Professional Documents
Culture Documents
NAS Quick Start Guide
NAS Quick Start Guide
2) launch your web browser such as IE or Firefox, etc, and type in the found IP
If for whatever reason, the NASFinder can not find your NAS, use the
next method to assign an static IP to it.
2) Connect the NAS to your network (connect the RJ45 network cable to the LAN port 0
as, if you are not sure which is NIC-0, connect both NIC ports), turn it on and allow it
approximately two (2) minutes to boot up.
3) once you see the login prompt from the console, login as follow:
user id: root
password: 0000
6) now go to any computer in the same network, open a web browser, and point to the IP
that you just setup with “netconfig”
7) login as:
ID: root
password: 0000
then you are ready to config your NAS via the Web GUI.