Professional Documents
Culture Documents
Atgl / 275GL /GL+
Atgl / 275GL /GL+
The purpose of this bulletin is to inform the field NOTE: P/N 295389G O-rings are ink-stamped in
of new igniter sleeve lower O-rings available for white with “INNIO 295389G.”
AT27GL/275GL and GL+ engines. The new O-rings
To install the new igniter sleeve upper and lower
(P/N 295389G) can replace the current O-rings
O-rings:
(P/N 295389C) for service use only (see Figure 1).
The current igniter sleeve lower O-rings can 1. Remove the igniter sleeve from the cylinder
deteriorate due to inadequate sealing of the head as described in the appropriate INNIO
admission valve connector, causing coolant Waukesha gas engine Repair & Overhaul
leakage into the cylinder sleeve (see latest manual.
edition of Service Bulletin 9-2947 for admission
valve installation). The new lower O-rings are 2. Remove the two igniter sleeve lower and two
upper O-rings and discard them.
capable of withstanding higher than normal
operating temperature of the engine. 3. Thoroughly clean the igniter sleeve grooves
and igniter sleeve cylinder head bore.
4. Lubricate the four O-rings using Parker
1
Super-O-Lube.
5. Install the four O-rings on the igniter sleeve
(see Figure 1).
6. Install the igniter sleeve as described in the
appropriate INNIO Waukesha gas engine
Repair & Overhaul manual.
04/24/2015
Copyright © 2015, INNIO Waukesha Gas Engines, Inc. Page 1 of 1