Professional Documents
Culture Documents
Measure Assembled I.D. of Bearings and O.D. of Crankshaft Journals
Measure Assembled I.D. of Bearings and O.D. of Crankshaft Journals
NOTE:
Also inspect and measure assembled I.D. of connecting rod bearings. Compare measurements with
connecting rod journal O.D. on crankshaft. See INSPECT AND MEASURE CONNECTING ROD
BEARINGS in Group 030.
1. With crankshaft removed from engine, install main bearing caps with bearing inserts. Be sure inserts are installed
correctly.
3. Measure I.D. of all assembled bearings in four locations 90° apart with an inside micrometer. Compare measurements
with the following specifications.
file:///C:/ProgramData/Service%20ADVISOR/Temp/CTM86_09001faa80107c3e.html 10.08.2020
Page 2 of 2
4.
RG10224-UN: Measuring Crankshaft Main Journals
Measure O.D. of all respective crankshaft main journals in four locations 90° apart. Compare measurements with the
following specifications.
NOTE:
If engine has previously had a major overhaul and undersized bearing inserts were used, I.D. and
O.D. dimensions may not be the same as those recorded. However, oil clearance must be
0.030—0.107 mm (0.0012-0.0042 in.). Replace bearings as needed.
Crankshaft Main Journal Taper per 25.4 mm (1.0 in.) length 0.0025 mm (0.0001 in.)
RG,RG34710,1172-19-19990610
file:///C:/ProgramData/Service%20ADVISOR/Temp/CTM86_09001faa80107c3e.html 10.08.2020