnth 8 mm dia
0.00 M
3 ch-3 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M
total lnth 8 mm dia
0.00 M
4 ch-4 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M
total lnth 8 mm dia
0.00 M
5 ch-5 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
Page 25 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 43
Walling of AAC bricks as specified from - Lintel Level to Ground Floor Slab
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.00 0.20 1.200 0.00 cum 6W2B
2 0 0.00 0.20 0.600 0.00 cum 6V-1C
3 0 0.00 0.20 2.100 0.00 cum RCC JALI
4 0 0.00 0.20 1.200 0.00 cum ALD-5B
5 0 0.00 0.20 0.900 0.00 cum FD-10B
6 0 1.00 0.20 0.700 0.00 cum D-7B
Total (B)= 0.00 cum
Item No. 44
Providing precast cement concrete (type 1:2:4 using 16 mm graded aggregate) hollow block 10cm thick in mortar
1:4 complete as specified up Plinth level to Lintel Level
Page 26 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.00 0.100 0.600 0.00 sqm
2 0 0.00 0.100 0.700 0.00 sqm
3 0 0.00 0.100 0.000 0.00 sqm
4 0 0.00 0.100 0.000 0.00 sqm
5 0 0.60 0.100 0.000 0.00 sqm
Item No. 45
Formwork to sides of pillars, post, struts, piers, columns and stanchions- F. FLOOR LEVEL TO F.FLOOR LINTEL LEVEL
Item No. 46
Page 27 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
RCC M-25 in RCC in Columns, pillars, piers, posts and struts-F.FLOOR LEVEL TO F.FLOOR LINTEL LEVEL
Item No. 47
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.F.FLOOR LEVEL TO F.FLOOR
LINTEL LEVEL
Item No. 48
Precast cement con-crete (type 1:2:4 using 16 mm graded aggregate) hollow block masonry exc. 10 cm in width
and setting in mortar 1:6 complete as specified at - F.FLOOR LEVEL TO F.FLOOR LINTEL LEVEL
Deduction (B)=
S.No. Nos height width length quantity
1 2 1.20 0.20 1.200 0.58 cum 6W2B
2 0 0.60 0.20 0.600 0.00 cum 6V-1C
3 0 1.20 0.20 2.100 0.00 cum RCC JALI
4 0 2.10 0.20 1.20 0.00 cum ALD-5B
5 1 2.10 0.20 0.900 0.38 cum FD-10B
6 0 2.10 0.20 0.70 0.00 cum D-7B
7 0 2.10 0.20 0.70 0.00 cum 0.00
8 0 2.10 0.20 0.80 0.00 cum 0.00
9 0 2.10 0.20 0.00 0.00 cum
Item No. 49
Providing precast cement concrete (type 1:2:4 using 16 mm graded aggregate) hollow block 10cm thick in mortar
1:4 complete as specified up F.FLOOR LEVEL TO F.FLOOR LINTEL LEVEL
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.600 0.100 0.600 0.00 sqm 6V-1C
Page 29 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 50
Formwork to sides of pillars, post, struts, piers, columns and stanchions- F.FLOOR LINTEL LEVEL TO F.F. SLAB
Item No. 51
RCC M-25 in RCC in Columns, pillars, piers, posts and struts- F.FLOOR LINTEL LEVEL TO F.F. SLAB
Page 30 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 52
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia. F.FLOOR LINTEL LEVEL TO
F.F. SLAB
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 53
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.-F.FLOOR LINTEL LEVEL TO
F.F. SLAB
Page 31 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 54
RCC M-25 in Beams, cantilevers, bressummers, lintels over 1.5m spanF.FLOOR LINTEL LEVEL TO F.F. SLAB
Item No. 55
Reinforcement in Roof Beam TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia. F.FLOOR LINTEL LEVEL TO
F.F. SLAB
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 0.00 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 56
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.-in lintel beam at FIRST
Item No. 57
RCC M-25 in lintel beam at FIRST,Beams, cantilevers, bressummers, lintels over 1.5m span
Item No. 58
Reinforcement in lintel beam TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia. Lintel Level to FIRST Floor
Level
Item No. 59
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.
Page 35 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 60
RCC M-25 (20 mm graded aggregate) in Roof Slabs supported on walls, beams and columns in floors, roofs,
landings, balconies, canopies, deck slabs and in shelves and the like
Item No. 61
Reinforcement in Roof Slab TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 FS-1 0 8 0.160 8 0.170
long span short span Along short span Along long span beam width continue
4.00 1.85 8 0.160 8 0.170 0.30 0.92
Page 36 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
nos short nos long len. Short len. Long total lnth 8 mm dia
26.00 12.00 2.91 5.06 0.00 M 0.00 extra
2 FS-1 0
long span short span Along short span Along long span beam width continue
0.00 0.00 8 0.160 8 0.170 0.30 0.05
nos short nos long len. Short len. Long total lnth 8 mm dia
1.00 1.00 0.62 0.62 0.00 M 0.00 extra
12MM 10MM 8 MM
TOTAL LENGTH 0.00 0.00 0.00
Item No. 62
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.(Roof Projections)
Page 37 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 63
RCC M-25 in FIRST Floor RCC in Beams, cantilevers, bressummers, lintels over 1.5m span (roof projection)
Item No. 64
Reinforcement in Roof Projection- TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 FA1 0
Page 38 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
long span short span Along short span Along long span beam width continue
20.20 0.75 10 0.13 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
163.00 5.00 1.46 20.91 0.00 M
total lnth 8 mm dia
0.00 M
0.00 0.00
2 FA2 0
long span short span Along short span Along long span beam width continue
17.80 0.75 10 0.13 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
144.00 5.00 1.46 18.51 0.00 M
total lnth 8 mm dia
M
Total
#10 #8
0.00 0.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 65
Formwork to chullah hoods, chajjas, troughs and similar items including edges FIRST Floor (projection at lintel)
Page 39 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 66
RCC M-25 with 20mm graded aggregate in chajjas at lintel
S.No. Name Nos thichness width length quantity
Item No. 67
Reinforcement in Chajjas at Lintel- TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 ch-1 0
long span short span Along short span Along long span beam width continue
1.50 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
13.00 4.00 1.16 2.21 0.00 M 0.00
total lnth 8 mm dia
0.00 M 0.00
2 ch-2 0
long span short span Along short span Along long span beam width continue
0.90 0.45 10 0.125 8 0.20 0.30 0.50
Page 40 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
nos short nos long len. Short len. Long total lnth 10 mm dia
9.00 4.00 1.16 1.61 0.00 M
total lnth 8 mm dia
0.00 M
0.00 0.00 0.00
3 ch-3 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M 0.00
total lnth 8 mm dia
0.00 M 0.00
4 ch-4 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M
total lnth 8 mm dia
0.00 M
0.00 0.00
5 ch-5 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M
total lnth 8 mm dia
M
Total
#10 #8
0.00 0.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 0.00 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 68
Precast cement con-crete (type 1:2:4 using 16 mm graded aggregate) hollow block masonry exc. 10 cm in width
and setting in mortar 1:6 complete as specified at - F.FLOOR LINTEL LEVEL TO F.F. SLAB
Deduction (B)=
S.No. Nos height width length quantity
1 2 0.00 0.20 1.200 0.00 cum 6W2B
2 0 0.00 0.20 0.600 0.00 cum 6V-1C
3 0 0.00 0.20 2.100 0.00 cum RCC JALI
4 0 0.00 0.20 1.200 0.00 cum ALD-5B
5 1 0.00 0.20 0.900 0.00 cum FD-10B
6 0 1.00 0.20 0.700 0.00 cum D-7B
Total (B)= 0.00 cum
Item No. 69
Providing precast cement concrete (type 1:2:4 using 16 mm graded aggregate) hollow block 10cm thick in mortar
1:4 complete as specified up F.FLOOR LINTEL LEVEL TO F.F. SLAB
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.00 0.100 0.600 0.00 sqm
2 0 0.00 0.100 0.700 0.00 sqm
3 0 0.00 0.100 0.000 0.00 sqm
4 0 0.00 0.100 0.000 0.00 sqm
5 0 0.60 0.100 0.000 0.00 sqm
Page 42 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 70
Formwork to sides of pillars, post, struts, piers, columns and stanchions- S. FLOOR LEVEL TO S.FLOOR LINTEL LEVEL
Item No. 71
RCC M-25 in RCC in Columns, pillars, piers, posts and struts-S. FLOOR LEVEL TO S.FLOOR LINTEL LEVEL
Item No. 72
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns,Page
hooking
43 ofends
100 and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.S. FLOOR LEVEL TO
S.FLOOR LINTEL LEVEL
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.S. FLOOR LEVEL TO
S.FLOOR LINTEL LEVEL
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 73
Precast cement con-crete (type 1:2:4 using 16 mm graded aggregate) hollow block masonry exc. 10 cm in width
and setting in mortar 1:6 complete as specified at - S. FLOOR LEVEL TO S.FLOOR LINTEL LEVEL
Deduction (B)=
S.No. Nos height width length quantity
1 0 1.20 0.20 1.200 0.00 cum 6W2B
2 0 0.60 0.20 0.600 0.00 cum 6V-1C
3 0 1.20 0.20 2.100 0.00 cum RCC JALI
4 0 2.10 0.20 1.20 0.00 cum ALD-5B
5 0 2.10 0.20 0.900 0.00 cum FD-10B
6 0 2.10 0.20 0.70 0.00 cum D-7B
7 0 2.10 0.20 0.70 0.00 cum 0.00
8 0 2.10 0.20 0.80 0.00 cum 0.00
Page 44 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 74
Providing precast cement concrete (type 1:2:4 using 16 mm graded aggregate) hollow block 10cm thick in mortar
1:4 complete as specified up S. FLOOR LEVEL TO S.FLOOR LINTEL LEVEL
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.600 0.100 0.600 0.00 sqm 6V-1C
2 0 2.100 0.100 0.700 0.00 sqm D-7B
3 0 0.60 0.100 0.000 0.00 sqm
4 0 0.60 0.100 0.000 0.00 sqm
5 0 0.60 0.100 0.000 0.00 sqm
Item No. 75
Formwork to sides of pillars, post, struts, piers, columns and stanchions-Lintel level to Slab Level
Item No. 76
RCC M-25 in RCC in Columns, pillars, piers, posts and struts-Lintel level to Slab Level
Item No. 77
Reinforcement in column TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.Lintel level to Slab Level
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 64.00 0.00 0.00 189.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 101.12 0.00 0.00 74.66
Add 3% wastage 0.00 0.00 3.03 0.00 0.00 2.24
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 78
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.-Lintel Level to Second Floor
Roof Level
Item No. 79
RCC M-25 in Beams, cantilevers, bressummers, lintels over 1.5m span-Lintel Level to SECOND Floor Roof Level
Item No. 80
Reinforcement in Roof Beam TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia. Lintel Level to SECOND
Floor Level
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Page 48 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 81
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.-in lintel beam at SECOND
FLOOR
Item No. 82
RCC M-25 in lintel beam at second ,Beams, cantilevers, bressummers, lintels over 1.5m span
Item No. 83
Reinforcement in lintel beam TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia. Lintel Level to SECOND
Floor Levelat SECOND
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
Page 50 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 84
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.
Item No. 85
RCC M-25 (20 mm graded aggregate) in Roof Slabs supported on walls, beams and columns in floors, roofs,
landings, balconies, canopies, deck slabs and in shelves and the like
Item No. 86
Reinforcement in Roof Slab TMT steel bars 10mm dia and over, cut to length, bent to shape required, including
cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild steel wire
(annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 RS-1 2 8 0.160 8 0.170
long span short span Along short span Along long span beam width continue
4.00 2.40 8 0.160 8 0.170 0.30 1.01
nos short nos long len. Short len. Long total lnth 8 mm dia
26.00 16.00 3.50 5.10 345.41 M 42.73 extra
2 RS-2 0
long span short span Along short span Along long span beam width continue
1.50 1.10 8 0.160 8 0.170 0.30 0.44
nos short nos long len. Short len. Long total lnth 8 mm dia
11.00 8.00 1.92 2.32 0.00 M 0.00 extra
12MM 10MM 8 MM
TOTAL LENGTH 0.00 0.00 0.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 87
Formwork to sides and soffits of floor or roof beams, beam haunchings, girders, bressummers, lintels, cantilevers,
shelves including supports, overhangs, etc. also splays between floors and beams, etc.(Roof Projections)
Item No. 88
RCC M-25 in second Floor RCC in Beams, cantilevers, bressummers, lintels over 1.5m span (roof projection)
Page 53 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 89
Reinforcement in Roof Projection- TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 FA1 2
long span short span Along short span Along long span beam width continue
20.20 0.75 10 0.10 8 0.18 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
203.00 6.00 1.46 20.91 590.73 M
total lnth 8 mm dia
250.86 M
2 FA2 2
long span short span Along short span Along long span beam width continue
17.80 0.75 10 0.13 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
144.00 5.00 1.46 18.51 419.04 M
total lnth 8 mm dia
185.05 M
Total
#10 #8
1010.00 436.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Page 54 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 90
Formwork to chullah hoods, chajjas, troughs and similar items including edges SECOND Floor (projection at lintel)
Item No. 91
RCC M-25 with 20mm graded aggregate in chajjas at lintel
S.No. Name Nos thichness width length quantity
Page 55 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 92
Reinforcement in Chajjas at Lintel- TMT steel bars 10mm dia and over, cut to length, bent to shape required,
including cranking, bending spirally for hooping for columns, hooking ends and binding with and including mild
steel wire (annealed) not less than 0.9mm dia or securing with clips + Ditto, but 6mm to 8mm dia.
Quantity of reinforcement
1 ch-1 0
long span short span Along short span Along long span beam width continue
1.50 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
13.00 4.00 1.16 2.21 0.00 M 0.00
0.00 0.00 0.00 0.00 total lnth 8 mm dia
0.00 0.00 0.00 0.00 0.00 M
2 ch-2 0
long span short span Along short span Along long span beam width continue
0.90 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
9.00 4.00 1.16 1.61 0.00 M 0.00
total lnth 8 mm dia
0.00 M 0.00
3 ch-3 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M 0.00
total lnth 8 mm dia
0.00 M
0.00
4 ch-4 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M 0.00
total lnth 8 mm dia
0.00 M 0.00
Page 56 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
5 ch-5 0
long span short span Along short span Along long span beam width continue
0.00 0.45 10 0.125 8 0.20 0.30 0.50
nos short nos long len. Short len. Long total lnth 10 mm dia
1.00 4.00 1.16 0.71 0.00 M 0.00
total lnth 8 mm dia
M 0.00
Total
#10 #8
0.00 0.00
dia of rein. 25 20 16 12 10 8
Now total reinforcement (m)= 0.00 0.00 0.00 0.00 0.00 0.00
unit weight in kg 3.850 2.470 1.580 0.888 0.617 0.395
weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Add 3% wastage 0.00 0.00 0.00 0.00 0.00 0.00
total Weight (kg) 0.00 0.00 0.00 0.00 0.00 0.00
Item No. 93
Precast cement con-crete (type 1:2:4 using 16 mm graded aggregate) hollow block masonry exc. 10 cm in width
and setting in mortar 1:6 complete as specified at - S.F Level to Lintel Level
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.00 0.20 1.200 0.00 cum 6W2B
2 0 0.00 0.20 0.600 0.00 cum 6V-1C
3 0 0.00 0.20 2.100 0.00 cum RCC JALI
4 0 0.00 0.20 1.200 0.00 cum ALD-5B
5 0 0.00 0.20 0.900 0.00 cum FD-10B
6 0 1.00 0.20 0.700 0.00 cum D-7B
Total (B)= 0.00 cum
Item No. 94
Page 57 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Providing precast cement concrete (type 1:2:4 using 16 mm graded aggregate) hollow block 10cm thick in mortar
1:4 complete as specified up S.F level to Lintel Level
Deduction (B)=
S.No. Nos height width length quantity
1 0 0.00 0.100 0.600 0.00 sqm
2 0 0.00 0.100 0.700 0.00 sqm
3 0 0.00 0.100 0.000 0.00 sqm
4 0 0.00 0.100 0.000 0.00 sqm
5 0 0.60 0.100 0.000 0.00 sqm
0 0 0.00 0.00 0.000 0.00
Total (B)= 0.00 sqm
Item No. 95
S&F Rolled mild steel in hollow tube,pipes,angle,plates (plain or chequered) channels, square cut or notched
(ordinary or counter sunk) forming holes without any attachment confirming to FE-410W (Gde E-250 quality 'A'
complete all as specified and directed.
NO OF
S.No. NAME NOS MEMBER LENGTH THICKNESS QUANTITY TOTAL UNIT WEIGHT
PER TRUSS/ IN M IN MM WEIGHT
Column
COLUMNS-
a ISMC-125 10 2.00 5.20 na 104.00 1362.40 13.10
5 1.00 13.250 3.30 66.25 473.03 7.14
5 2.00 7.00 3.30 69.97 499.59 7.14
TUBE
b 70X70X3.3
0 0.00 0.00 3.65 0.00 0.00 7.14
0 2.00 4.99 3.65 0.00 0.00 7.14
TUBE
c 40X40X2.6 5 2.00 9.15 3.65 91.48 289.08 3.16
Page 58 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
PURLIN
d TUBE
70X70X3.3 12 1.00 18.824 3.65 225.89 1612.84 7.14
CLEAT ANGLE 5 12.00 0.05 6.00 3.00 10.50 3.50
e 40X40X6 5 4.00 0.15 0.01 3.00 10.50 3.50
NO OF
S.No. NAME NOS MEMBER LENGTH THICKNESS QUANTITY TOTAL UNIT WEIGHT/CUM
PER TRUSS/ IN M IN MM WEIGHT
Column
f GUSSET PLATE 8
MM TH. 5 8.00 0.0075 0.30 18.85 7854.00
g BASE PLATES 10
MM TH. 5 4.00 0.203 4.05 318.09 7854.00
h BASE PLATES 10
MM TH. 5 4.00 0.090 1.80 141.37 7855.00
i PLATES 6 MM
TH. For ISMC125 10 26.00 0.004 1.09 51.46 7854.00
Total = 4890.86 KG
Item No. 96
Galvanised, corrugated mild steel sheeting with two corrugations side lap, fixed with coach screws and
washers, in roofs, walls etc. with grade of zinc coating 275. ®
NO AREA QTY
G.I CORRUGATED SHEET
22 GAUGE
1 NA 252.00 252.00 sqm
11002
11003
sqm 252.00 436.20 640.93
Page 59 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Item No. 97
windows as specified
S.No. name Nos height width quantity
1 6W2B 0 1.20 1.20 0.00 sqm
2 6V-1C 0 0.60 0.60 0.00 sqm
3 RCC JALI 0 1.20 2.10 0.00 sqm
4 ALD-5B 0 2.10 1.20 0.00 sqm
Item No. 98
doors as specified
Item No. 99
Rendering 15mm thick on fair faces of brick work or concrete surfaces in finished even and smooth (without using
extra lime or cement) C.M 1:6-Internal
place Nos Length Width height Qty
PARKING SHED
FOR SPECIALIZES
VEHICLE
1 17.20 10.57 5.20 288.81 sqm G.FLOOR
PARKING SHED
FOR SPECIALIZES
VEHICLE
Page 62 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
Ceiling
PARKING SHED
FOR SPECIALIZES
VEHICLE
1 0 17.20 10.57 5.20 0.00 sqm G.FLOOR
2 RAMP 0 12.00 2.00 0.00 0.00 sqm G.FLOOR
3 TOILET 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
4 STEPS 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
5 STEPS 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
6 TECH ROOM 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
7 VERENDAH 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
8 STAIRCASE 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
0.00
unit quantity SI SSR10 RATE MAR. RATE
15002,
sqm 0.00 15007
12.70 30.60
Page 63 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
THREE COATS OF WHITE WASHING INCLUDING PREPARATION OF NEWLY PLASTERED SURFACES. (Wall)
PARKING SHED
FOR SPECIALIZES
VEHICLE
1 17.20 10.57 5.20 288.81 sqm G.FLOOR
RAMP 0 12.00 2.00 0.00 0.00 sqm G.FLOOR
TOILET 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
STEPS 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
STEPS 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
TECH ROOM 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
VERENDAH 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
STAIRCASE 0 0.00 0.00 0.00 0.00 sqm G.FLOOR
Stage - XI : Flooring
PARKING SHED
FOR SPECIALIZES
VEHICLE
0 17.20 10.57 5.20 0.00 sqm
RAMP 0 12.00 2.00 0.00 0.00 sqm
TOILET 0 0.00 0.00 0.00 0.00 sqm
STEPS 0 0.00 0.00 0.00 0.00 sqm
STEPS 0 0.00 0.00 0.00 0.00 sqm
TECH ROOM 0 0.00 0.00 0.00 0.00 sqm
VERENDAH 0 0.00 0.00 0.00 0.00 sqm
STAIRCASE 0 0.00 0.00 0.00 0.00 sqm
Page 64 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
14001,
sqm 0.00 13080
739.60 1083.99
13079
Page 65 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
MACHINE CUT KOTA STONE 12 TO 15MM TH AND SIZE NOT LESS THAN 550X100MM SHALL BE FIXED WITH NEAT
CEMENT SLURRY OVER BACKING COAT OF 10MM TH IN CM 1:3
Item No. 107
PARKING SHED
FOR SPECIALIZES
VEHICLE
1 17.20 10.57 0.10 5.55 sqm
RAMP 0 12.00 2.00 0.10 0.00 sqm
TOILET 0 0.00 0.00 0.10 0.00 sqm
STEPS 0 0.00 0.00 0.10 0.00 sqm
STEPS 0 0.00 0.00 0.10 0.00 sqm
TECH ROOM 0 0.00 0.00 0.10 0.00 sqm
VERENDAH 0 0.00 0.00 0.10 0.00 sqm
STAIRCASE 0 0.00 0.00 0.10 0.00 sqm
Page 66 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
MIRROR POLISHED KOTA STONE SLAB SIZE NOT LESS THAN (550X450MM) AND 20 TO 25MM TH LAID OVER 20MM
TH BEDDING LAYER IN CM 1:3 OVER 75MM TH PCC (1:4:8) TYPE D2 USING 40MM GRADED STONE AGGREGATE
OVER RAMMED EARTH
PARKING SHED
FOR SPECIALIZES
VEHICLE
1 17.20 10.57 5.20 181.80 sqm
RAMP 0 12.00 2.00 0.00 0.00 sqm
TOILET 0 0.00 0.00 0.00 0.00 sqm
STEPS 0 0.00 0.00 0.00 0.00 sqm
STEPS 0 0.00 0.00 0.00 0.00 sqm
TECH ROOM 0 0.00 0.00 0.00 0.00 sqm
VERENDAH 0 0.00 0.00 0.00 0.00 sqm
STAIRCASE 0 0.00 0.00 0.00 0.00 sqm
Page 67 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
PARKING SHED
FOR SPECIALIZES
VEHICLE
2 URINAL 0 0.00 no
3 WC 0 0.00 no
4 NT 0 0.00 no
5 TOWEL RAIL 600 MM 0 0.00 no
6 TAP 0 0.00 no
7 SP, WWP 0 0.00 no
8 Toilet Paper Holder 0 0.00 no
9 OHT-500 ltrs 0 500 ltrs 0.00 no
10 OHT-1000 ltrs 0 1000 ltrs 0.00 no
Page 69 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
Estimate of Quantities for Block of
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
S.No. quantity
1 0.00 sqm
Total = 0.00 sqm
11068,
sqm 0.00 14001 etc
369.90 507.41
Page 71 of 100
Estimate of Quantities for Block of
PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU AF AT 33 SU,AF
JODHPUR
Sl No. Description of Material SSR No. Unit Quantity At SSR 2010 At Market
Rate Amount Rate Amount
1 TMT REINFORCEMENT 10110 KG 3782.36 41.1 155455 40 151294
2 BINDING WIRE IN KG 10114 KG 37.82 56 2118 55 2080
3 CEMENT IN BAGS 4098 BAGS 533.00 270.3 144070 270 143910
4 SAND 4095 CUM 54.08 646.3 34952 470 25417
5 COARSE AGGREGATE 40 mm 4093 CUM 45.69 587.5 26845 800 36555
6 COARSE AGGREGATE 20 mm 4093 CUM 23.68 646.3 15307 800 18947
7 COARSE AGGREGATE 12.5 mm 4093 CUM 10.32 675 6964 800 8253
8 COARSE AGGREGATE 63 mm 4093 CUM 0.00 587.5 0 800 0
9 STONE IN CUM 6001 CUM 9.25 600 5552 1700 15730
10 BLOCKS IN NOS FOR 200 MM WALL 4031 NOS 0.00 46 0 38 0
11 BLOCKS IN NOS FOR 100 MM WALL 4038 NOS 0.00 34 0 22 0
CHLORPHYROPHOSE
12 IN LTR 3063 LTR 148.93 305.5 45497 280 41700
13 WPC IN LTR 4100 LTR 70.79 193.9 13726 220 15574
14 CEMENT PAINT IN KG 15018 KG 108.24 49.4 5347 49.4 5347
LIME
15 IN KG 4097 KG 80.87 4.47 361 12.9 1043
GLUE
16 IN KG 7117 KG 0.20 95 19 95 19
17 ULTRAMARINE BLUE IN KG Assd KG 0.23 2000 462 2000 462
18 SODIUM CHLORIDE IN KG Assd KG 10.54 4 42 4 42
19 NON-SKID COLOUR CERAMIC TILE 300X300 IN SQM 13155 SQM 0.00 261.11 0 500 0
20
GLAZED COLOUR CERAMIC TILE 300X200 IN SQM 13080 SQM 0.00 592.3 0 350 0
21 VITRIFIED TILE IN SQM 13086 SQM 0.00 813.9 0 430 0
22 WHITE CEMENT IN KG Assd KG 0.00 15 0 15 0
23 KOTA STONE IN SQM 13013 SQM 196.73 316.1 62185 300 59018
24 POLISH,TUPETINE OIL,DETERGENT ETC Assd SQM 187.36 95 17799 95 17799
SEALING COMPOUND
25 IN RMT 20084 RMT 248.10 23.82 5910 23.82 5910
26 MEMBRANE SHEET IN SQM 11068 SQM 0.00 171.8 0 185 0
27 BITUMIN PRIMER IN KG 13135 KG 0.00 47 0 54 0
LPG FUEL& MISC SUNDRIES
28 IN KG Assd KG 0.00 35 0 35 0
29 WINDOWS-RS 3500 per sqm Assd SQM 0.00 1721 0 1721 0
30 DOORS-Rs 3500 per sqm Assd SQM 0.00 1721 0 1721 0
31 PLUMBING SANITARY AMOUNT Assd LS 0 65% 0 65% 0
32 HIGHER CHARGES FOR MISC. MACHINARY IN
CONCRETE Assd CUM 45.78 24 1099 24 1099
33 SITE CLEARENCE, RCC JALI ETC 2% OF ALL MATERIAL
AMOUNT Assd LS 2% 10874 2% 11004
34 ROOLED STEEL SECTIONS 10046 KG 4890.86 44.10 215687 42.00 205416
35 G.I CORRUGATED SHEET 22 GAUGE
11002
11003
sqm 252.00 355.90 89687 435 109620
Page 72 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
MATERIAL REQUIREMENT FOR
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU AF
AT 33 SU,AF JODHPUR
ULTRAMARINE BLUE IN
12.5 63
SEALING COMPOUND
OIL,DETERGENT ETC
CHLORPHYROPHOSE
BINDING WIRE @ 1%
SODIUM CHLORIDE
NON-SKID COLOUR
Sand 40mm 20mm
MEMBRANE SHEET
POLISH,TUPETINE
REINFORCEMENT
WHITE CEMENT
VITRIFIED TILE
CEMENT PAINT
CEMENT IN KG
CERAMICTILE
GLAZED TILE
SUNDRIES
BLOCKS
BLOCKS
IN SQM
IN SQM
IN SQM
IN CUM
IN SQM
STONE
IN RMT
IN LTR
IN LTR
IN KG
IN KG
IN KG
WALL
WALL
IN KG
IN KG
IN KG
GLUE
LIME
QTY.
UNIT
WPC
KG
AGGREGATES IN CUM
THREE COATS OF WHITE WASHING (WALL) 289 sqm 81 0.20 0.23 10.5
Page 73 of 100
PARKING SHED FOR SPECIALIZES VEHICLE
MATERIAL REQUIREMENT FOR
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU AF
AT 33 SU,AF JODHPUR
ULTRAMARINE BLUE IN
12.5 63
SEALING COMPOUND
OIL,DETERGENT ETC
CHLORPHYROPHOSE
BINDING WIRE @ 1%
SODIUM CHLORIDE
NON-SKID COLOUR
Sand 40mm 20mm
MEMBRANE SHEET
POLISH,TUPETINE
REINFORCEMENT
WHITE CEMENT
VITRIFIED TILE
CEMENT PAINT
CEMENT IN KG
CERAMICTILE
GLAZED TILE
SUNDRIES
BLOCKS
BLOCKS
IN SQM
IN SQM
IN SQM
IN CUM
IN SQM
STONE
IN RMT
IN LTR
IN LTR
IN KG
IN KG
IN KG
WALL
WALL
IN KG
IN KG
IN KG
GLUE
LIME
QTY.
UNIT
WPC
KG
AGGREGATES IN CUM
WHB no
URINAL no
WC no
NT no
TOWEL RAIL 600 MM no
TAP no
SP, WWP no
Toilet Paper Holder no
OHT-500 ltrs no
OHT-1000 ltrs no
PCC
RCC floor 100 mm
Slab With Appth. B1 over
based 150 th PCC D2
polymeric
over rammed
membrane earth weighing 3kg/sqm and
minimum 62 sqm 3435 7.13 8.87 5.46 248.1
minimum 3mm thick reinforcedas specified
.
0 sqm 0 0.00 0 0 0
Page 74 of 100
MARKET ANALYSIS FOR SCH 'A' ITEM NO 2 PARKING SHED FOR SPECIALIZES VEHICLE
AS PER APPENDIX-`H’ TO CONTRACT MANUAL
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION
OF ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
COST OF MATERIAL FOR FORM WORK AS PAR SSR AND MARKET RATE Annexure-III
1 FOOTINGS/PB
A MATERIAL
Plate
Props 191.50
Sundries nuts and bolts
B LABOUR
Carpenter 225 700 0.13 29.25 91.00
Mazdoor 169 350 0.13 21.97 45.50
A+B 51.22 136.50
2 SLABS
A MATERIAL
Plate
Props
Channel (Telescopic)
Sundries nuts and bolts 191.50
B LABOUR
Carpenter 225 700.00 0.23 51.75 161.00
Mazdoor 169 300.00 0.20 33.80 60.00
A+B 85.55 221.00
3 BEAMS
A MATERIAL
Plate
Props
Channel
191.50
Sundries nuts and bolts 191.50
B LABOUR
Carpenter 225 700.00 0.30 67.50 210.00
Mazdoor 169 350.00 0.20 33.80 70.00
A+B 101.30 280.00
4 COLUMNS
A MATERIAL
Plate
Props
Channel
Sundries nuts and bolts 191.50
B LABOUR
Carpenter 225 700.00 0.25 56.25 175.00
Mazdoor 169 350.00 0.20 33.80 70.00
A+B 90.05 245.00
5 WALL
A MATERIAL
Plate
Props
Channel
Sundries nuts and bolts 191.50
B LABOUR
Carpenter 225 700.00 0.25 56.25 175.00
Mazdoor 169 350.00 0.20 33.80 70.00
A+B 90.05 245.00
7 STAIRCASE
A MATERIAL
Plate
Props
Channel (Telescopic)
Sundries nuts and bolts 191.50
B LABOUR
Carpenter 225 700.00 0.23 51.75 161.00
Mazdoor 169 350.00 0.20 33.80 70.00
A+B 85.55 231.00
PARKING SHED FOR SPECIALIZES VEHICLE
MARKET ANALYSIS FOR SCH 'A' ITEM NO 2
UNSKILLED
7 Mazdoor (Male) 1016 169.00 171751 350.00 355696
8 Mazdoor ( Female) 0 169.00 0 300.00 0
LABOUR ON ITEMS TAKEN ON ASSESD RATES
9 Windows 0 927 0 927 0
10 Doors 0 927 0 927 0
11 Plumbing & Sanitary 0 35% 0 35% 0
12 Misc. labour for RCC chajja etc
LS 2% 5060 2% 11988
Total 258035 611394
PROVN OF WATCH
Estimate TOWERCUM
of Quantities for Block GUARD REST
of WATCH ROOM
TOWER ATGUARD
CUM AF STNREST
(MANDORE)
ROOM (A) JODHPUR
Fitter/Welder
Fitter/Welder
Blacksmith
Blacksmith
Carpentar
Carpentar
Wall Tiler
Wall Tiler
Mason -II
Plasterer
Plasterer
Mason -I
Majdoor
Majdoor
S.
Painter
Painter
Mason
Floor/
Floor/
coolie
coolie
No. Description of Item Unit Qty.
1 Surface excavation sqm 461.75 0.08 0.00 0.00 0.00 0.00 0.00 0.00 0.00 36.94 0.00
2 Excavating in trenches, n exc 1.5 m wide and n exc 1.5 cum 30.20 2.19 0.00 0.00 0.00 0.00 0.00 0.00 0.00 66.14 0.00
m in depth;in( trenches,
Excavating soft / disintegrated
exc 1.5 m rock)
wide and n exc 1.5 m
3 cum 90.04 2.37 0.00 0.00 0.00 0.00 0.00 0.00 0.00 213.39 0.00
in depth; ( soft / disintegrated rock)
4 Cement concrete in foundatons, filling and mass cum 11.40 0.10 1.73 1.14 0.00 0.00 0.00 0.00 0.00 0.00 19.71 0.00
M,L & Treating
concrete the 1:4:8
Type D-2 bottom and sides of excavation at
5 the rate of 5 litres of emulsion per square metre of sqm 113.96 0.03 0.00 0.00 0.00 0.00 0.00 0.00 0.00 3.42 0.00
surface
Treatingarea
the backfill at the rate of 7.5 litres of emulsion
6 sqm 192.70 0.03 0.00 0.00 0.00 0.00 0.00 0.00 0.00 5.78 0.00
per
M,L square
& Treating the top surface of filled earth at the rate
7 sqm 192.70 0.03 0.00 0.00 0.00 0.00 0.00 0.00 0.00 5.78 0.00
of 5 litres of emulsion per square metre of surface
RCC M-25 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
8 RCC M-25 Foundations cum 20.25 0.17 2.30 3.44 0.00 0.00 0.00 0.00 0.00 0.00 46.58 0.00
9 RCC M-25 Columns cum 2.94 0.23 3.80 0.68 0.00 0.00 0.00 0.00 0.00 0.00 11.16 0.00
10 RCC M-25 Plinth Beams cum 11.20 0.17 2.30 1.90 0.00 0.00 0.00 0.00 0.00 0.00 25.76 0.00
11 RCC M-25 Roof Beams cum 0.00 0.20 3.30 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
12 RCC M-25 Slabs cum 0.00 0.17 2.30 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
13 RCC M-25 in lintals- lintal bands cum 0.00 0.20 3.30 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
14 RCC M-25 in chajjs, Facias, drops, cum 0.00 0.20 3.30 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
15 RCC M-25 in Slabs - Stair cum 0.00 0.17 2.30 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Form Work 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
16 Formwork Foundations sqm 36.00 0.13 0.13 0.00 4.68 0.00 0.00 0.00 0.00 0.00 4.68 0.00
17 Formwork Columns sqm 26.10 0.25 0.20 0.00 6.53 0.00 0.00 0.00 0.00 0.00 5.22 0.00
18 Formwork Plinth Beams sqm 74.68 0.13 0.13 0.00 9.71 0.00 0.00 0.00 0.00 0.00 9.71 0.00
19 Formwork Roof Beams sqm 0.00 0.13 0.13 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
20 Formwork Slabs sqm 0.00 0.23 0.20 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
21 Formwork in lintals- lintal bands sqm 0.00 0.13 0.13 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
22 Formwork in chajjs, Facias, drops, sqm 0.00 0.45 0.40 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
23 Formwork in Slabs - Stair sqm 0.00 0.23 0.20 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
24 TMT Reinforcement Bar 10 mm dia and above (kg) 3164.33 0.006 0.006 0.00 0.00 19.94 0.00 0.00 0.00 0.00 19.94 0.00
25 TMT Reinforcement Bar 8 mm dia (kg) 437.92 0.006 0.006 0.00 0.00 2.76 0.00 0.00 0.00 0.00 2.76 0.00
26 Returning, filling in, cum 67.01 0.35 0.00 0.00 0.00 0.00 0.00 0.00 0.00 23.45 0.00
27 sand filling below floors cum 62.93 0.35 0.00 0.00 0.00 0.00 0.00 0.00 0.00 22.02 0.00
28 Walling of square rubble below plinth beam etc cum 8.41 0.60 1.62 5.05 0.00 0.00 0.00 0.00 0.00 0.00 13.63 0.00
Precast cement con-crete hollow block masonry exc. 10
29 cm in width cum 0.00 1.32 1.80 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
30 Providing precast cement concrete hollow block 10cm sqm 0.00 0.22 0.32 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
thick
Page 78 of 100
PROVN OF WATCH
Estimate TOWERCUM
of Quantities for Block GUARD REST
of WATCH ROOM
TOWER ATGUARD
CUM AF STNREST
(MANDORE)
ROOM (A) JODHPUR
Fitter/Welder
Fitter/Welder
Blacksmith
Blacksmith
Carpentar
Carpentar
Wall Tiler
Wall Tiler
Mason -II
Plasterer
Plasterer
Mason -I
Majdoor
Majdoor
S.
Painter
Painter
Mason
Floor/
Floor/
coolie
coolie
No. Description of Item Unit Qty.
Fitter/Welder
Fitter/Welder
Blacksmith
Blacksmith
Carpentar
Carpentar
Wall Tiler
Wall Tiler
Mason -II
Plasterer
Plasterer
Mason -I
Majdoor
Majdoor
S.
Painter
Painter
Mason
Floor/
Floor/
coolie
coolie
No. Description of Item Unit Qty.
Misc Items 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
49 Site clearance, Enamel Paint of truss etc. L.S. 0.00 0.00 0.00 0.00 0.01 0.00 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00
Total Stage of (I to XV) 3.99 1.68 0.10 0.10 2.57 0.22 40.35 0.00 20 21 65 78 22 118 47 1016 0
Page 80 of 100
Abstract of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
SSR
S.
No. Description of Item Unit Qty. SI 2010 Amount
Rates
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
SSR
S.
No. Description of Item Unit Qty. SI 2010 Amount
Rates
26 Returning, filling in, cum 67.01 3009 41.70 2794
27 sand filling below floors cum 62.93 3009 41.70 2624
Walling of square rubble below plinth beam
28 etc cum 8.41 6014 1976.40 16625
Precast cement con-crete hollow block
29
masonry exc. 10 cm in width cum 0.00 5019 2392.40 0
Providing precast cement concrete hollow
30
block 10cm thick sqm 0.00 4038 422.10 0
S&F Rolled mild steel in hollow tube, pipes,
31 angle,plates (plain or chequered) channels,
square cut or notched
KG 4890.86 10046 62.70 306657
11002
32 Corrugted Sheet 11003
sqm 252.00 436.20 109922
33 windows as specified sqm 0.00 M.R. 3500.00 0
34 doors as specified sqm 0.00 M.R. 3500.00 0
Plaster
Rendering 15mm thick on fair faces of brick 14002,
35 work or concrete surfaces 14004
sqm 288.81 14005 126.60 36563
Page 82 of 100
Abstract of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF
ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
SSR
S.
No. Description of Item Unit Qty. SI 2010 Amount
Rates
Mirror polished kota stone slab with mortar 13013,
45
bedding sqm 0.00 14009 673.10 0
46 Sainitary Fitting & Fixtures
WHB nos 0.00 mr 2500 0
URINAL nos 0.00 mr 2000 0
WC nos 0.00 mr 3500 0
NT nos 0.00 mr 450 0
TOWEL RAIL 600 MM nos 0.00 mr 500 0
TAP nos 0.00 mr 350 0
SP, WWP nos 0.00 mr 450 0
Toilet Paper Holder nos 0.00 mr 500 0
OHT-500 ltrs nos 0.00 mr 3000 0
OHT-1000 ltrs nos 0.00 mr 6000 0
Plinth Protection to building
47 PCC floor 100 mm th. B1 over 150 th PCC D2 13033,
over rammed earth sqm 62.03 13035 643.30 39901
Roof Treatment
RCC Slab With App based polymeric
membrane minimum weighing 3kg/sqm and
48 minimum 3mm thick reinforcedas specified
11068,
. sqm 0.00 14001 etc 369.90 0
Misc Items
Site clearance, Enamel Paint of truss etc.
49
L.S. 1196718.23 NA 2% 23934
Page 83 of 100
Abstract of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION
OF ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
SSR
S. Description of Item Unit Qty. SI 2010 Amount Market Market
No. Rate Amount
Rates
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION
OF ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
SSR
S. Description of Item Unit Qty. SI 2010 Amount Market Market
No. Rate Amount
Rates
Rendering 5 mm thick in CM 1:4 using WPC@
37 3% over 10 mm thick cement plaster in CM 14001,
1:6-OUTER sqm 270.60 14004-05 157.10 42511 320.69 86779
Paint 0.00 0
Page 85 of 100
Abstract of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION
OF ROHINI AT 315 TRU AF AT 33 SU,AF JODHPUR
SSR
S. Description of Item Unit Qty. SI 2010 Amount Market Market
No. Rate Amount
Rates
Page 86 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 87 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 88 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 89 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 90 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 91 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 92 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 94 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 95 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 96 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 97 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
Page 98 of 100
Yardstic of Quantities for Block of PARKING SHED FOR SPECIALIZES VEHICLE
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR
PROVN OF HARD STANDING ,PARKING SHEDS CERTAIN TECH TECH AND STORES FOR INDUCTION OF ROHINI AT 315 TRU
AF AT 33 SU,AF JODHPUR