The document outlines mock-up activities for testing high-density polyethylene (HDPE) welding, including fusion wedge welding of 1.5 linear meters x 300mm sections and air pressure testing of the welded areas. Extrusion welding repair will also be done, followed by vacuum box testing of the repaired area and additional fusion wedge welding to create a test seam from which samples will be peel tested using a tensiometer.
The document outlines mock-up activities for testing high-density polyethylene (HDPE) welding, including fusion wedge welding of 1.5 linear meters x 300mm sections and air pressure testing of the welded areas. Extrusion welding repair will also be done, followed by vacuum box testing of the repaired area and additional fusion wedge welding to create a test seam from which samples will be peel tested using a tensiometer.
The document outlines mock-up activities for testing high-density polyethylene (HDPE) welding, including fusion wedge welding of 1.5 linear meters x 300mm sections and air pressure testing of the welded areas. Extrusion welding repair will also be done, followed by vacuum box testing of the repaired area and additional fusion wedge welding to create a test seam from which samples will be peel tested using a tensiometer.
2. Air pressure test on 1.5 LM fusion welded area 3. Extrusion welding repair 4. Vacuum Box Test on extrusion welding repair area 5. Fusion wedge welding on 1.5 LM x 300mm to get a test seam 6. Samples from both end of the test seam (total 2 Nos) of size 25mm x 300mm shall be peel tested at site by tensio meter