Professional Documents
Culture Documents
Decor Texture - TDS
Decor Texture - TDS
PRODUCT DESCRIPTION
KANSAI DÉCOR TEXTURE is a water based acrylic copolymer textured coating for exterior use. Available
in different texture sizes ranging from 1mm to 3 mm and can be applied by different techniques to produce a
variety of textured designs.
INTENDED USAGE
To protect and decorate exterior wall surfaces.
Suitable for application to suitably primed cement plaster, concrete and brickwork.
PHYSICAL PROPERTIES
Appearance
Matt VOC
Less than 0.01 g/Liter
Colours
White and range of standard colours. Specific Gravity at 23oC
1,9 (approx.)
Tint Bases
N.A Recommended DFT per coat
Varied as per texture sizes
Generic Type
Styrene Acrylic Flash Point
N.A
Volume Solids
Approx. 70 ± 2 % Theoretical Spreading Rate
0.2 - 0.7 m2/litre
APPLICATION DETAILS
Mixing Cleaning
Stir thoroughly with a flat paddle until Water
homogeneous and stir periodically during use.
Application Environment
Substrate Surface Ambient Relative
Temperature Humidity
Thoroughly prepared Cement plaster, concrete Temperature
and gypsum plaster. Min 10 °C 10 °C 10%
Or 2 °C min. above dew point
Method
Putty knife or trowel. Max 40 °C 50 °C 85%
Thinning Drying Time
Ready for use. Touch Dry 3h at 23 °C
Recoating 16h at 23 °C
Dry to handle 16h at 23 °C
Page 1 of 3
kansai décor texture
PRODUCT CODE: DATASHEET NO: ISSUE DATE:
A-421 KPME-B-14 APRIL 2015
APPLICATION PROCEDURE
Apply using putty knife or trowel. Various pattern van be obtained based on application techniques.
Apply at recommended spreading rates.
CAUTIONS
Friable and powdery surfaces require special care before painting - if in doubt contact
manufacturer.
For health reasons avoid dusting when preparing fiber cement surfaces. Keep surfaces wet and
wash off residues with water.
Do not paint under conditions of frost, dew, rain, fog or inclement weather. Note: Painting under
the above conditions may affect the performance of the paint film.
Avoid painting during inclement weather or if temperature is below 10 °C.
To ensure colors on a project are consistent check the batch numbers and/or colours supplied are
the same.
SAFETY PRECAUTIONS
Keep out of reach of children.
Ensure good ventilation during application and drying.
In case of skin contact, wash with soap and water or a recognized skin cleaner.
Avoid contact with eyes – In case of contact, rinse eyes immediately with plenty of water and seek
medical advice if symptoms persist.
Harmful if swallowed. Do not induce vomiting. Seek medical attention.
Refer to Material Safety Data Sheet for complete information.
Page 2 of 3