Professional Documents
Culture Documents
Manual DS-2CE16C0T-IRP
Manual DS-2CE16C0T-IRP
content is subject to change without notice. 2006/95/EC, the EMC Directive 2004/108/EC, expansion screws before you install the camera.
The updates will be added to the new version of the RoHS Directive 2011/65/EU. If the wall is the wooden wall, you can use
this manual. We will readily improve or update 2012/19/EU (WEEE directive): HD Video Cable self-tapping screw to secure the camera.
the products or procedures described in the Products marked with this symbol Sun Shield lIf the product does not function properly,
manual. cannot be disposed of as unsorted Lens please contact your dealer or the nearest
IR LED
municipal waste in the European service center. Do not disassemble the camera
Union. For proper recycling, return for repair or maintenance by yourself.
0100001050203
this product to your local supplier
2.1 Ceiling Mounting for Type I Clip Plate 2.3 Installation of Type III Camera
Camera 5.Adjust the surveillance angle.
1).Loosen No.3 adjusting screw to adjust the Steps:
panning position ( 0° ~ 360° ). 1.Drill the screw holes and the cable hole on the
2).Tighten No.3 adjusting screw . ceiling according to the supplied drill template.
Both wall mounting and ceiling mounting are 3).Loosen the No.2 adjusting screw to adjust the
suitable for type I bullet camera. Ceiling mounting
tilting position ( 0° ~ 90° ).
will be taken as an example in the section. And you Figure 2-5 Screw the Clip Plate
can take steps of ceiling mounting as a reference 4).Tighten No.2 adjusting screw. Cable Hole
if wall mounting is adopted. 5).Loosen No.1 adjusting screw to adjust the 3. Fix the mounting base to the ceiling with the
azimuth angle of the image ( 0° ~ 360° ). supplied screws.
Steps: 6).Tighten No.1 adjusting screw . Screw Hole
4.Route the cables through the side opening and
1.Drill the screw holes in the ceiling according connect the corresponding power cable and
to the supplied drill template. video cable.
2.Hammer the supplied plastic expansion bolt into 5.Pull out the clip plate and secure the camera Figure 2-8 The Drill Template
the screw holes. with the trim ring to the mounting base.
2.Fix the mounting base to the ceiling with the
6.Push the clip plate in and tighten the lock screw
supplied screws.
3 to secure the trim ring.
360°
2
90°
360°
1 Side Opening
Clip Plate
Screw hole
Figure 2-3 3-axis Adjustment
0°~360°
0°~75°
Figure 2-4 The Drill Template
0°~360°
Figure 2-7 3-axis Adjustment
0°~75°
Figure 2-2 Fix the Camera to the Ceiling 2. Screw the clip plate onto the mounting base 7. Adjust the camera according to the figure 2-7 to
loosely. 0°~360°
get an optimum angle and tighten the trim ring.
Figure 2-10 3-axis Adjustment