Professional Documents
Culture Documents
Settings Editor (7SR242 DIFF RLY - 7SR242x-2xAxx-0CA0-after Testing
Settings Editor (7SR242 DIFF RLY - 7SR242x-2xAxx-0CA0-after Testing
rsf2 Page 1 of 5
SYSTEM CONFIG
System Frequency (50..60) 50Hz
Setting Dependencies (Disabled..Enabled) Enabled
Favourite Meters Timer (Off..60) 60min
Backlight timer (Off..60) 5min
W1 Settings Display (xNom..Secondary) xNom
W2 Settings Display (xNom..Secondary) xNom
Ig-1 Settings Display (xNom..Secondary) xNom
Ig-2 Settings Display (xNom..Secondary) xNom
Select Grp Mode (Edge triggered..Level triggered) Edge triggered
Clock Sync. From BI (Disabled..Minutes) Disabled
Operating Mode (Out Of Service..Local Or Remote) Local Or Remote
Gn Unexpected Restart Blocking (Disabled..Enabled) Disabled
Setting Password (Password) NONE
Control Password (Password) 340701675
Trip Alert (Disabled..Enabled) Enabled
General Alarm Alert (Disabled..Enabled) Enabled
Relay Identifier (16 Character String) 7SR242·DIFF·RLY·
Circuit Identifier (16 Character String) 10MW·OFBL·SPV···
CT/VT CONFIG
W1 Phase Input (1..5) 1A
W1 Phase CT Ratio Prim ( 6 Character String) 60····
W1 Phase CT Ratio Sec (0.2..7) 1
W2 Phase Input (1..5) 1A
W2 Phase CT Ratio Prim ( 6 Character String) 250···
W2 Phase CT Ratio Sec (0.2..7) 1
Ig-1 Input (1..5) 1A
Ig-1 CT Ratio Prim ( 6 Character String) 60····
Ig-1 CT Ratio Sec (0.2..7) 1
Ig-2 Input (1..5) 1A
Ig-2 CT Ratio Prim ( 6 Character String) 250···
Ig-2 CT Ratio Sec (0.2..7) 1
Nominal Voltage (40..160) 63.5V
Voltage Trim Magnitude (-20..20) 0V
Voltage Trim Angle (-45..45) 0deg
VT Ratio Prim ( 6 Character String) 132000
VT Ratio Sec (40..160) 110
VT Connection (Vpn..Vpp) Vpp
FUNCTION CONFIG
Gn Differential (Enabled..Disabled) Enabled
Gn Inrush Detector (Enabled..Disabled) Enabled
Gn Overfluxing Detector (Enabled..Disabled) Enabled
Gn Phase Overcurrent (Enabled..Disabled) Disabled
Gn Derived E/F (Enabled..Disabled) Disabled
Gn Measured E/F (Enabled..Disabled) Disabled
Gn Restricted E/F (Enabled..Disabled) Enabled
Gn NPS Overcurrent (Enabled..Disabled) Disabled
Gn Under Current (Enabled..Disabled) Disabled
Gn U/O Voltage (Enabled..Disabled) Disabled
Gn Neutral Overvoltage (Enabled..Disabled) Disabled
Gn U/O Frequency (Enabled..Disabled) Disabled
Gn Overfluxing (Enabled..Disabled) Enabled
Gn Thermal (Enabled..Disabled) Disabled
Gn Open Circuit (Enabled..Disabled) Disabled
Gn CB Fail (Enabled..Disabled) Disabled
Gn CB Control (Enabled..Disabled) Disabled
Gn Trip Cct Supervision (Enabled..Disabled) Enabled
Gn Close Cct Supervision (Enabled..Disabled) Disabled
Gn CB Counters (Enabled..Disabled) Disabled
Gn I^2t CB Wear (Enabled..Disabled) Disabled
DIFFERENTIAL PROT'N
W1 ICT Multiplier (0.25..3) 1x
W1 ICT Connection (Yy0,0..Ydy10,60) Yy0,0deg
W2 ICT Multiplier (0.25..3) 1x
W2 ICT Connection (Yy0,0..Ydy10,60) Yy0,0deg
87BD
Gn 87BD Element (Disabled..Enabled) Enabled
Gn 87BD Initial Setting (0.1..2) 0.2xIn
Gn 87BD 1st Bias Slope (0.1..0.7) 0.2x
Gn 87BD 1st Bias Slope Limit (1..20) 3xIn
Gn 87BD 2nd Bias Slope Type (Line..Curve) Line
Gn 87BD 2nd Bias Slope (1..2) 1.2x
Gn 87BD Delay (0..1) 0.005s
Gn 87BD Inrush Action (Off..Inhibit) Inhibit
Gn 87BD Overfluxing Action (Off..Inhibit) Inhibit
87HS
Gn 87HS Element (Disabled..Enabled) Enabled
Gn 87HS Setting (1..30) 7xIn
Gn 87HS Delay (0..1) 0.005s
Gn 87HS Inrush Action (Off..Inhibit) Off
Gn 87HS Overfluxing Action (Off..Inhibit) Off
CURRENT PROT'N
RESTRICTED E/F
64H-1
Gn 64H-1 Element (Disabled..Enabled) Enabled
Gn 64H-1 Select (Ig-1..Ig-2) Ig-1
Gn 64H-1 Setting (0.005..0.95) 0.1xIn
Gn 64H-1 Delay (0..14400) 0s
64H-2
Gn 64H-2 Element (Disabled..Enabled) Enabled
Gn 64H-2 Select (Ig-1..Ig-2) Ig-2
Gn 64H-2 Setting (0.005..0.95) 0.1xIn
Gn 64H-2 Delay (0..14400) 0s
VOLTAGE PROT'N
OVERFLUXING
24DT-1
Gn 24DT-1 Element (Disabled..Enabled) Enabled
Gn 24DT-1 Setting (0.1..2) 1.1x
Settings Editor 7SR242 DIFF RLY - 7SR242x-2xAxx-0CA0-after testing.rsf2 Page 2 of 5