Professional Documents
Culture Documents
Purchase Spec. For Nozzles Swage (Sa106b)
Purchase Spec. For Nozzles Swage (Sa106b)
Purchase Spec. For Nozzles Swage (Sa106b)
Doc.No. : SWI0900051-PS-06
S&W HEAT
PURCHASE SPECIFICATION Rev.No. : 0
EXCHANGERS
(S) PTE LTD Page No.: 1 of 3
1.2 Code
American Society of Mechanical Engineers (ASME):
ASME SEC.VIII -DIV.1, 2007 Edition +2008 Add.
1.4 End Use : For Swage Nozzles (Normalized after cold forming)
2.1 The Swage Nozzles Forming shall strictly conform to the requirements of
ASME Sec.VIII - Div.1, UG-79,UCS-79 & UCS-85
2.2 The tolerance for Swage Nozzles shall confrom to ASME Sec.VIII - Div.1, UG- 80
2.3 The manufacture of the Swage Nozzles shall furnish identification in accordance with
ASME Sec.VIII - Div.1, UG-77,UG-93 & UG-94
2.4 The Swage Nozzles shall be marked with the name of trademark of the manufacturer
2.5 The Swage Nozzles material requirement shall be followed as per PS: SWI0900051-PS-04
2.6 The Swage Nozzles shall be normalized after cold forming.
2.7 100% PT shall be carried out after normalizing.
2.8 The mechanical properties of swage nozzles shall be represented by test specimens
which have been subjected to the same heat treatment cycles during fabrication
Exhibit 03 ASME form-003
Doc.No. : SWI0900051-PS-06
S&W HEAT
PURCHASE SPECIFICATION Rev.No. : 0
EXCHANGERS
(S) PTE LTD Page No.: 3 of 3
2.9 The Swage Nozzles forming procedure shall be submitted for review before start of work.
2.10 The swage nozzles manufacture shall furnish a material test report and forming report ( PT,
dimension and thickness check report ) certifying that the swage nozzles was manufctured tested
and inspected in accordance with specification and the results met the requirement
of the specification.