Professional Documents
Culture Documents
Da Vinci, Da Vinci S, Da Vinci Si Quick Reference Guide (Harmonic Ace Curved Shears) (550999-02) PDF
Da Vinci, Da Vinci S, Da Vinci Si Quick Reference Guide (Harmonic Ace Curved Shears) (550999-02) PDF
Assembly
Note: Read and follow the Instructions for Use prior to assembly and use.
Step 4
➥
For 8 mm instruments: (a) Hand tighten the gray shaft, while holding the instrument housing and hand piece together until finger-
tight. (b) Slide the torque wrench over the jaws onto the wrench flats and turn the wrench in a clockwise direction until you hear one “click.”
See Side 2 for
For 5 mm instruments: Slide the torque wrench over the jaws onto the wrench flats. While firmly pushing the wrench and hand piece
together, turn the wrench in a clockwise direction until you hear one “click.”
Generator Self Test,
Note: If you do not hear the click after several turns of the wrench, pull the Insert partially out of the housing, rotate the Insert 180 degrees, and re-engage into the housing. HARMONIC ACE Components,
8 mm Instrument (a) 8 mm (b) 5 mm Instrument Product Comparison
and Contact Information
© 2010 Intuitive Surgical. All rights reserved. Intuitive®, Intuitive Surgical®, da Vinci®,
da Vinci® S™, da Vinci® Si™, InSite®, TilePro™, Single-Site™, and EndoWrist® are trade-
marks or registered trademarks of Intuitive Surgical. All other product names are
trademarks or registered trademarks of their respective holders.
Note: The housing and the hand Ethicon Endo-Surgery DSL #: 10-1438
piece must be held together to Note: The housing and the hand piece must be held to-
minimize the gap. gether to minimize the gap.
SIDE 1
Slide the wrench off the Insert, over the closed jaws, and remove it completely. Confirm that the Insert is securely attached to the housing by Customer Service: 1.800.876.1310
trying to slide the Insert out while holding the housing. www.intuitivesurgical.com
PN 550999-02 Rev. A
Generator Self-Test
Note: Do not turn the generator power on before the hand piece and instrument are connected to the generator. Read and follow the Instructions
for Use prior to assembly and use.
Step 1
➥ See Side 1 for
Assembly Instructions
SIDE 2
Plug the hand piece into the appropriate generator port. Turn on the generator by pressing the power button on HARMONIC ACE® Curved Shears Components
the front panel.