Professional Documents
Culture Documents
Damaged Nut/Bolt Extractor Set: 12pc 12pc 12pc 12pc
Damaged Nut/Bolt Extractor Set: 12pc 12pc 12pc 12pc
10mm
Guarantee
12mm This item contains consumable elements and are NOT covered
by the Tool Connection Guarantee. For spares contact our service
10mm department direct on: +44 (0) 1926 818186.
www.lasertools.co.uk
Our products are designed to be used correctly and with
care for the purpose for which they are intended. No
Instructions
liability is accepted by the Tool Connection for incorrect The following instructions are for guidance only.
use of any of our products, and the Tool Connection The use of this extractor kit is purely down to the user’s
cannot be held responsible for any damage to personnel, discretion and The Tool Connection cannot be held
property or equipment when using the tools. Incorrect responsible for any damage caused whatsoever.
use will also invalidate the warranty.
Note:
When removing the cap from the fixing do not strike the
caps directly with a hammer
Description
The kit is made up of a set of cleverly designed hexagon 10mm
bolt and nut extractor adaptor caps. The caps fit
over the rounded off fixing and allow a standard 12
point socket or ring wrench to be used to remove the 10mm
rounded off hexagon fitting.
Note: Due the method of use and the material 12mm
requirements of the 7524 kit the adaptors are
considered consumable.
10mm
Sizes
8mm Extractor Cap
9mm Extractor Cap Extractor Cap Removal
10mm Extractor Cap
11mm Extractor Cap
12mm Extractor Cap
13mm Extractor Cap
14mm Extractor Cap
15mm Extractor Cap
16mm Extractor Cap
17mm Extractor Cap
18mm Extractor Cap
19mm Extractor Cap