Professional Documents
Culture Documents
Methodology in Dismantling of DX and CHW Type Aircon Unit
Methodology in Dismantling of DX and CHW Type Aircon Unit
2. Get to the outside equipment, take the lids from the valves on the pipes with a
wrench. They’re the tin hexagonal lids that are screwed to the pipes’ “elbows”.
3. Turn the AC on in the cold mode. (You may have to warm up the sensor if the day is
too cold, or start the procedure warming up the room where the inner air is installed,
as the technical alternative to this is a bit complicated)
4. Allow the equipment to run until the compressor starts. Screw the valve of the
thinner pipe all the way in with a 5mm-Allen wrench, and let the same Allen ready in
the other valve.
5. The compressor sound will change to a lower pitch. When it gets steady screw in the
other valve and tell the one inside to turn off/unplug the equipment.
Compressor.
- If you don’t allow enough time, refrigerant may not be removed completely.
METHODOLOGY IN DISMANTLING OF AC CHILLED WATER TYPES: