Professional Documents
Culture Documents
SS 316L Cut Time Test (ETR-327) PDF
SS 316L Cut Time Test (ETR-327) PDF
Technical
Report PRIVATE & CONFIDENTIAL
1. Introduction
CMP Products has been invited to design an anti-theft bracket to protect cables on the DMRC project. The
thickness of the material used will have a direct relation to how long it would potentially take to cut through
the bracket using standard hand tools.
This document will record the actual time it takes to cut through 2, 3 and 4mm stainless steel grade 316L.
2. Method
1. The SS316L cut samples will all have the same width 50mm
2. The hand tool for cutting the SS316L - Hacksaw with a partly used blade 12” X 24 TPI
This technical report is for the benefit of the intended recipients only and
may be reproduced only in full.
PRIVATE & CONFIDENTIAL
3. The cutting blade will be held parallel to the face of the 50mm wide sample during the manual cut.
3. Results
This technical report is for the benefit of the intended recipients only and may be reproduced only in full.