Professional Documents
Culture Documents
Solved Problems On Rectifiers-161111043120 PDF
Solved Problems On Rectifiers-161111043120 PDF
Sign In
F ree Tri al
This Book
Electronic Devices
4.9. SOLVED PROBLEMS
and Integrated
Circuits 1. Determine the peak and rms voltages on the secondary of a
transformer connected across a bridge rectifier to provide a no
load dc voltage of 9 V. If the secondary winding resistance is 3 Ω
and dynamic resistance of each diode is 1 Ω, determine the dc
Search
output across a load resistance of 100 Ω and 1 K. Also determine
the regulation.
Contents
C opyright
Dedication
Preface
Acknowledgements
C h. 1. Physics of
Semiconductors
C h. 2. Physical Phenomenon
in Homojunction
C h. 3. Diode as C ircuit
Element
C h. 4. Junction Diode
Rectifier
Introduction
Half-wave Rectifier
Full-wave Rectifier
Bridge Rectifier
Transformer Utilization
Factor
Passive Filter
Voltage Multiplier
Voltage Regulation
SOLVED PROBLEMS
EXERC ISES
C h. 5. Physical Phenomenon
in BJT 2. A 220 V, 60 Hz voltage is applied to a centre tapped step-down
C h. 6. Physical Phenomenon
in JFET and MOSFET
transformer of 22: 1 with a load of 1 K connected across the
C h. 7. Biasing output of two-diode full-wave rectifier. Assume diodes to be
C h. 8. BJT Amplifiers ideal. If the resistance of half-secondary winding is 0.5 Ω,
C h. 9. FET Amplifiers determine the (a) peak, rms and dc voltages, (b) peak, rms and
C h. 10. Frequency Response dc currents, (c) dc power delivered to the load, (d) VA rating of
of BJT Amplifiers
the transformer secondary, (e) ac input to transformer assuming
C h. 11. Multistage Amplifiers
C h. 12. Feedback in
it to be 80% efficient, (f) ac ripple voltage across the load and
Amplifiers its frequency, (g) How much is the PIVof each diode if the circuit
C h. 13. Oscillators is changed to a bridge rectifier using the full secondary winding
C h. 14. Power Amplifiers of the same transformer? (h) How much are the peak, rms, dc
C h. 15. Operational Amplifier
voltages?
C h. 16. Regulated Power
Supplies
C h. 17. Integrated C ircuit
Solution:
Timers
C h. 18. Special Two-terminal (a) Vm (between full secondary) = 10√2 = 14.14 V
Devices
C h. 19. Tuned Amplifier
vrms (full secondary) = 10 V, Vm (half secondary) =
Bibliography
Index 7.07 V
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 1/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 2/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
Solution:
Solution:
Solution:
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 3/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
Solution:
If there are 100 turns in the primary, then it must have 10 turns
in the secondary.
Solution:
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 4/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
8. What is the value of VDC and Vac developed across the load in
circuit of Fig. 4.33 assuming all diodes to be ideal. What is the
frequency of ac voltage present across load?
Solution:
Solution:
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 5/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
capacitor filter. The value of the capacitor is 1000 μF and the
value of load resistance is 100 Ω with frequency of input voltage
equal to 50 Hz. Determine the ripple factor and dc voltage.
Solution:
11. Calculate the ripple factor in the case of a full-wave rectifier with
π-filter having the component values C1 = C2 = 500 μF and laod
resistance = 100 Ω.
Solution:
Solution:
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 6/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
Solution:
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 7/8
16/5/2014 Electronic Devices and Integrated Circuits > Junction Diode Rectifier > SOLVED PROBLEMS - Pg. : Safari Books Online
http://my.safaribooksonline.com/book/electrical-engineering/semiconductor-technology/9788177589788/junction-diode-rectifier/solved_problems-003 8/8