Professional Documents
Culture Documents
Laser Marking Machine Manual
Laser Marking Machine Manual
Laser Marking Machine Manual
Add:No. 6, Anju Road, Jiaming Industrial Park, Dongchangfu District, Liaocheng City,
252000, Shandong Province, China
laser marking
machine
manual
Thank you for choosing the laser marking machine. This equipment is a
In the manual, there are a large number of physical pictures for your
better understanding.
can help you better master the operation and maintenance of the
Due to the limited level of editors, mistakes and deficiencies in the book
One,...............................................Equipment acceptance
two,...............................................Equipment introduction
four,...............................................Safety Precautions
1. Equipment acceptance
wholeheartedly.
(The picture is different from the actual product, please refer to the
actual product)
2. After opening the packing box, check whether the appearance of
packing box. When removing the device, please take out the device
move the lens and working platform when taking the equipment, so
However, the basic case functions are basically the same, please
and repair are caused by failure of this equipment, the company will
wires on the domestic power socket are not really grounded. All,
nail on the wall, the depth should not be less than 5 cm. The next
step can only be carried out after connecting the ground wire.
2. Use the random power cord, connect the power of the device,
turn on the power switch on the back of the device, then turn on
When the above conditions are met, the following steps can be
performed:
right to left, turn on the main switch at the back, then the front
control switch, and finally the laser switch) to install the driver .
6, After installed the driver, then find the marking machine folder
that has been in the computer, right click and send to the desktop
shortcut
panel
surface of the material. This value is a fixed value. Find a very thin
the red light button and check the approximate location. Hook the
by hand, adjust the lens to the position of the material (blade), find
the light that reacts the most, and the reaction sound will also be
the loudest at this time. Turn off marking and remove continuous
processing! The focal length has been found. Remove the material
product.
First of all, you must hook, after finding the focal length, then
10, Fill the imported vector graphics or the completed text to make
it a solid effect. The line spacing defaults to 0.05 (for metal). The
effect .
The smaller the line spacing density, the slower the processing
speed will be
11, Adjust the speed and power. (Do not move other parameters)
The default value of the speed is 500, the power is 50%, the slower
the speed, the heavier the effect, and the greater the power, the
occurs.
the emitted laser for a long time during operation to avoid damage
to the eyes.
agrees to stick dust and other dirt, causing laser wear and damage
rotating manner. (Note that the lens should be wiped gently, and
the surface coating should not be lost. During the wiping process, it