Professional Documents
Culture Documents
EV Series: Instruction Manual
EV Series: Instruction Manual
When mounting the sensor, be sure to use the Note that the sensor's residual voltage is
toothed washer suppIied as an accessory. 3.4V. (A 12 VDC relay cannot be operated.)
Tighten the washer to less than the torque
specified for each model in the table below. ■Low load current
If the load current is less than 5mA, connect
DC two-wire self contained Shielded Unshielded a bleader resistor in parallel with the load so
that a current of more than 5mA flow through
the sensor.
amplifier proximity sensors A B A B
EV series Model
EV-108M·EV-108U
Distance Dimension
A(mm)
3
A part
8Nm max.
B part
9Nm max.
EV-112M·EV-112U 6 15Nm max. 30Nm max.
Specifications
Type M:Shielded/U:Non-shielded
Model EV-108M / U EV-112M / U EV-118M / U EV-130M / U
Size M8 M12 M18 M30
Detecting distance / M 1.5mm ± 10% 2.5mm ± 10% 5mm ± 10% 10mm ± 10%
Detecting distance / U 4mm ± 10% 8mm ± 10% 15mm ± 10% 27mm ± 10%
Detectable object Ferrous metals (see Characteristics for non-ferrous metals)
Standard target / M
(iron,t =1mm) 10 × 10 mm 12 × 12 mm 18 × 18 mm 30 × 30 mm
Standard target / U
(iron,t =1mm) 20 × 20 mm 30 × 30 mm 50 × 50 mm 70 × 70 mm
Hysteresis 10% max. of detecting distance / 20% max. of detecting distance within –10 to + 70°C (–14 to 158°F), No freezing
Response frequency 800Hz 600Hz 350Hz 250Hz
*1 M: ±10%max. of detecting distance at 23°C (73.4°F)
Temperature fluctuation within –25 to + 70°C (–13 to 158°F), No freezing
Operation mode N.O. (N.C. output type available for all models)
Control output
(switching capacity) 5 to 80mA 5 to 200mA
B
Model
EV-108M/U 20/30 11/28
Distance
EV-112M/U 30/55 22/62 Model A (mm) B (mm)