Professional Documents
Culture Documents
Modeling 6 Story RC Building Etabs 2013 Tutorial PDF
Modeling 6 Story RC Building Etabs 2013 Tutorial PDF
------------------------------------------------
Modeling 6story RC building
ETAB 2013 Tutorial
Eng .Affoune Mohamed El Hadi
-------------------------------------------------- ----------------------------------
September 2014
ETAB 2013 tutorial
Table of Content
1 General Modeling
Objective
' ow you have Never Used ETAB before, do not BE September back. We
have
Designed Print course in Suchi away That even the- inexperienced ETAB user
Will have no problem following ALONG. '
Author
Affoune Mohamed El Hadi , Structural Engineer at China
State Construction Engineering Corporation (CSCEC).
Contact:
E-mail: affoune.m.hadi@gmail.com
Section parameters
Beam 30x45cm
Column 40x40cm
Slab Ribbed slab 16 + 4cm
Shear wall 20cm
Typical Story 3m
Story at base of building 3m
Damping 0.1
Quality factor 1.2
Behavior factor 4
Zone acceleration 0.15
ETAB 2013 tutorial
1General Modeling
1.1 Setting up the- model
geometry from atemplate
1.1.1. From the- File menu select New Model from Template.
-Figure 1-
ETAB 2013 tutorial
- Figure 2-
ETAB 2013 tutorial
- Figure 3-
ETAB 2013 tutorial
- Figure 4-
- Figure 5-
ETAB 2013 tutorial
Beam >> frame section Properties >> frame sections >> add new Property >>
- Figure 6-
ETAB 2013 tutorial
- Figure 7-
ETAB 2013 tutorial
- Figure 8-
ETAB 2013 tutorial
- Figure 9-
ETAB 2013 tutorial
- Figure 10 -
ETAB 2013 tutorial
Go to Select >> Properties >> frame sections ,select "ConcBm" to select For beams in model.
- Figure 11 -
Go to Assign >> Frame >> section Property and select "Beam 30x45 " from
- Figure 12 -
1.6.2 Select All columns and Assign "Column 40x40 " Section Properties
Go to Select >> Properties >> frame sections ,select "ConcCol" to select For columns in model.
ETAB 2013 tutorial
- Figure 13 -
ETAB 2013 tutorial
Go to Assign >> Frame >> section Property and select "Column 40x40 " from
-Figure 14 -
ETAB 2013 tutorial
- Figure 15 -
ETAB 2013 tutorial
Go to Assign >> shell >> slab section and select "Ribbed slab 16 + 4 ' from
- Figure 16 -
ETAB 2013 tutorial
- Figure 17 -
ETAB 2013 tutorial
-Figure 18 -
Go to Define Fuctions >> >> Response Spectrum and select "Add new function from file
-Figure 19 -
ETAB 2013 tutorial
- Figure 20 -
ETAB 2013 tutorial
- Figure 21 -
ETAB 2013 tutorial
- Figure 22 -
ETAB 2013 tutorial
- Figure 23 -
Run analysis