Professional Documents
Culture Documents
Bearings
Bearings
A. directly as load
2. In hydrodynamic bearings
C. the oil film pressure is generated only by the pressure of the journal
A. 0.1 to 0.5
B. 0.2 to 0.6
C. 0.2 to 0.8
D. 0.25 to 1.0
4. When the line of action of the load bisects the arc of partial bearing is said to be
A. centrally loaded
B. eccentrically loaded
C. fit loaded
D. surface loaded
A. Ball bearing
B. Needle bearing
C. Roller bearing
D. Tapered bearing
6. Which of the following is not a type of ball bearing?
A. act as a coolant
B. adhesion
C. corrosion prevention
8. If P = bearing pressure on projected bearing area, Z = absolute viscosity of lubricant, and N = speed of
journal, then the bearing characteristic number is given by
A. P/ZN
B. ZN/P
C. Z/PN
D. ZP/N
9. The radial distance between the center of the bearing and the displaced center of the journal is
called:
A. Concentricity
B. Eccentricity
C. Embeddability
D. Weldability
A. Peripheral load
B. Radial load
C. Tangential load
D. Thrust load
A. 120 degrees F
B. 140 degrees F
C. 160 degrees F
D. 200 degrees F
12. The rule of thumb in journal bearing design, the clearance ratio/clearance should be
A. 0.0010
B. 0.01001
C. 0.0101
D. 0.0110
A. Graphite
B. Grease
C. Lube oil
D. Motor oil
A. Cast iron
B. Low carbon steel
C. Nylon
D. Teflon
16. It exists primarily to guide the motion of a machine member without specific regard to the direction
of load application is called:
A. Guide bearing
B. Journal bearing
C. Radial bearing
D. Thrust bearing
17. The product of absolute viscosity and rotational speed divided by the unit loading is known as
A. Bearing modulus
B. Section modulus
C. Shear modulus
D. Young modulus
18. The line that passes through the centers of the bearing and the journal is called the
A. line of action
B. line of center
C. line of tangent
D. under cut
A. Babbitt bearing
B. Central bearing
C. Full bearing
D. Offset bearing
20. Which of the following is the bearing material?
A. Babbitt
B. Bronze
C. Plastics
A. Extra heavy
B. Heavy
C. Light
D. Medium
24. Length-diameter ratio was a good compromise for the general case of hydrodynamic bearings is
approximately
A. 1
B. 2
C. 3
D. 4
25. A type of roller bearing in which the balls are assembled by the eccentric displacement of the inner
ring is
26. Fluid film desired between two surfaces having relatively sliding motion is known as
A. graphite
B. lube oil
C. lubrication
D. packing
27. Measured from the line of radial loading on the bearing to the position of the minimum oil-film
thickness is called:
A. Altitude angle
B. Attitude angle
C. Latitude angle
D. Longitude angle
28. A machine part that supports another part, which rotates, slides or oscillates in or on it.
A. Bearing
B. Casing
C. Journal
D. Roller
29. A shaft rotating in anticlockwise direction at slow speed inside a bearing will be
A. at bottom most of bearing
30. It carries a load collinear to the axis of possible rotation of the supported member.
A. Guide bearing
B. Journal bearing
C. Radial bearing
D. Thrust bearing