This document provides specifications for the National Pipe Hanger Corporation's Fig. NR20 Pre-Insulated Pipe Riser Clamp. It is designed to provide vertical support for insulated pipes carrying fluids like chilled water, hot water, and steam. The clamp uses calcium silicate insulation and carbon steel materials. Charts provide dimensions and load ratings for the clamp in different pipe sizes and insulation thicknesses.
This document provides specifications for the National Pipe Hanger Corporation's Fig. NR20 Pre-Insulated Pipe Riser Clamp. It is designed to provide vertical support for insulated pipes carrying fluids like chilled water, hot water, and steam. The clamp uses calcium silicate insulation and carbon steel materials. Charts provide dimensions and load ratings for the clamp in different pipe sizes and insulation thicknesses.
This document provides specifications for the National Pipe Hanger Corporation's Fig. NR20 Pre-Insulated Pipe Riser Clamp. It is designed to provide vertical support for insulated pipes carrying fluids like chilled water, hot water, and steam. The clamp uses calcium silicate insulation and carbon steel materials. Charts provide dimensions and load ratings for the clamp in different pipe sizes and insulation thicknesses.
This document provides specifications for the National Pipe Hanger Corporation's Fig. NR20 Pre-Insulated Pipe Riser Clamp. It is designed to provide vertical support for insulated pipes carrying fluids like chilled water, hot water, and steam. The clamp uses calcium silicate insulation and carbon steel materials. Charts provide dimensions and load ratings for the clamp in different pipe sizes and insulation thicknesses.
• Provides vertical support to upward • Provides continuous, zero permeability vapor Insulation: Calcium Silicate meeting and downward riser loads barrier ASTM C-585 and • Structural insulation for load transfer C-656 Type II Grade 6 • Designed for use on: • ASTM E-84 Flame Spread/Smoke Developed: 10/20 900 psi, 28 pcf Chilled Water Hot Water Steam • Thermal Conductivity other insulation materials, Page 34 0.61 Btu•in/(hr•ft2•°F) @ 200°F Base/Clamp: ASTM A-36 Carbon Steel • Installation: welded to a flat surface or • Insulation chemically bonded Fasteners: ASTM A-307 Electro-Galv. Plated rigidly braced • Four thrust plates shipped loose for field welding Shield: ASTM A-653 G-90, 18 ga Galv. Steel • Temperature Range: +20°F to +1200°F Vapor Barrier: ASTM E-96 All Service Jacket • Vertical Load ratings do not include • Outside hanger bolt is offset to accomodate Finishes: (H) Hot-Dip Galv. per ASTM A-123 local stress evaluation at thrust weldless eye nut on sizes 6” and above. (P) Painted Red Shop Primer plate/pipe wall interface. Contact (B) Unfinished factory for assistance. • See National Pipe Hanger Corporation’s Pipe Hangers and Supports Catalog for hardware and upper attachments.