Professional Documents
Culture Documents
Balcony Noise Attenuation Using Formboard Top Pine Panels
Balcony Noise Attenuation Using Formboard Top Pine Panels
General Information
Individual panel segmentation within the following design size:
The smaller dimension of the finished parts must not exceed 1300 mm,
if coating is required.
Our Formboard top pine® panel is a high-density fibreboard bonded with polyurethane. The
material is moisture-resistant and it therefore suitable for external applications.
The panels are laser-cut to exact dimensions and coated in any desired RAL/NCS S colour. The
panels are available in 10 and 18 mm thickness.
1
Important Storage/Sorting Note
Formboard top pine® panels must never be stored outside in unprotected flat/horizontal
position during sorting. Paint damage may occur, if water remains on the panels in a horizontal
position! Please store in a protected location and always place the supplied, dry PU-foam
foils between the individual panels.
2
Design Notes
Fixing distances
Fixing distances
The diameter of the drill holes is usually 6 mm. The panels are fixed by means of
“façade screws with truss head”, diameter 4.8 mm, supplied by Bruag.
Alternatively, rivets or other screw types may be used. These must be provided by the
contractor and must comply with the applicable requirements. We can paint the
chosen fastenings on request.
3
Details and Connections
The overall design should be at least 80 mm, ideally 100 mm. The substructure can be
made using wood or metal profiles. Formboard top pine® panels are covered first with a
fleece or felt and then with a layer of insulation of 30 mm thickness. The cavity behind
should be 30 to 50 mm to absorb low-pitched noise.
Section Design
For rectangular areas, it is recommended that the structure be set away from the edge
on all sides by approx. 100 mm. This makes design and construction more efficient,
especially inside buildings.
Section: Section:
Support Intermediate Point Support Panel Joint
4
Schematic
5
4
2
3
5
Use Cases
Bruag AG
Bahnhofstrasse 8 Phone: +41 71 414 00 90 info@bruag.ch
8594 Güttingen Fax: +41 71 414 00 91 www.bruag.ch
Switzerland