Professional Documents
Culture Documents
RTN
RTN
The cable will be plugged to the interface SCC (Port ETH OR ETH –
HUB).
OptiX RTN 600
OptiX RTN 600 is a PDH/SDH integrated short-haul digital microwave
transmission system developed by Huawei.
Equipment Overview
IDU
ODU
Antenna
Hybrid coupler
Indoor unit (IDU) realizes the mutual conversion between the service
signal and IF analog signal. Two types of IDU are available:
1/2 inch and RG-8U (1/4 inch) cable: connection between ODU and IF
jumper.
RG-8U (1/4 inch) cable is used for the distance less than 180
meter.
1/2 inch cable is used for the distance between 180m and 300m.
ODU
Outdoor unit (ODU) realizes the mutual conversion between
IF analog signal and RF signal.
Antenna
The antenna performs the directional transmission and
reception of RF signals. The main parameters are frequency
band, cross polarization de-coupling and antenna gain.
Equipment Characteristics
PDH/SDH integrated microwave transmission system.
The modulation mode and link capacity are set through software.
The boards of IDU 610 and IDU 620 are compatible each other
IF Interface
supply switch
Output one-path -48V and one-path +3.3V power for other boards.
Clock processing
Trace the clock source to provide the system clock and the frame headers of service
signal and overhead signal for each unit.
Select the external clock source or the service clock source as the clock source. The
service clock source can be line, tributary, or microwave clock source, at most five
paths.
Perform the clock protection based on the clock priority, Synchronization Status
Message (SSM) protocol or extended SSM protocol.
Cross-connection processing
The VC-4 pass-through service channel transparently transmits the AU-AIS alarms.
Protection processing
Support the 1+1 backup of internal power module (OptiX RTN 610).
Support the 1+1 backup of input power and the 2+1 backup of internal power module
(OptiX RTN 620).
Support the 1+1 hot backup of clock unit and the cross-connection unit (OptiX RTN
620).
Maintenance characteristics
Note: The soft reset can reset the board software module in the SCC board and does
not affect the services. The hard reset can reset the board software module, and also
can re-load the FPGA in the board. The hard reset interrupts the services.
When multiple RTN600 products are not connected directly through the optical
fiber or microwave link, they can be connected through the network ports of
.combined cabinet to transmit the management information