Professional Documents
Culture Documents
Dell Working Capital Q1 How Was Dells Wo PDF
Dell Working Capital Q1 How Was Dells Wo PDF
Dell had a policy of working with low inventory and it used to make inventory
purchases based on the sale orders received. This led to following advantages:
• No obsolete goods.
• Defects in raw material manufacturers were easily weeded out.
• New technological up gradations can be easily set into the system before the
competition turns over the existing inventory. Thus Dell had a first mover’s
advantage in being abreast with latest technological inclusion.
• High inventory turnover and low inventory days. This resulted in low cash
conversion cycle.
From Table A, Dell had Days Supply of Inventory (DSI) as 32 days while the
competition average for is:
DSI average = (54 + 73 + 48) / 3 = 58 days
From Exhibit 4, the COGS for Dell for 1995 is $2737 and the DSI is 32 days. Hence the
Average inventory comes out to $239mn, which is almost $200mn less than the
competitions average of $436mn for the same amount of COGS.
When we compare Dell’s performance in 1996 as compared to 1995, the Sale grew
from $3475 to $5296 reporting a growth of 52.4%. However, the total assets in 1995
were $1594 i.e. 46% of sales and operating assets were total asset less short-term
investment i.e. $1110 which is about 32% of sales. Thus when the sales grow by 52%, the
operating assets need to grow in a similar proportion. Thus, the operating assets in 1996
must be
Thus the operating asset must increase by $584mn to meet the expenses, which will the
additional funds that Dell must have procured. If we look at the sources of funds, the
liabilities less accounts payable have increased by $500mn and the projected operational
profit at 4.3% of projected increase in sale gives additional $230mn. Thus the firm can
make sufficient funding through internal sources. The increase in current liability was
$939-$752 = $187mn. The increase in current asset was $1957-$1470 = $487mn.
Q3: Assuming Dell sales will grow 50% in 1997, how might the company fund its
growth internally? How much would the working capital need to be reduced and /
or profit margin increased? What steps do you recommend the company take?
The Days Accounts Receivable comes out to 44 days. The Days Accounts Payable is
37.45 days while the Days Inventory Turnover is about 31.15 days. This brings the cash
conversion cycle to 37.7 days. The 50% hike in revenue gives the projections as below:
1997 ($ mn)
Year 1996 ($ mn) Days
[projected]
Cash 55 --- 55
Short Term Investments 591 --- 591
Accounts Receivables 726 44 1189
Inventories 429 31.15 654
Others 156 --- 156
Current Assets: 1957 --- 2645
Accounts Payable 466 37.45 835
Other Liability 473 --- 473
Current Liabilities: 939 1308
Cash Conversion Cycle 37.7
Hence additional operating asset of $794mn is required to sustain the growth. The
increase in the current liability acts as source of funds, which is $469mn. Estimated
increase in net profits is about $123mn to reach the figure of $395mn. The short-term
investment is assumed to stay the same as year 1996 i.e. $591mn. Hence we can safely
say that the growth will be internally funded.
Q4: How would you answer to Q3 change if Dell also repurchased $500 million of
common stock in 1997 and repaid its long-term debt?
This results in net addition of $433mn that will be sufficient to fund the working capital.