Professional Documents
Culture Documents
Wiring Pigtail Kits: Identification Guide
Wiring Pigtail Kits: Identification Guide
Wiring Pigtail Kits: Identification Guide
Identification Guide
Motorcraft®®isisaaregistered
registered trademark
trademark of
of Ford
Ford Motor
MotorCompany.
Motorcraft Company. motorcraft.com
MC-PIGTAIL2015A
MC-PIGTAILS2015A MA-20148
MA-20298 motorcraft.com
Wiring Pigtail Kits
36
36
NUD105-R025E Ford Flex Probe Kit
Avoid damaging the vehicle’s electrical connections!! Using the proper size probe tip to access
the working end of an electrical connection will reduce the risk of damaging the vehicle terminal
and will eliminate the need to back probe or pierce wires (opening up the risk of future corrosion).
The latest in the line of Ford Flex Probe Kits, this newest release includes all the probes from the
previous “D” kit, but now adds two each of the Micro Pin (.5mm) Probe. Additionally, all probes
will now be printed with the tip size, helping technicians ensure usage of the properly sized tip.
These tools coincide with the release by Ford of 9 terminal repair kits to allow you to
repair connectors with damaged terminals instead of replacing an entire wire harness.
Improved wiring repair capability was a key request of technicians, FSEs and the TRP
(Technician Repair Panel). With the release of these tools, the terminal repair kits and
terminal part number identification in the Wiring manuals (starting with new models in
2013), you now have the ability to repair most wiring connector issues, especially in high
cavity count connectors.
There are 8 female terminal kits, 6 male terminal kits and 3 Power Distribution Box (PDB) terminal kits that
will service 65% of the terminals used on Ford vehicles today. This is accomplished by having one terminal in
a kit that can substitute for up to 10 other terminals in the vehicle.
To help identify which kit you need, Ford has started updating the Online Wiring Manual on the Ford PTS
(Professional Technician Society) website with terminal information. Not all manuals will have this information.
Here’s how it works:
• When you are looking at a wiring diagram on a 2013 or newer vehicle, click on a connector number
(C Number). It will take you to the Connector Face View page where there is a box that says “Check
for Terminal Part Numbers.”
• Click on it and it will display the Ford Engineering Part number of each terminal in the connector.
There also will be a chart that shows the terminal part number and the Service Part Number of the
Wire Terminal Repair Kit that will service that terminal.
Terminal Size 0.64 0.64 0.64 1.5 1.2 2.8 2.8 2.8
Ford Terminal P/N 9U5T-14474-DA 7S4T-14474-AA BU5T-14474-AA 7U5T-14474-UA 6W8T-14474-BA 3M5T-14474-HCA 97BG-14474-BFA XF2T-14474-BA
Terminal Description Tin 0.5mm^2 Silver 0.5mm^2 Silver 0.5mm^2 Silver 1.5mm^2 Silver 0.75mm^2 Tin 1.5mm^2 Tin 1.5mm^2 Tin 4.00mm^2
DU5T-14474-
FU5T-14474-LA 1L2T-14474-CA 7C3T-14474-CA 6W8T-14474-AA 1F1T-14474-BA 1F1T-14474-EA 7L7T-14474-EA
TAA
DU5T-14474-
9U5T-14474-YA 1L2T-14474-DA 7C3T-14474-DA 6W8T-14474-WA 1F1T-14474-CA 1F1T-14474-FA F8VB-14474-AA
SAA
DU5T-14474-
9U5T-14474-EA 3F2T-14474-RA 7C3T-14474-EA 6W8T-14474-XA 1F1T-14474-DA 1F1T-14474-GA F8VB-14474-BA
EAA
DU5T-14474-
7S4T-14474-BA CU5T-14474-EA 7C3T-14474-GA 6W8T-14474-DBA 3F2T-14474-LA 1F1T-14474-JA
HBA
Female Terminal Service Kits
DU5T-14474-
8U5T-14474-CA BU5T-14474-UA 97BG-14474-BAA 97BG-14474-BDA
NBA
97BG-14474-BCA 97BG-14474-BEA
XF2T-14474-DA 97BG-14474-BEA
97BG-14474-BFA
F8ZB-14474-AA
Legend
Tin = Black wire
Silver = Green wire
Gold = White wire
7 Male Terminal Service Kits 7
Kit PN EU2Z-14421-AA EU2Z-14474-BA EU2Z-14421-CA EU2Z-14421-DA EU2Z-14421-EA EU2Z-14421-FA
Terminal Description Tin 0.5mm^2 Tin 0.5mm^2 Silver 1.0mm^2 Tin 4.0mm^2 Tin 3.0mm^2 Tin 2.5mm^2
4L2T-14421-AA
DU5T-14421-EA
DU5T-14421-HA
DU5T-14421-JA
DU5T-14421-KA
AU5T-14421-DA
AU5T-14421-EA
AU5T-14421-FA
Legend
Tin = Black wire
PDB Female Terminal Service Kits
Silver = Green wire
Kit PN DU2Z-14474-GA DU2Z-14474-HA DU2Z-14474-JA
Gold = White wire
Terminal Size 2.8 4.8 6.3
F2DB-14474-DA F6DB-14474-AEA
F37B-14474-DA F6DB-14474-JA
F6DB-14474-LA F6DB-14474-ZA
8 1-Cavity Connectors 8
WPT-237 (Tin) WPT-265 (Tin) WPT-274 (Tin) WPT-295 (Tin) WPT-305 (Tin) WPT-352 (Tin)
3U2Z-14S411-TA 3U2Z-14S411-GCA 3U2Z-14S411-GXA 3U2Z-14S411-KAA 3U2Z-14S411-CJA 3U2Z-14S411-HNA
WPT-371 (Tin) WPT-378 (Tin) WPT-413 (Tin) WPT-434 (Tin) WPT-439 (Tin) WPT-452 (Tin)
3U2Z-14S411-KBA 3U2Z-14S411-FJA 3U2Z-14S411-CXA 3U2Z-14S411-MFA 3U2Z-14S411-MHA 3U2Z-14S411-MUA
1-Cavity Connectors
WPT-461 (Tin) WPT-476 (Tin) WPT-488 (Tin) WPT-538 (Gold) WPT-616 (Tin) WPT-674 (Tin)
3U2Z-14S411-NYA 3U2Z-14S411-NRA 3U2Z-14S411-RMA 3U2Z-14S411-UHA 3U2Z-14S411-NSA 3U2Z-14S411-CRAA
WPT-700 (Tin) WPT-757 (Tin) WPT-797 (Tin) WPT-901 (Tin) WPT-932 (Tin) WPT-976 (Tin)
3U2Z-14S411-DBAA 3U2Z-14S411-FCAA 3U2Z-14S411-FDAA 8U2Z-14S411-BA 9U2Z-14S411-HA 3U2Z-14S411-KRB
WPT-1017 (Tin) WPT-1022 (Tin) WPT-1036 (Tin) WPT-1059 (Silver) WPT-1106 (Tin) WPT-1121 (Tin)
3U2Z-14S411-NYB 3U2Z-14S411-DXAB 9U2Z-14S411-ARA AU2Z-14S411-XA AU2Z-14S411-AUA 9U2Z-14S411-AAA
WPT-104 (Tin) WPT-113 (Tin) WPT-122 (Tin) WPT-146 (Tin) WPT-148 (Tin) WPT-173 (Tin)
1U2Z-14S411-CA 1U2Z-14S411-MA 1U2Z-14S411-YA 1U2Z-14S411-BAA 1U2Z-14S411-BCA 1U2Z-14S411-AJA
WPT-194 (Tin) WPT-197 (Tin) WPT-212 (Tin) WPT-216 (Tin) WPT-226 (Tin) WPT-236 (Tin)
3U2Z-14S411-ADA 3U2Z-14S411-XA 3U2Z-14S411-BZA 3U2Z-14S411-CUA 3U2Z-14S411-AYA 3U2Z-14S411-PA
2-Cavity Connectors
WPT-244 (Tin) WPT-260 (Tin) WPT-272 (Tin) WPT-273 (Tin) WPT-288 (Tin) WPT-304 (Gold)
3U2Z-14S411-EGA 3U2Z-14S411-BJA 3U2Z-14S411-GUA 3U2Z-14S411-GVA 3U2Z-14S411-JFA 3U2Z-14S411-CDA
WPT-314 (Tin) WPT-322 WPT-334 (Tin) WPT-342 (Tin) WPT-349 (Tin) WPT-355 (Tin)
3U2Z-14S411-EHA (Tin greased) 3U2Z-14S411-GZA 3U2Z-14S411-GDA 3U2Z-14S411-KDA 3U2Z-14S411-FBA
3U2Z-14S411-JZA
WPT-356 (Tin) WPT-357 (Tin) WPT-359 (Tin) WPT-361 (Tin) WPT-372 (Tin) WPT-374 (Tin)
3U2Z-14S411-GYA 3U2Z-14S411-HVA 3U2Z-14S411-JCA 3U2Z-14S411-BAA 3U2Z-14S411-ATA 3U2Z-14S411-DHA
WPT-381 (Tin) WPT-404 (Tin) WPT-410 (Gold) WPT-420 (Gold) WPT-428 (Tin) WPT-433 (Tin)
3U2Z-14S411-GEA 3U2Z-14S411-CAA 3U2Z-14S411-BA 3U2Z-14S411-JUA 3U2Z-14S411-FZA 3U2Z-14S411-MEA
10 2-Cavity Connectors 10
WPT-437 (Tin) WPT-438 (Tin) WPT-441 (Tin) WPT-451 (Tin) WPT-470 (Gold) WPT-471 (Tin)
3U2Z-14S411-LVA 3U2Z-14S411-MGA 3U2Z-14S411-MNA 3U2Z-14S411-MTA 3U2Z-14S411-MSA 3U2Z-14S411-MXA
WPT-473 (Tin) WPT-484 (Tin) WPT-492 (Tin) WPT-494 (Tin) WPT-497 (Tin) WPT-520 (Tin)
3U2Z-14S411-NEA 3U2Z-14S411-PZA 3U2Z-14S411-CMA 3U2Z-14S411-NZA 3U2Z-14S411-PYA 3U2Z-14S411-TYA
2-Cavity Connectors
WPT-530 (Tin) WPT-544 (Tin) WPT-545 (Tin) WPT-551 (Tin) WPT-564 (Tin) WPT-565 (Tin)
3U2Z-14S411-HCA 3U2Z-14S411-URA 3U2Z-14S411-USA 3U2Z-14S411-LPA 3U2Z-14S411-SFA 3U2Z-14S411-STA
WPT-572 (Tin) WPT-579 (Tin) WPT-595 (Tin) WPT-597 (Tin) WPT-634 (Tin) WPT-664 (Tin)
3U2Z-14S411-VPA 3U2Z-14S411-SMA 3U2Z-14S411-XLA 3U2Z-14S411-XPA 3U2Z-14S411-AHAA 3U2Z-14S411-AXAA
WPT-675 (Tin) WPT-687 (Tin) WPT-692 (Tin) WPT-698 (Tin) WPT-713 (Tin) WPT-717 (Gold)
3U2Z-14S411-CSAA 3U2Z-14S411-ZAA 3U2Z-14S411-CJAA 3U2Z-14S411-CUAA 3U2Z-14S411-EEAA 3U2Z-14S411-ELAA
WPT-719 (Tin) WPT-751 (Tin) WPT-772 (Tin) WPT-776 (Gold) WPT-778 (Tin) WPT-789 (Tin)
3U2Z-14S411-EPAA 3U2Z-14S411-EMAA 3U2Z-14S411-CPAA 3U2Z-14S411-ERAA 3U2Z-14S411-EUAA 3U2Z-14S411-DKAA
11 2-Cavity Connectors 11
WPT-819 (Tin) WPT-822 (Tin) WPT-823 (Tin) WPT-824 (Tin) WPT-826 (Tin) WPT-829 (Tin)
4U2Z-14S411-BA 4U2Z-14S411-DA 3U2Z-14S411-TFA 3U2Z-14S411-ZLA 4U2Z-14S411-FA 2U2Z-14S411-BB
WPT-830 (Tin) WPT-835 (Tin) WPT-838 (Tin) WPT-841 (Tin) WPT-856 (Tin) WPT-861 (Tin)
5C3Z-14S411-AA 4U2Z-14S411-NA 4U2Z-14S411-SA 5U2Z-14S411-AA 5U2Z-14S411-NA 5U2Z-14S411-VA
2-Cavity Connectors
WPT-867 (Tin) WPT-868 (Tin) WPT-869 (Tin) WPT-871 (Gold) WPT-884 (Tin) WPT-885 (Tin)
6U2Z-14S411-BA 6U2Z-14S411-CA 6U2Z-14S411-DA 6U2Z-14S411-GA 7U2Z-14S411-BA 7U2Z-14S411-CA
WPT-896 (Tin) WPT-897 (Tin) WPT-904 (Tin) WPT-905 (Tin) WPT-908 (Tin) WPT-910 (Tin)
7U2Z-14S411-PA 7U2Z-14S411-RA 8U2Z-14S411-GA 8U2Z-14S411-EA 8U2Z-14S411-MA 8U2Z-14S411-SA
WPT-913 (Gold) WPT-914 (Gold) WPT-916 (Tin) WPT-917 (Tin) WPT-948 WPT-952 (Silver)
8U2Z-14S411-KA 8U2Z-14S411-YA 8U2Z-14S411-PA 8U2Z-14S411-VA (Tin greased) 3U2Z-14S411-VZB
3U2Z-14S411-EKB
WPT-964 (Tin) WPT-965 (Silver) WPT-966 (Silver) WPT-967 (Tin) WPT-969 (Tin) WPT-980 (Tin)
1U2Z-14S411-BDB 3U2Z-14S411-AEB 3U2Z-14S411-CNB 3U2Z-14S411-CZB 3U2Z-14S411-EPAB 5U2Z-14S411-EB
12 2-Cavity Connectors 12
WPT-1021 WPT-1024 (Tin) WPT-1026 (Tin) WPT-1027 (Tin) WPT-1051 (Silver) WPT-1052
(Tin greased) 3U2Z-14S411-ZLB 9U2Z-14S411-ABA 9U2Z-14S411-ANA 5U2Z-14S411-ZB (Tin greased)
3U2Z-14S411-DLAB 3U2Z-14S411-JLB
WPT-1075 (Tin) WPT-1077 (Tin) WPT-1078 WPT-1080 (Tin) WPT-1081 WPT-1082 (Silver)
9U2Z-14S411-AMA 3U2Z-14S411-FDB (Tin greased) 1U2Z-14S411-FC (Tin greased) AU2Z-14S411-EA
3U2Z-14S411-LAB 3U2Z-14S411-BNB
WPT-1133 (Silver) WPT-1134 (Tin) WPT-1137 (Tin) WPT-1149 (Tin) WPT-1150 (Tin) WPT-1153
BU2Z-14S411-FA BU2Z-14S411-HA 3U2Z-14S411-DUAB 6U2Z-14S411-PB AU2Z-14S411-AYA (Tin greased)
3U2Z-14S411-XYB
2-Cavity Connectors
WPT-1156 (Tin) WPT-1158 (Tin) WPT-1163 (Silver) WPT-1172 (Gold) WPT-1181 (Silver) WPT-1186
BU2Z-14S411-KA 3U2Z-14S411-ACAB 3U2Z-14S411-JYB 8U2Z-14S411-ABB BU2Z-14S411-ABA (Tin greased)
BU2Z-14S411-AKA
WPT-1282 WPT-1300 WPT-1302 (Silver) WPT-1303 (Silver) WPT-1306 (Silver) WPT-1314 (Silver)
(Tin greased) (Tin greased) CU2Z-14S411-ARA CU2Z-14S411-ATA AU2Z-14S411-AGB 8U2Z-14S411-AAC
CU2Z-14S411-XA 3U2Z-14S411-VBB
WPT-1322 WPT-1325 WPT-1331 (Silver) WPT-1336 (Tin) WPT-1340 (Silver) WPT-1347 (Tin)
(Tin greased) (Tin greased) DU2Z-14S411-BA DU2Z-14S411-KA AU2Z-14S411-NB DU2Z-14S411-NA
3U2Z-14S411-CSAB 3U2Z-14S411-LXB
WPT-1372 (Tin) WPT-1377 WPT-1378 WPT-1383 (Gold) WPT-1384 (Tin) WPT-1385 (Tin)
3U2Z-14S411-BJB (Tin greased) (Tin greased) EU2Z-14S411-DA EU2Z-14S411-JA DU2Z-14S411-APA
3U2Z-14S411-ATA DU2Z-14S411-AXA
2-Cavity Connectors
16 3-Cavity Connectors 16
WPT-105 (Tin) WPT-106 (Tin) WPT-109 (Tin) WPT-118 (Tin) WPT-119 (Tin) WPT-151 (Tin)
1U2Z-14S411-DA 1U2Z-14S411-EA 1U2Z-14S411-HA 1U2Z-14S411-TA 1U2Z-14S411-UA 1U2Z-14S411-BFA
WPT-168 (Tin) WPT-196 (Tin) WPT-203 (Tin) WPT-210 (Tin) WPT-214 (Tin) WPT-224 (Tin)
1U2Z-14S411-ADA 3U2Z-14S411-NA 3U2Z-14S411-AZA 3U2Z-14S411-BRA 3U2Z-14S411-CLA 3U2Z-14S411-AA
3-Cavity Connectors
WPT-229 (Tin) WPT-239 (Tin) WPT-241 (Tin) WPT-243 (Tin) WPT-301 (Tin) WPT-328 (Tin)
3U2Z-14S411-CBA 3U2Z-14S411-DUA 3U2Z-14S411-DXA 3U2Z-14S411-ECA 3U2Z-14S411-BHA 3U2Z-14S411-FLA
WPT-348 (Tin) WPT-350 (Tin) WPT-362 (Tin) WPT-397 (Tin) WPT-406 (Tin) WPT-414 (Tin)
3U2Z-14S411-GGA 3U2Z-14S411-KEA 3U2Z-14S411-ESA 3U2Z-14S411-CFA 3U2Z-14S411-KHA 3U2Z-14S411-FHA
WPT-419 (Tin) WPT-474 (Tin) WPT-493 (Tin) WPT-517 (Tin) WPT-526 (Tin) WPT-535 (Tin)
3U2Z-14S411-JSA 3U2Z-14S411-NFA 3U2Z-14S411-NPA 3U2Z-14S411-TNA 3U2Z-14S411-SRA 3U2Z-14S411-SHA
WPT-560 (Gold) WPT-584 (Tin) WPT-593 (Tin) WPT-594 (Tin) WPT-601 (Tin) WPT-603 (Tin)
3U2Z-14S411-LZA 3U2Z-14S411-PSA 3U2Z-14S411-VXA 3U2Z-14S411-VYA 3U2Z-14S411-XXA 3U2Z-14S411-XZA
17 3-Cavity Connectors 17
WPT-617 (Tin) WPT-660 (Tin) WPT-723 (Tin) WPT-754 (Tin) WPT-763 (Tin) WPT-777 (Gold)
3U2Z-14S411-TEA 3U2Z-14S411-ZNA 3U2Z-14S411-XGA 3U2Z-14S411-EYAA 3U2Z-14S411-UNA 3U2Z-14S411-ESAA
WPT-801 (Tin) WPT-805 (Gold) WPT-859 (Tin) WPT-870 (Tin) WPT-878 (Tin) WPT-899 (Gold)
3U2Z-14S411-RSA 3U2Z-14S411-YLA 5U2Z-14S411-XA 6U2Z-14S411-EA 6U2Z-14S411-FA 7U2Z-14S411-SA
3-Cavity Connectors
WPT-911 (Silver) WPT-931 (Silver) WPT-970 (Tin) WPT-990 WPT-993 WPT-1001 (Tin)
8U2Z-14S411-LA 9U2Z-14S411-EA 3U2Z-14S411-EVAB (Tin greased) (Tin greased) 3U2Z-14S411-NUB
3U2Z-14S411-ZB 1U2Z-14S411-AFB
WPT-1147 (Silver) WPT-1160 (Tin) WPT-1162 WPT-1167 (Silver) WPT-1180 (Silver) WPT-1182 (Silver)
3U2Z-14S411-BHAB 3U2Z-14S411-SJB (Tin greased) 3U2Z-14S411-FHAB AU2Z-14S411-ASA BU2Z-14S411-AFA
3U2Z-14S411-CCB
WPT-1240 WPT-1247 (Tin) WPT-1261 (Silver) WPT-1264 (Silver) WPT-1281 WPT-1284 (Silver)
(Tin greased) 1U2Z-14S411-JB CU2Z-14S411-MA CU2Z-14S411-KA (Tin greased) CU2Z-14S411-AFA
CU2Z-14S411-BA CU2Z-14S411-PA
3-Cavity Connectors
20 4-Cavity Connectors 20
WPT-111 (Gold) WPT-112 (Gold) WPT-114 (Tin) WPT-115 (Tin) WPT-123 (Gold) WPT-152
1U2Z-14S411-KA 1U2Z-14S411-LA 1U2Z-14S411-NA 1U2Z-14S411-PA 1U2Z-14S411-ZA (Tin greased)
1U2Z-14S411-BGA
WPT-169 (Tin) WPT-171 (Tin) WPT-182 (Tin) WPT-207 (Tin) WPT-225 (Gold) WPT-234 (Tin)
1U2Z-14S411-AEA 1U2Z-14S411-AGA 1U2Z-14S411-AUA 3U2Z-14S411-ACA 3U2Z-14S411-APA 3U2Z-14S411-DA
4-Cavity Connectors
WPT-253 (Tin) WPT-293 (Tin) WPT-303 (Tin) WPT-307 (Tin) WPT-344 (Tin) WPT-347 (Tin)
3U2Z-14S411-FAA 3U2Z-14S411-JRA 3U2Z-14S411-BVA 3U2Z-14S411-DAA 3U2Z-14S411-AVA 3U2Z-14S411-FMA
WPT-376 (Tin) WPT-380 (Tin) WPT-392 (Tin) WPT-394 (Tin) WPT-395 (Tin) WPT-408 (Tin)
3U2Z-14S411-EDA 3U2Z-14S411-FXA 3U2Z-14S411-KJA 3U2Z-14S411-KNA 3U2Z-14S411-KVA 3U2Z-14S411-KSA
WPT-417 (Tin) WPT-448 (Tin) WPT-454 (Tin) WPT-480 (Tin) WPT-511 (Tin) WPT-542 (Tin)
3U2Z-14S411-HXA 3U2Z-14S411-MCA 3U2Z-14S411-NCA 3U2Z-14S411-PGA 3U2Z-14S411-SZA 3U2Z-14S411-UMA
WPT-556 (Tin) WPT-574 (Tin) WPT-582 (Tin) WPT-629 (Tin) WPT-654 (Tin) WPT-668 (Tin)
3U2Z-14S411-LJA 3U2Z-14S411-VUA 3U2Z-14S411-XHA 3U2Z-14S411-ZJA 3U2Z-14S411-TMA 3U2Z-14S411-CCAA
21 4-Cavity Connectors 21
WPT-670 (Tin) WPT-685 (Tin) WPT-688 (Tin) WPT-703 (Tin) WPT-704 (Tin) WPT-709 (Tin)
3U2Z-14S411-CFAA 3U2Z-14S411-VFA 3U2Z-14S411-ZEA 3U2Z-14S411-EAAA 3U2Z-14S411-SCA 3U2Z-14S411-DGAA
WPT-726 (Tin) WPT-742 (Tin) WPT-750 (Tin) WPT-755 (Tin) WPT-788 (Tin) WPT-807
3U2Z-14S411-ZDA 3U2Z-14S411-BKAA 3U2Z-14S411-EJAA 3U2Z-14S411-FAAA 3U2Z-14S411-BAAA (Tin & Gold)
3U2Z-14S411-XBA
4-Cavity Connectors
WPT-818 (Tin) WPT-831 (Tin) WPT-840 (Tin) WPT-858 (Tin) WPT-893 WPT-894
3U2Z-14S411-FFAA 4U2Z-14S411-HA 5U2Z-14S411-JA 5U2Z-14S411-RA (Tin & Gold) (Tin & Gold)
7U2Z-14S411-LA 7U2Z-14S411-MA
WPT-912 (Tin) WPT-925 (Silver) WPT-935 (Tin) WPT-940 (Silver) WPT-977 (SIlver) WPT-981
8U2Z-14S411-HA 8U2Z-14S411-TA 9U2Z-14S411-LA 9U2Z-14S411-MA 3U2Z-14S411-LUB (Tin greased)
5U2Z-14S411-HB
WPT-982 (Silver) WPT-1008 WPT-1012 (Tin) WPT-1013 (Silver) WPT-1014 (Tin) WPT-1015 (Tin)
6U2Z-14S411-JB (Tin greased) 9U2Z-14S411-PA 9U2Z-14S411-TA 1U2Z-14S411-BB 3U2Z-14S411-BCAB
3U2Z-14S411-HSB
WPT-1016 (Silver) WPT-1041 (Tin) WPT-1055 (Silver) WPT-1072 (Tin) WPT-1074 WPT-1076
3U2Z-14S411-FFB 9U2Z-14S411-AJA 3U2Z-14S411-KYB AU2Z-14S411-RA (Tin greased) (Tin greased)
9U2Z-14S411-ALA 3U2Z-14S411-BUB
22 4-Cavity Connectors 22
WPT-1088 WPT-1102 (Tin) WPT-1127 (Tin) WPT-1135 WPT-1139 (Silver) WPT-1143 (Tin)
(Tin greased) AU2Z-14S411-BAA BU2Z-14S411-DA (Tin greased) 3U2Z-14S411-PRC AU2Z-14S411-BPA
9U2Z-14S411-AFA BU2Z-14S411-JA
WPT-1154 (Silver) WPT-1155 (Tin) WPT-1171 (Silver) WPT-1177 (Tin) WPT-1191 WPT-1194
9U2Z-14S411-ACA AU2Z-14S411-BRA BU2Z-14S411-TA AU2Z-14S411-BHA (Tin greased) (Tin greased)
BU2Z-14S411-AEA 9U2Z-14S411-AKB
4-Cavity Connectors
WPT-1220 (Silver) WPT-1232 WPT-1239 (Silver) WPT-1252 WPT-1258 (Tin) WPT-1260 (Tin)
BU2Z-14S411-AXA (Tin greased) CU2Z-14S411-AA (Tin greased) 3U2Z-14S411-DB CU2Z-14S411-JA
BU2Z-14S411-ATA CU2Z-14S411-FA
WPT-1262 (Tin) WPT-1273 (Silver) WPT-1288 (Silver) WPT-1290 WPT-1293 (Silver) WPT-1298
1U2Z-14S411-AGB 9U2Z-14S411-ADB CU2Z-14S411-ZA (Tin greased) 3U2Z-14S411-UC (Tin greased)
CU2Z-14S411-AHA 3U2Z-14S411-HZB
WPT-1307 (Silver) WPT-1309 (Silver) WPT-1311 (Tin) WPT-1319 (Tin) WPT-1323 WPT-1328 (Silver)
CU2Z-14S411-AGA CU2Z-14S411-AYA CU2Z-14S411-BAA DU2Z-14S411-GA (Tin greased) DU2Z-14S411-AA
3U2Z-14S411-FAB
WPT-1339 (Silver) WPT-1343 (Tin) WPT-1346 (Tin) WPT-1350 (Tin) WPT-1361 WPT-1373
3U2Z-14S411-SPC DU2Z-14S411-ABA DU2Z-14S411-MA DU2Z-14S411-UA (Tin greased) (Tin greased)
9U2Z-14S411-LB 3U2Z-14S411-DGAB
23 4-Cavity Connectors 23
4-Cavity Connectors
24 5-Cavity Connectors 24
WPT-153 (Tin) WPT-300 (Tin) WPT-319 (Tin) WPT-346 (Tin) WPT-415 (Tin) WPT-523 (Tin)
1U2Z-14S411-BHA 3U2Z-14S411-BDA 3U2Z-14S411-GA 3U2Z-14S411-DDA 3U2Z-14S411-GAA 3U2Z-14S411-UCA
WPT-524 (Tin) WPT-527 (Tin) WPT-566 (Tin) WPT-638 (Tin) WPT-662 (Tin) WPT-697 (Tin)
3U2Z-14S411-UGA 3U2Z-14S411-TXA 3U2Z-14S411-UEA 3U2Z-14S411-ASAA 3U2Z-14S411-ZVA 3U2Z-14S411-CHAA
5-Cavity Connectors
WPT-705 (Tin) WPT-721 (Tin) WPT-738 (Tin) WPT-780 (Tin) WPT-802 (Tin) WPT-882 (Tin)
3U2Z-14S411-VSA 3U2Z-14S411-SBA 3U2Z-14S411-BFAA 3U2Z-14S411-SEA 3U2Z-14S411-TAA 6U2Z-14S411-TA
WPT-163 (Tin) WPT-246 (Tin) WPT-259 (Tin) WPT-271 (Tin) WPT-285 (Tin) WPT-297 (Tin)
1U2Z-14S411-BUA 3U2Z-14S411-ENA 3U2Z-14S411-ANA 3U2Z-14S411-GTA 3U2Z-14S411-JBA 3U2Z-14S411-KGA
WPT-363 WPT-369 (Tin) WPT-375 (Tin) WPT-388 (Tin) WPT-435 (Gold) WPT-455 (Tin)
(Tin & Gold) 3U2Z-14S411-ZA 3U2Z-14S411-EAA 3U2Z-14S411-FA 3U2Z-14S411-MKA 3U2Z-14S411-NDA
3U2Z-14S411-HEA
6-Cavity Connectors
WPT-502 (Tin) WPT-505 (Tin) WPT-586 (Tin) WPT-598 (Tin) WPT-622 (Tin) WPT-663 (Tin)
3U2Z-14S411-RKA 3U2Z-14S411-SDA 3U2Z-14S411-RRA 3U2Z-14S411-XRA 3U2Z-14S411-XUA 3U2Z-14S411-ANAA
WPT-695 (Tin) WPT-733 (Tin) WPT-832 (Tin) WPT-845 (Tin) WPT-855 (Tin) WPT-903 (Tin)
3U2Z-14S411-TVA 3U2Z-14S411-AVAA 4U2Z-14S411-JA 5U2Z-14S411-FA 5U2Z-14S411-MA 8U2Z-14S411-AA
WPT-923 (Silver) WPT-929 (Silver) WPT-944 (Silver) WPT-958 WPT-962 (Silver) WPT-963 (Tin)
8U2Z-14S411-XA 9U2Z-14S411-BA 9U2Z-14S411-NA (Tin & Silver) 3U2Z-14S411-JBB 5U2Z-14S411-YB
6U2Z-14S411-LB
WPT-971 (Silver) WPT-973 (Silver) WPT-978 WPT-1004 (Tin) WPT-1006 (Silver) WPT-1019 (Tin)
3U2Z-14S411-FEAB 3U2Z-14S411-FNB (Tin greased) 3U2Z-14S411-XTB 7U2Z-14S411-NB 3U2Z-14S411-XVB
3U2Z-14S411-MLB
26 6-Cavity Connectors 26
WPT-1028 (Silver) WPT-1029 (Tin) WPT-1032 (Silver) WPT-1049 (Silver) WPT-1056 (Tin) WPT-1060
9U2Z-14S411-APA 9U2Z-14S411-ASA 9U2Z-14S411-XA 9U2Z-14S411-UA 3U2Z-14S411-SKB (Tin greased)
3U2Z-14S411-HDB
WPT-1207 (Silver) WPT-1213 WPT-1237 (Silver) WPT-1241 (Silver) WPT-1242 (Silver) WPT-1249 (Silver)
5U2Z-14S411-ABC (Tin greased) 3U2Z-14S411-PNB 3U2Z-14S411-FJAC 3U2Z-14S411-MJB 3U2Z-14S411-BYAC
BU2Z-14S411-AUA
WPT-1299 (Tin) WPT-1312 WPT-1327 (Silver) WPT-1329 (Tin) WPT-1330 (Tin) WPT-1334
3U2Z-14S411-NBB (Tin greased) 3U2Z-14S411-BSB DU2Z-14S411-EA DU2Z-14S411-HA (Tin greased)
CU2Z-14S411-BBA DU2Z-14S411-FA
27 6-Cavity Connectors 27
WPT-1335 (Tin) WPT-1338 (Silver) WPT-1344 (Tin) WPT-1351 (Silver) WPT-1355 WPT-1375 (Silver)
DU2Z-14S411-JA 9U2Z-14S411-BB DU2Z-14S411-AEA DU2Z-14S411-VA (Tin greased) EU2Z-14S411-BA
DU2Z-14S411-AFA
WPT-1382 WPT-1389
(Tin greased) (Tin greased)
DU2Z-14S411-AVA EU2Z-14S411-FA
6-Cavity Connectors
28 7-Cavity Connectors 28
WPT-179 (Tin) WPT-181 (Tin) WPT-193 (Tin) WPT-400 (Tin) WPT-421 (Tin) WPT-513 (Tin)
1U2Z-14S411-ARA 1U2Z-14S411-ATA 3U2Z-14S411-SA 3U2Z-14S411-DJA 3U2Z-14S411-KCA 3U2Z-14S411-TCA
WPT-567 (Tin) WPT-596 (Tin) WPT-606 (Tin) WPT-821 (Tin) WPT-839 (Tin) WPT-846 (Tin)
3U2Z-14S411-VHA 3U2Z-14S411-XMA 3U2Z-14S411-YGA 4U2Z-14S411-AA 5U2Z-14S411-BA 5U2Z-14S411-GA
7-Cavity Connectors
WPT-100 (Tin) WPT-117 (Tin) WPT-155 (Tin) WPT-162 (Tin) WPT-172 (Tin) WPT-185 (Tin)
1W3Z-14S411-AB 1U2Z-14S411-SA 1U2Z-14S411-BKA 1U2Z-14S411-BTA 1U2Z-14S411-AHA 1U2Z-14S411-AYA
WPT-199 (Tin) WPT-215 (Tin) WPT-218 (Tin) WPT-220 (Tin) WPT-227 (Tin) WPT-240 (Tin)
3U2Z-14S411-MA 3U2Z-14S411-CPA 3U2Z-14S411-CYA 3U2Z-14S411-DMA 3U2Z-14S411-BPA 3U2Z-14S411-DVA
8-Cavity Connectors
WPT-252 (Tin) WPT-257 (Tin) WPT-264 (Tin) WPT-270 (Tin) WPT-275 (Tin) WPT-283 (Tin)
3U2Z-14S411-EZA 3U2Z-14S411-AKA 3U2Z-14S411-FYA 3U2Z-14S411-GSA 3U2Z-14S411-HAA 3U2Z-14S411-HUA
WPT-298 (Tin) WPT-299 (Tin) WPT-313 (Tin) WPT-337 (Tin) WPT-379 (Tin) WPT-382 (Tin)
3U2Z-14S411-BBA 3U2Z-14S411-BCA 3U2Z-14S411-EFA 3U2Z-14S411-JTA 3U2Z-14S411-FSA 3U2Z-14S411-GKA
WPT-389 (Tin) WPT-399 (Tin) WPT-464 (Tin) WPT-485 (Tin) WPT-487 (Tin) WPT-521 (Tin)
3U2Z-14S411-FVA 3U2Z-14S411-DFA 3U2Z-14S411-PMA 3U2Z-14S411-RAA 3U2Z-14S411-RGA 3U2Z-14S411-TZA
WPT-534 (Tin) WPT-547 (Tin) WPT-557 (Tin) WPT-561 (Tin) WPT-642 (Tin) WPT-643 (Tin)
3U2Z-14S411-PJA 3U2Z-14S411-UUA 3U2Z-14S411-LLA 3U2Z-14S411-RFA 3U2Z-14S411-AZAA 3U2Z-14S411-BNAA
30 8-Cavity Connectors 30
WPT-665 (Tin) WPT-678 (Tin) WPT-696 (Tin) WPT-731 (Tin) WPT-737 (Tin) WPT-769 (Tin)
3U2Z-14S411-BLAA 3U2Z-14S411-NNA 3U2Z-14S411-BTAA 3U2Z-14S411-AJAA 3U2Z-14S411-BEAA 3U2Z-14S411-TPA
WPT-860 (Tin) WPT-945 (Silver) WPT-961 (Silver) WPT-991 (Silver) WPT-995 (Silver) WPT-998 (Silver)
5U2Z-14S411-UA 9U2Z-14S411-RA 3U2Z-14S411-RHB 3U2Z-14S411-LCB 3U2Z-14S411-BGB 3U2Z-14S411-DLB
8-Cavity Connectors
WPT-1031 WPT-1034 (Tin) WPT-1043 (Tin) WPT-1045 WPT-1046 (Tin) WPT-1050 (Tin)
(Tin & Silver) 3U2Z-14S411-ZTB 3U2Z-14S411-UZB (Tin greased) 1W3Z-14S411-AC AU2Z-14S411-FA
3U2Z-14S411-PPB 1U2Z-14S411-AHC
WPT-1183 (Silver) WPT-1184 WPT-1187 (Silver) WPT-1198 (Silver) WPT-1206 (Tin) WPT-1212
BU2Z-14S411-AGA (Tin greased) BU2Z-14S411-ALA 4U2Z-14S411-LC 3U2Z-14S411-ZBB (Tin & Silver)
BU2Z-14S411-AHA 3U2Z-14S411-DYB
WPT-1215 (Tin) WPT-1219 (Silver) WPT-1233 (Silver) WPT-1270 (Silver) WPT-1272 (Tin) WPT-1276 (Silver)
3U2Z-14S411-CTC 3U2Z-14S411-DAAC BU2Z-14S411-AZA CU2Z-14S411-VA 3U2Z-14S411-RGB CU2Z-14S411-ALA
31 8-Cavity Connectors 31
WPT-1295 (Silver) WPT-1310 (Silver) WPT-1324 WPT-1332 (Tin) WPT-1333 (Silver) WPT-1349
1U2Z-14S411-BRD CU2Z-14S411-AZA (Tin greased) DU2Z-14S411-CA DU2Z-14S411-DA (Tin greased)
3U2Z-14S411-GSB DU2Z-14S411-TA
8-Cavity Connectors
32 9-Cavity Connectors 32
WPT-165 (Tin) WPT-317 (Tin) WPT-424 (Tin) WPT-504 (Tin) WPT-516 (Tin) WPT-568 (Tin)
1U2Z-14S411-AAA 3U2Z-14S411-KTA 3U2Z-14S411-LGA 3U2Z-14S411-SAA 3U2Z-14S411-TJA 3U2Z-14S411-VJA
WPT-607 (Tin) WPT-611 (Tin) WPT-672 (Tin) WPT-886 (Tin) WPT-1283 WPT-1392 (Tin)
3U2Z-14S411-YHA 3U2Z-14S411-YNA 3U2Z-14S411-CLAA 7U2Z-14S411-AA (Tin greased) 1U2Z-14S411-AAB
CU2Z-14S411-ACA
9-Cavity Connectors
33 10-Cavity Connectors 33
WPT-289 (Tin) WPT-320 (Tin) WPT-367 (Tin) WPT-570 (Tin) WPT-575 (Tin) WPT-619 (Tin)
3U2Z-14S411-JGA 3U2Z-14S411-KA 3U2Z-14S411-AHA 3U2Z-14S411-VLA 3U2Z-14S411-VVA 3U2Z-14S411-XAA
WPT-667 (Tin) WPT-676 (Tin) WPT-762 (Tin) WPT-782 (Tin) WPT-784 (Tin) WPT-785 (Tin)
3U2Z-14S411-CAAA 3U2Z-14S411-CTAA 3U2Z-14S411-TKA 3U2Z-14S411-XSA 3U2Z-14S411-ZPA 3U2Z-14S411-ZXA
10-11-Cavity Connectors
WPT-842 (Tin) WPT-934 (Silver) WPT-936 (Silver) WPT-1037 (Silver) WPT-1042 WPT-1083 (Silver)
3U2Z-14S411-CA 3U2Z-14S411-LSB 3U2Z-14S411-YAB 1U2Z-14S411-BLB (Tin & Silver) AU2Z-14S411-AHA
AU2Z-14S411-CA
WPT-1348 WPT-1354
(Tin greased) (Tin & Silver)
DU2Z-14S411-PA DU2Z-14S411-ADA
11-Cavity Connectors
WPT-178 (Tin) WPT-187 (Tin) WPT-813 (Tin) WPT-1248 (Tin) WPT-320 (Tin)
1U2Z-14S411-APA 1U2Z-14S411-BXA 3U2Z-14S411-EDAA 3U2Z-14S411-BXB 3U2Z-14S411-KA
34 12-Cavity Connectors 34
WPT-164 (Tin) WPT-192 (Tin) WPT-208 (Tin) WPT-396 (Tin) WPT-463 (Tin) WPT-503 (Tin)
1U2Z-14S411-BVA 3U2Z-14S411-RA 3U2Z-14S411-BLA 3U2Z-14S411-BKA 3U2Z-14S411-PLA 3U2Z-14S411-RNA
WPT-571 (Tin) WPT-590 (Tin) WPT-591 (Tin) WPT-613 (Tin) WPT-620 (Tin) WPT-637 (Tin)
3U2Z-14S411-VNA 3U2Z-14S411-VCA 3U2Z-14S411-VEA 3U2Z-14S411-YRA 3U2Z-14S411-XCA 3U2Z-14S411-ARAA
12-Cavity Connectors
WPT-647 (Tin) WPT-673 (Tin) WPT-691 (Tin) WPT-820 (Tin) WPT-919 WPT-928 (Tin)
3U2Z-14S411-BUAA 3U2Z-14S411-CNAA 3U2Z-14S411-AGAA 4U2Z-14S411-CA (Tin & Gold) 3U2Z-14S411-ZMB
8U2Z-14S411-FA
WPT-930 (Silver) WPT-933 (Tin) WPT-937 WPT-939 (Silver) WPT-949 (Silver) WPT-996
9U2Z-14S411-DA 9U2Z-14S411-FA (Tin & Silver) 9U2Z-14S411-GA 3U2Z-14S411-BMAB (Tin greased)
5U2Z-14S411-KB 3U2Z-14S411-CEAB
WPT-176 (Tin) WPT-308 (Tin) WPT-475 (Tin) WPT-577 (Tin) WPT-610 (Tin) WPT-1020 (Tin)
1U2Z-14S411-AMA 3U2Z-14S411-DNA 3U2Z-14S411-NJA 3U2Z-14S411-NKA 3U2Z-14S411-YMA 6U2Z-14S411-RC
14-Cavity Connectors
13-14-15-Cavity Connectors
WPT-296 (Tin) WPT-331 (Tin) WPT-747 (Tin) WPT-955 WPT-974 (Silver) WPT-1140
3U2Z-14S411-KFA 3U2Z-14S411-GFA 3U2Z-14S411-DRAA (Tin & Silver) 3U2Z-14S411-JEB (Tin & Silver)
3U2Z-14S411-BJAC 3U2Z-14S411-ZZB
WPT-1374 (Silver)
DU2Z-14S411-XA
15-Cavity Connectors
WPT-198 (Tin) WPT-202 (Tin) WPT-242 (Tin) WPT-278 (Tin) WPT-326 (Tin) WPT-332 (Tin)
3U2Z-14S411-ABA 3U2Z-14S411-AUA 3U2Z-14S411-EBA 3U2Z-14S411-HHA 3U2Z-14S411-JVA 3U2Z-14S411-GMA
WPT-341 (Tin) WPT-615 (Tin) WPT-632 (Tin) WPT-645 (Tin) WPT-650 (Tin) WPT-689 (Tin)
3U2Z-14S411-FKA 3U2Z-14S411-LKA 3U2Z-14S411-ABAA 3U2Z-14S411-BRAA 3U2Z-14S411-LFA 3U2Z-14S411-ZSA
16-Cavity Connectors
WPT-791 (Tin) WPT-891 WPT-892 WPT-918 (Tin) WPT-938 (Silver) WPT-959 (Silver)
3U2Z-14S411-ETAA (Tin & Silver) (Tin & Silver) 8U2Z-14S411-UA 9U2Z-14S411-JA 3U2Z-14S411-BDAB
7U2Z-14S411-JA 7U2Z-14S411-KA
WPT-1142 WPT-1145 (Silver) WPT-1152 (Silver) WPT-1165 (Tin) WPT-1170 WPT-1176 (Tin)
(Tin & Silver) BU2Z-14S411-GA 3U2Z-14S411-AJD AU2Z-14S411-BGA (Tin greased) AU2Z-14S411-BFA
7U2Z-14S411-JB BU2Z-14S411-SA
WPT-1179 WPT-1189 WPT-1279 (Silver) WPT-1294 (Silver) WPT-1320 (Silver) WPT-1321 (Silver)
(Tin & Silver) (Tin greased) CU2Z-14S411-ADA CU2Z-14S411-AJA DU2Z-14S411-RA DU2Z-14S411-SA
3U2Z-14S411-EKB BU2Z-14S411-ZA
37 16-Cavity Connectors 37
17-Cavity Connectors
16-17-18-19-Cavity Connectors
WPT-157 (Tin)
1U2Z-14S411-BMA
18-Cavity Connectors
19-Cavity Connectors
WPT-1398
(Tin greased)
EU2Z-14S411-CA
38 20-Cavity Connectors 38
WPT-180 (Tin) WPT-184 (Tin) WPT-255 (Tin) WPT-889 (Silver) WPT-890 (Silver) WPT-1040 (Silver)
1U2Z-14S411-ASA 1U2Z-14S411-AXA 3U2Z-14S411-FCA 7U2Z-14S411-GA 7U2Z-14S411-HA 9U2Z-14S411-AHA
24-Cavity Connectors
WPT-1033 WPT-1126
(Tin & Silver) (Tin & Silver)
9U2Z-14S411-YA AU2Z-14S411-ATA
26-Cavity Connectors
WPT-1234
(Tin & Silver)
BU2Z-14S411-BAA
46-Cavity Connectors
38-46-58-98-Cavity Connectors
WPT-1356
(Tin greased)
BU2Z-14S411-BBB
58-Cavity Connectors
WPT-1445 (Silver)
FU2Z-14S411-VA
98-Cavity Connectors
WPT-1353
(Tin & Silver)
AU2Z-14S411-ALA
40 WPT Number/Service Number Index 40
WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page
100 1W3Z-14S411-AB 29 152 1U2Z-14S411-BGA 20 184 1U2Z-14S411-AXA 38 229 3U2Z-14S411-CBA 16 274 3U2Z-14S411-GXA 8
• Clock • Fuel Pump/Sending Unit • Radio • Mirror - Sideview • Lamp - Dome
• Module - Radio Power Antenna • Lamp - Fog/Driving • Switch - Overdrive Cancel • Lamp - Dome/Map
• Motor - Heater/AC Blend Door • Module - Radio Power Antenna 185 1U2Z-14S411-AYA 29 • Switch - Traction Control
• Switch - Message Center • Sensor - Air Suspension • Radio 275 3U2Z-14S411-HAA 29
• Switch - Radio Antenna • Sensor - Catalyst Monitor 234 3U2Z-14S411-DA 20 • Solenoid - Electronic Automatic Tempera-
187 1U2Z-14S411-BXA 33 • Motor - Radio Power Antenna ture Control (EATC)
• Sensor - Cylinder Head Temperature • Switch - Headlamp
104 1U2Z-14S411-CA 9 • Sensor - O2 (HEGO/ EGO) • Sensor - Compass • Switch - Heater A/C Temp Control
• Motor - Heater/AC Blower (Auxiliary) • Switch - Door Cylinder Disarm (Anti- 192 3U2Z-14S411-RA 34
• Motor - Heater/AC Blower (Front) 236 3U2Z-14S411-PA 9 278 3U2Z-14S411-HHA 36
Theft) • Instrument Cluster • Mirror - Vanity • Instrument Cluster
105 1U2Z-14S411-DA 16 • Switch - Door Lock (LH) • Module - Seat Memory
• Switch - Door Lock (RH) 193 3U2Z-14S411-SA 28 279 3U2Z-14S411-HKA 37
• Lamp - CHMSL (Center High Mount • Lamp - Dome/Map • Motor - Heater/AC Blower (Auxiliary)
Stop Lamp) • Switch - Hood Ajar • Motor - Heater/AC Blower (Front) • Radio
• Mirror - Rearview (electrochromatic)
• Lamp - Front Cornering/Turn 153 1U2Z-14S411-BHA 24 • Module - Auto Lamps • Radio - Amplifier 283 3U2Z-14S411-HUA 29
• Lamp - Front Turn/ Marker • Module - Variable Speed Blower • Resistor - Blower Motor (Front) • Radio - Amplifier
• Lamp - Park/Turn Controller 194 3U2Z-14S411-ADA 9 • Switch - Heater/A/C Blower (Front) • Switch - Dimmer
• Lamp - Park/Turn/Stop • Solenoid - Electronic Automatic • Lamp - CHMSL (Center High Mount • Switch - Message Center
• Lamp - Rear Turn 237 3U2Z-14S411-TA 8
Temperature Control (EATC) Stop Lamp)
• Lamp - Reverse • Lamp - Courtesy - Reading (Rear) • Sensor - Oil Level 285 3U2Z-14S411-JBA 25
155 1U2Z-14S411-BKA 29 • Lamp - Dome/Map 239 3U2Z-14S411-DUA 16 • Lamp - CHMSL (Center High Mount
106 1U2Z-14S411-EA 16 • Radio • Lamp - Courtesy - Reading (Rear) Stop Lamp)
• Lamp - Front Turn 196 3U2Z-14S411-NA 16 • Mirror - Sideview
• Lamp - Rear Turn 157 1U2Z-14S411-BMA 37 • Sensor - Cam Shaft Position • Lamp - Dome
• Sensor - Power Steering Pressure
• Lamp - Reverse • Radio 240 3U2Z-14S411-DVA 29 • Sensor - Transmission Range
197 3U2Z-14S411-XA 9
109 1U2Z-14S411-HA 16 162 1U2Z-14S411-BTA 29 • Switch - Brake Pedal Position • Switch - Power Mirror • Speaker - Front
• Speaker - Subwoofer
WPT Number/Service Number Index
• Lamp - Front Park • Fuel Pump/Sending Unit • Switch - Radio Antenna 241 3U2Z-14S411-DXA 16
• Lamp - Front Turn/ Marker • Switch - Stop Lamp • Switch - Courtesy Lamp - Liftgate
163 1U2Z-14S411-BUA 25 • Sensor - Adjustable Pedal • Switch - Deck Lid / Lift Gate Ajar
• Lamp - Park/Turn/Stop • Sensor - Memory Seat Position
• Lamp - Reverse • Motor - Windshield Wiper 198 3U2Z-14S411-ABA 36 • Switch - Fog Lamp
• Instrument Cluster 242 3U2Z-14S411-EBA 36 • Switch - Gear Shift Select/Neutral Safety
111 1U2Z-14S411-KA 20 164 1U2Z-14S411-BVA 34 • Switch - Multifunction (Wiper)
• Module - Auto Lamps • Module - Lighting Control
• Sensor - O2 (HEGO/ EGO) • CD Changer • Module - Driver Door • Switch - Overdrive Cancel
• Instrument Cluster • Module - Seat Memory
• Module - Lighting Control • Switch - Power Sliding Door
112 1U2Z-14S411-LA 20 • Radio 243 3U2Z-14S411-ECA 16 • Switch - Reverse Park Aid
• Radio
• Sensor - Catalyst Monitor • Radio - Rear Audio Controls • Lamp - Front Cornering/Turn • Switch - Seat Lumbar
• Sensor - Cylinder Head Temperature 165 1U2Z-14S411-AAA 32
• Fuel Injector • Switch - Seat Passenger Side (2nd Row)
• Sensor - O2 (HEGO/ EGO) 199 3U2Z-14S411-MA 29 244 3U2Z-14S411-EGA 9 • Switch - Traction Control
• Switch - Headlamp • Switch - Air Suspension • Fuel Injector
113 1U2Z-14S411-MA 9 288 3U2Z-14S411-JFA 9
168 1U2Z-14S411-ADA 16 • Switch - Fog Lamp • Switch - Power Steering Pressure
• Motor - Heater/AC Blower (Auxiliary) • Switch - Hazard Warning • Motor - Windshield Washer Fluid Pump
• Motor - Seat Lumbar • Motor - Engine Cooling Fan 246 3U2Z-14S411-ENA 25
• Switch - Seatbelt 169 1U2Z-14S411-AEA 20 202 3U2Z-14S411-AUA 36 • Module - Auto Lamps 289 3U2Z-14S411-JGA 33
• Motor - Engine Cooling Fan • Instrument Cluster • Module - Seat Memory • Actuator - Door Lock
114 1U2Z-14S411-NA 20 • Switch - Door Ajar / Interior Lamp
• Pump - Vacuum • Monitor - Video/DVD
• Resistor - Blower Motor (Front) 203 3U2Z-14S411-AZA 16 • Switch - Wiper Washer - Rear
• Sensor - Barometric Pressure • Lamp - Dome 293 3U2Z-14S411-JRA 20
115 1U2Z-14S411-PA 20 • Sensor - Fuel Tank Pressure Transducer 252 3U2Z-14S411-EZA 29 • Lamp - Dome/Map
• Lamp - Dome/Map
• Resistor - Blower Motor (Auxiliary) • Sensor - Power Steering Pressure • Lamp - Storage Compartment - Cargo • Switch - Door Lock (LH) • Lamp - Map
• Resistor - Blower Motor (Front) • Sensor - Purge Flow • Lamp - Storage Compartment - Trunk • Switch - Door Lock (RH) • Lamp - Overhead Console
• Switch - A/C Compressor Clutch Cycling • Switch - Cargo Lamp • Switch - Power Mirror • Module - Power Moonroof
117 1U2Z-14S411-SA 29 • Switch - A/C High Pressure
• Motor - Heater/AC Blend Door • Switch - Door Ajar/Interior Lamp • Motor - Steering Column Adjust
• Switch - A/C Pressure Cut Off 253 3U2Z-14S411-FAA 20 • Speaker - Tweeter - LH - Front
• Switch - Heater A/C Blower (Rear) • Switch - Power Steering Pressure 207 3U2Z-14S411-ACA 20 • Motor - Heater/AC Blend Door
• Switch - Power Mirror • Speaker - Tweeter - RH - Front
• Switch - Refrigerant Containment • Coil - Ignition • Switch - Dimmer
255 3U2Z-14S411-FCA 38
118 1U2Z-14S411-TA 16 171 1U2Z-14S411-AGA 20 208 3U2Z-14S411-BLA 34 • Switch - Heated Back Light (Rear Defrost)
• Module - Seat Memory
• Alternator • Motor - Air Suspension Compressor • Instrument Cluster • Monitor - Video/DVD • Transceiver - Passive Anti-Theft (PATS)
• Sensor - Brake Fluid Level • Motor - Engine Cooling Fan • Radio - Amplifier 295 3U2Z-14S411-KAA 8
• Sensor - Throttle Position • Relay - Air Suspension Compressor 210 3U2Z-14S411-BRA 16
• Solenoid - Brake Shift Park Interlock 257 3U2Z-14S411-AKA 29 • Lamp - Courtesy - Reading (Rear)
119 1U2Z-14S411-UA 16 • Trailer Tow - Vehicle Side • Lamp - Dome
• Connector - Inline
• Alternator 172 1U2Z-14S411-AHA 29 212 3U2Z-14S411-BZA 9 • Motor - Rear Window Wiper 296 3U2Z-14S411-KFA 35
• Sensor - Coolant Level • Fuel Pump/Sending Unit • Lamp - Courtesy - Door
259 3U2Z-14S411-ANA 25 • CD Changer
122 1U2Z-14S411-YA 9 • Motor - Windshield Wiper 214 3U2Z-14S411-CLA 16 • Lamp - PRNDL Indicator
• Relay - Daytime Running Lamp (DRL) • Switch - Fog Lamp
• Lamp - Fog/Driving • Lamp - Storage Compartment - Cargo • Radio
173 1U2Z-14S411-AJA 9 • Sensor - Sunload 260 3U2Z-14S411-BJA 9 • Radio - Amplifier
123 1U2Z-14S411-ZA 20 • Radio - Rear Audio Controls
• A/C Compressor Clutch • Fuel Injector
• Sensor - Air Suspension - LH - Rear 215 3U2Z-14S411-CPA 29 • Horn • Speaker - Subwoofer
• Sensor - Air Suspension - RH - Rear • Radio • Radio - Amplifier • Motor - Intercooler Pump • Switch - Seat (driver)
• Sensor - Catalyst Monitor 176 1U2Z-14S411-AMA 35 • Switch - Brake Pressure
• Sensor - O2 (HEGO/ EGO) 216 3U2Z-14S411-CUA 9 297 3U2Z-14S411-KGA 25
• Control Head - Electronic Automatic • Sensor - Brake Fluid Level • Switch - Idle Position
Temperature (EATC) • Switch - Power Steering Pressure • Module - Ignition
146 1U2Z-14S411-BAA 9 • Sensor - Brake Pressure • Motor - Windshield Wiper
• Actuator - Electronic Variable Orifice • Module - Air Suspension • Switch - Speed Control Deactivation
• Module - Lighting Control 218 3U2Z-14S411-CYA 29 • Valve - Vapor Management • Valve - Fuel Tank Selector
• Actuator - Power Steering Pump
• Sensor - Intake Manifold Runner Control • Module - Remote Keyless Entry • Switch - Fog Lamp 298 3U2Z-14S411-BBA 29
• Processor - Radio Audio Signal Control 264 3U2Z-14S411-FYA 29
• Solenoid - Super Charger Bypass • Switch - Heated Seat • Module - Daytime Running Lamp (DRL)
Unit • Switch - Reverse Park Aid • Switch - 4x4 Control
• Switch - Deck Lid / Lift Gate Ajar • Switch - Reverse Park Aid • Sensor - Transmission Range
• Switch - Door Ajar / Interior Lamp 178 1U2Z-14S411-APA 33 220 3U2Z-14S411-DMA 29 299 3U2Z-14S411-BCA 29
• Switch - Lift Gate Glass Ajar • Switch - Multifunction 265 3U2Z-14S411-GCA 8
• Switch - Traction Control • Connector - Inline
• Valve - Thermactor Air Diverter (TAD) • Lamp - Dome
179 1U2Z-14S411-ARA 28 224 3U2Z-14S411-AA 16 • Mirror - Sideview
148 1U2Z-14S411-BCA 9 • Switch - Dimmer 270 3U2Z-14S411-GSA 29 • Solenoid - Brake Shift Park Interlock
• Switch - Moon Roof/Sun Roof • Switch - Headlamp
• Lamp - Fog/Driving • Switch - Multifunction • Switch - Heated Seat
• Lamp - Headlamp - High Beam 225 3U2Z-14S411-APA 20 • Switch - Reverse Park Aid • Switch - Power Window - Quarter Glass
• Lamp - Headlamp - High/Low Beam 180 1U2Z-14S411-ASA 38 • Sensor - Knock • Switch - Sliding Door Contact
• Switch - Fog Lamp • Junction Box - Relay 271 3U2Z-14S411-GTA 25
• Sensor - Mass Air Flow 300 3U2Z-14S411-BDA 24
• Sensor - O2 (HEGO/ EGO) • Actuator - Speed Control
151 1U2Z-14S411-BFA 16 181 1U2Z-14S411-ATA 28 • Module - Auto Lamps
• Lamp - Park/Turn/Stop • Switch - Adjustable Pedal 226 3U2Z-14S411-AYA 9 272 3U2Z-14S411-GUA 9 • Module - Transfer Case Shift Control
• Switch - Moon Roof/Sun Roof • Lamp - CHMSL (Center High Mount • Lamp - Glove Box
• Mirror - Vanity 301 3U2Z-14S411-BHA 16
• Switch - Reverse Park Aid Stop Lamp)
• Switch - Seat Lumbar • Lamp - Headlamp - High/Low Beam
• Mirror - Vanity 273 3U2Z-14S411-GVA 9 • Relay - Flasher
182 1U2Z-14S411-AUA 20 • Switch - Overdrive Cancel • Sensor - Ambient Temp
• Switch - A/C Pressure Cut Off 227 3U2Z-14S411-BPA 29 • Sensor - Heated Thermostat
• Switch - Horn
• Switch - Speed Control
41 WPT Number/Service Number Index 41
WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page
302 3U2Z-14S411-BTA 35 346 3U2Z-14S411-DDA 24 374 3U2Z-14S411-DHA 9 410 3U2Z-14S411-BA 9 464 3U2Z-14S411-PMA 29
• Junction Plate • Switch - Door Lock (LH) • Module - Lighting Control • Sensor - Knock • Switch - Traction Control
• Switch - Door Lock (LH) • Switch - Door Lock (RH) • Module - Seat Memory
• Switch - Power Window • Switch - Power Window - Driver • Motor - Seat Lumbar 413 3U2Z-14S411-CXA 8 470 3U2Z-14S411-MSA 10
• Switch - Power Window - • Solenoid - EGR Vacuum Regulator • Switch - Oil Sending Unit • Sensor - Ambient Temp
303 3U2Z-14S411-BVA 20 Passenger (Front) • Sensor - Fuel Rail Temperature
• Switch - A/C Compressor Clutch Cycling 375 3U2Z-14S411-EAA 25 414 3U2Z-14S411-FHA 16 • Sensor - Fuel Tank Temperature
• Switch - A/C Pressure Cut Off 347 3U2Z-14S411-FMA 20 • Actuator - Speed Control • Switch - Inertia
• Sensor - Intake Manifold Runner Control • Module - Driver Door 471 3U2Z-14S411-MXA 10
304 3U2Z-14S411-CDA 9 415 3U2Z-14S411-GAA 24 • Lamp - License
• Module - Power Moonroof • Switch - Stop Lamp
• Motor - Idle Air Control 348 3U2Z-14S411-GGA 16 • Motor - Moon Roof/Sun Roof • Lamp - Side Marker
• Lamp - Ash Tray • Motor - Seat Track Adjuster 417 3U2Z-14S411-HXA 20 • Switch - Courtesy Lamp
305 3U2Z-14S411-CJA 8 • Lamp - Dome
• Switch - Deck Lid / Lift Gate Ajar • Radio - Amplifier • Sensor - Steering Wheel Position 473 3U2Z-14S411-NEA 10
• Mirror - Sideview • Speaker - Subwoofer
• Radio - Amplifier 419 3U2Z-14S411-JSA 16 • Motor - Convertible Top
307 3U2Z-14S411-DAA 20 • Switch - Overdrive Cancel • Motor - Power Window - LH - Front
• Element - Heated Seat 349 3U2Z-14S411-KDA 9 • Switch - Power Window • Mirror - Rearview
• Mirror - Sideview • Motor - Power Window - LH - Rear
• Lamp - PRNDL Indicator • Actuator - Intake Manifold Valve 376 3U2Z-14S411-EDA 20 • Motor - Power Window - RH - Front
• Switch - Overdrive Cancel • Control - Engine Air Shutoff 420 3U2Z-14S411-JUA 9 • Motor - Power Window - RH - Rear
• Module - Seat Memory
308 3U2Z-14S411-DNA 35 • Switch - Courtesy Lamp • Radio - Amplifier • Sensor - Air Charge Temperature • Switch - Seat Lumbar
• Control Head - Electronic Automatic 350 3U2Z-14S411-KEA 16 • Sensor - Seat Height (Rear) • Sensor - Brake Pressure 474 3U2Z-14S411-NFA 16
Temperature (EATC) • Switch - Low Vacuum Warning • Speaker - Subwoofer 421 3U2Z-14S411-KCA 28 • Lamp - CHMSL (Center High Mount
• Module - Lighting Control 378 3U2Z-14S411-FJA 8 • Trailer Tow - Vehicle Side Stop Lamp)
• Solenoid - Electronic Automatic Tempera- 352 3U2Z-14S411-HNA 8 • Lamp - License
ture Control (EATC) • Capacitor - Ignition/Radio • Horn 424 3U2Z-14S411-LGA 32
• Lamp - Storage Compartment - Cargo • Lamp - PRNDL Indicator
313 3U2Z-14S411-EFA 29 355 3U2Z-14S411-FBA 9 • Motor - Power Slider • Lamp - Running Board
• Relay - Starter Motor
• Switch - Power Window - LH - Rear • Switch - Multifunction (Wiper) • Lamp - Running Board 1027 9U2Z-14S411-ANA 12
• Switch - Power Window - Passenger • Sensor - Knock • Switch - Backup Lamp • Fuel Pump/Sending Unit
• Switch - Seat (3rd Row) • Mirror - Rearview
(Front) • Switch - Third Row Power Folding Seat • Sensor - Mass Air Flow • Switch - Reverse Park Aid
• Sensor - O2 (HEGO/ EGO) • Mirror - Sideview
984 3U2Z-14S411-BXAB 12 • Switch - Traction Control • Switch - Hood Ajar 1028 9U2Z-14S411-APA 26 • Module - Daytime Running Lamp (DRL)
• A/C Compressor Clutch 996 3U2Z-14S411-CEAB 34 • Switch - Power Window - LH - Rear • Pump - Fuel (External)
• EGR Cooler Outlet • Sensor - Transmission Range 1010 3U2Z-14S411-UVB 12 • Switch - Power Window - Passenger • Relay - Daytime Running Lamp (DRL)
• Electronic Locking Differential • Element - Heated Seat (Front)
• Horn 997 3U2Z-14S411-DHAB 36 • Lamp - CHMSL (Center High Mount Stop • Switch - Power Window - RH - Rear 1046 1W3Z-14S411-AC 30
• Lamp - CHMSL (Center High Mount Stop • Mirror - Rearview Lamp) • Clock
Lamp) • Mirror - Sideview • Switch - Heated Seat - RH - Rear 1029 9U2Z-14S411-ASA 26 • Motor - Heater/AC Blend Door
• Lamp - Rear Park • Sensor - Yaw • Switch - Message Center
• Lamp - Reverse 998 3U2Z-14S411-DLB 30 1011 5U2Z-14S411-AAB 12
• Radio • Switch - Hood Ajar 1030 1U2Z-14S411-BNB 24 1047 9U2Z-14S411-ZA 34
• Lamp - Side Marker • Motor - Windshield Wiper • Switch - Moon Roof/Sun Roof
• Motor - Adjustable Pedal • Radio - Amplifier
• Switch - Fuel Filler Door 1012 9U2Z-14S411-PA 21 • Switch - Multifunction
• Sensor - Adjustable Pedal • Motor - Windshield Wiper 1031 3U2Z-14S411-PPB 30 • Switch - Sunshade
• Sensor - Brake Fluid Level • Switch - Message Center • Switch - Adjustable Pedal
• Switch - Power Mirror • Radio - Amplifier
• Sensor - Cam Shaft Position • Switch - Convertable Top 1048 9U2Z-14S411-SA 36
• Sensor - Cylinder Head Temperature • Switch - Power Window - Driver 1013 9U2Z-14S411-TA 21 • Switch - Door Lock (Cargo) • Clockspring
• Sensor - Exhaust Gas Temperature • Switch - Seat Lumbar • Module - Auto Lamps • Switch - Door Lock (LH)
• Sensor - Liftgate Obstacle • Switch - Steering Column Tilt/Telescope • Sensor - Sunload • Switch - Door Lock (RH) 1049 9U2Z-14S411-UA 26
• Sensor - Oil Level • Switch - Upfitter • Switch - Moon Roof/Sun Roof • Actuator - Door Lock - RH - Front
• Sensor - Output Shaft Speed 1014 1U2Z-14S411-BB 21 • Switch - Power Window - Driver • Motor - Heater A/C Mode Door
999 3U2Z-14S411-ERB 12
• Sensor - Speed • Module - Driver Door • Switch - Power Window - LH - Rear • Motor - Heater/AC Blend Door
• Lamp - Ash Tray • Switch - Heater / A/C Blower (Front) • Motor - Heater/AC Inlet Door
• Solenoid - Engine Variable Timing • Lamp - Courtesy - Door • Switch - Power Window - Passenger
• Speaker - Door • Switch - Heater A/C Blower (Rear) (Front) • Switch - Heated Back Light (Rear Defrost)
• Lamp - Courtesy - Footwell • Switch - Heated Seat - LH - Rear
• Speaker - Front • Lamp - Map 1015 3U2Z-14S411-BCAB 21 • Switch - Power Window - RH - Rear
• Speaker - Rear • Switch - Seat Lumbar • Switch - Heated Seat - RH - Front
• Lamp - Storage Compartment - Trunk • Sensor - O2 (HEGO/ EGO) • Switch - Heated Seat - RH - Rear
• Speaker - Subwoofer • Lamp - Under Hood • Switch - Third Row Power Folding Seat
• Speaker - Tweeter - LH - Front • Motor - Adjustable Pedal 1016 3U2Z-14S411-FFB 21 1050 AU2Z-14S411-FA 30
• Switch - A/C Compressor Clutch Cycling • Motor - Fuel Filler Door 1032 9U2Z-14S411-XA 26
• Motor - Steering Column Adjust • Switch - Seat (passenger)
• Switch - Backup Lamp • Speaker - Subwoofer • Module - Climate Control Seat
• Motor - Moon Roof/Sun Roof • Module - Heated Seat
• Switch - Deck Lid / Hatch Release • Motor - Power Seat Track • Transceiver - Passive Anti-Theft (PATS) 1051 5U2Z-14S411-ZB 12
• Switch - Deck Lid / Lift Gate Ajar • Fuel Injector
• Switch - Hood Ajar
• Motor - Seat Height (Front) 1017 3U2Z-14S411-NYB 8 1033 9U2Z-14S411-YA 38
• Horn
• Motor - Seat Height (Rear) • Horn • Module - Driver Door
• Switch - Lift Gate Glass Ajar • Motor - Seat Recline • Module - Seat Memory • Switch - Backup Lamp
• Switch - Power Liftgate • Lamp - Courtesy - Reading (Rear) • Switch - Hood Ajar
• Speaker - Subwoofer • Lamp - Dome • Radio
• Switch - Reverse Park Aid • Switch - Clutch Pedal Position • Radio - Amplifier
• Lamp - Storage Compartment - Cargo 1052 3U2Z-14S411-JLB 12
985 3U2Z-14S411-MDB 12 • Switch - Deck Lid / Lift Gate Ajar • Terminal - Rear Window Defroster Grid 1034 3U2Z-14S411-ZTB 30 • A/C Compressor Clutch
• Lamp - Running Board • Switch - Fuel Filler Door • Actuator - Door Lock
• Lamp - Side Marker • Switch - Traction Control 1018 3U2Z-14S411-PBB 12 • Lamp - Park/Turn/Stop • Actuator - Door Lock - LH - Front
• Capacitor - Ignition/Radio • Lamp - Park/Turn/Stop/Reverse - Inline
• Sensor - Cylinder Head Temperature 1001 3U2Z-14S411-NUB 17 (Male) • Actuator - Door Lock - LH - Rear
• Motor - Seat Lumbar • Actuator - Door Lock - LH - Sliding Door
986 3U2Z-14S411-SLB 12 • Actuator - Door Lock - Decklid/Liftgate • Radio - Amplifier 1035 9U2Z-14S411-AEA 17
• Lamp - CHMSL (Center High Mount Stop • Actuator - Door Lock - RH - Front
• Coil - Ignition • Speaker - Subwoofer • Lamp - CHMSL (Center High Mount Stop • Actuator - Door Lock - RH - Rear
• Lamp - License Lamp) • Switch - Deck Lid / Hatch Release
• Lamp - Courtesy - Reading (Rear) Lamp) • Actuator - Door Lock - RH - Sliding Door
• Sensor - Cam Shaft Position • Switch - Deck Lid / Lift Gate Ajar • Actuator - Liftgate Glass
• Sensor - Crank Shaft Position • Lamp - Dome 1036 9U2Z-14S411-ARA 8
• Lamp - Dome/Map 1019 3U2Z-14S411-XVB 25 • Switch - Park Brake • Lamp - Headlamp - Low Beam
987 3U2Z-14S411-CZAB 12 • Lamp - Side Rail • Junction Box - Relay • Lamp - License
• Switch - Power Steering Pressure • Lamp - Side Marker
• Sensor - Cylinder Head Temperature • Lamp - Storage Compartment - Cargo • Switch - Adjustable Pedal
• Sensor - Knock • Motor - Rear Window Wiper • Switch - Moon Roof/Sun Roof 1037 1U2Z-14S411-BLB 33 • Motor - Power Window - LH - Rear
• Radio - Amplifier • Switch - Power Window - Driver • Inverter - DC to AC • Pump - Fuel (External)
988 3U2Z-14S411-EUB 12 • Sensor - Brake Fluid Level • Sensor - Side Impact
• Switch - Power Window - LH - Rear • Module - Anti-theft
• Lamp - Fog/Driving • Sensor - EATC In Car Temperature • Switch - Power Window - Passenger • Module - Heated Seat • Solenoid - Brake Shift Park Interlock
• Lamp - Headlamp - Low Beam • Switch - Courtesy Lamp (Front) • Module - Power Moonroof • Speaker - Door (front)
989 3U2Z-14S411-HYB 12 • Switch - Deck Lid / Hatch Release • Switch - Power Window - Quarter Glass • Radio - Amplifier • Speaker - Door (rear)
• Switch - Deck Lid / Lift Gate Ajar • Switch - Power Window - RH - Rear • Solenoid - Brake Shift Park Interlock • Speaker - Front
• Sensor - Coolant Temperature • Speaker - Rear
• Sensor - Cylinder Head Temperature • Switch - Door Ajar / Interior Lamp • Switch - Seat Passenger Side (2nd Row) • Switch - Gear Shift Select/Neutral Safety
• Switch - Heated Back Light (Rear Defrost) • Switch - Third Row Power Folding Seat • Switch - Headlamp • Speaker - Tweeter - LH - Front
• Sensor - Transmission Oil Temperature • Speaker - Tweeter - LH - Rear
• Switch - Heater/AC Selector • Switch - Heated Seat
990 8U2Z-14S411-ZB 17 • Switch - Inertia 1020 6U2Z-14S411-RC 35 • Switch - Moon Roof/Sun Roof • Speaker - Tweeter - RH - Front
• Sensor - Cam Shaft Position • Switch - Ignition • Switch - Multifunction • Speaker - Tweeter - RH - Rear
1002 3U2Z-14S411-PXB 17
• Sensor - Crank Shaft Position 1021 3U2Z-14S411-DLAB 12 • Switch - Overdrive Cancel 1054 3U2Z-14S411-GLB 12
• Sensor - Fuel Tank Pressure Transducer • Actuator - Intake Manifold Valve • A/C Compressor Clutch • Switch - Turn Signal • Actuator - Turbocharger Waste Gate
• Sensor - Turbine Shaft Speed • Coil - Ignition • Switch - Windshield Wiper / Washer
• Sensor - Air Suspension • Motor - Power Window - LH - Front • Fuel Injector
• Switch - Fuel Delivery Pressure • Motor - Power Window - LH - Rear • Sensor - Cam Shaft Position
• Sensor - Intake Manifold Runner Control 1039 9U2Z-14S411-AGA 17
• Sensor - Seat Height (Rear) • Motor - Power Window - RH - Front • Sensor - Adjustable Pedal • Sensor - Crank Shaft Position
• Motor - Power Window - RH - Rear • Sensor - Cam Shaft Position • Valve - Cold Start
• Sensor - Brake Fluid Level • Sensor - Crank Shaft Position
• Sensor - Output Shaft Speed
45 WPT Number/Service Number Index 45
WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page
1055 3U2Z-14S411-KYB 21 1078 3U2Z-14S411-LAB 12 1108 1U2Z-14S411-AXB 38 1129 5U2Z-14S411-SB 8 1150 AU2Z-14S411-AYA 13
• Actuator - Door Lock - Decklid/Liftgate • Connector - Inline • Radio • Alternator • Lamp - Reverse
• Actuator - Liftgate Glass • Element - Heated Seat • Lamp - Glove Box
• Switch - Deck Lid/Lift Gate Ajar • Lamp - PRNDL Indicator 1109 3U2Z-14S411-CEB 17 • Switch - Door Ajar / Interior Lamp 1151 BU2Z-14S411-MA 26
• Switch - Steering Column Tilt/Telescope • Speaker - Front • Switch - Courtesy Lamp • Motor - Heater A/C Mode Door
• Switch - Seat Lumbar • Switch - Deck Lid/Lift Gate Ajar 1130 AU2Z-14S411-BNA 30 • Motor - Heater/AC Blend Door
1056 3U2Z-14S411-SKB 26 • Switch - Door Ajar/Interior Lamp • Camera - Reverse Park Aid • Motor - Heater/AC Blower (Auxiliary)
• Switch - Clutch Pedal Position 1080 1U2Z-14S411-FC 12 • Motor - Heater/AC Inlet Door
• Lamp - Fog/Driving 1110 5U2Z-14S411-DB 12 1131 BU2Z-14S411-BA 13
1057 3U2Z-14S411-TLB 12 • Lamp - Headlamp - High Beam • A/C Compressor Clutch • Lamp - CHMSL (Center High Mount Stop 1152 3U2Z-14S411-AJD 36
• Motor - Idle Air Control • Motor - Radio Power Antenna Lamp) • Mirror - Sideview
• Sensor - Brake Fluid Level 1081 3U2Z-14S411-BNB 12 • Speaker - Door (front) • Mirror - Vanity
• Sensor - Coolant Level • Switch - 4x4 Control • Speaker - Door (rear) 1132 BU2Z-14S411-CA 13 • Overhead Console -Inline (Female)
• Sensor - Low Coolant • Speaker - Front • Lamp - Rear Turn • Switch - Multifunction
• Sensor - Washer Fluid level 1082 AU2Z-14S411-EA 12 • Speaker - Rear
• Valve - Heated PCV 1133 BU2Z-14S411-FA 13 1153 3U2Z-14S411-XYB 13
• Speaker - Subwoofer • Coil - Ignition
1058 AU2Z-14S411-LA 17 • Speaker - Tweeter - LH - Front • Lamp - Running Board
• Sensor - Exhaust Gas Pressure 1083 AU2Z-14S411-AHA 33
• Module - Front Interface • Speaker - Tweeter - RH - Front 1134 BU2Z-14S411-HA 13 • Switch - Seatbelt
• Switch - A/C Compressor Clutch Cycling • Motor - Heater/AC Blower (Auxiliary)
• Switch - Heater A/C Blower (Rear) 1111 AU2Z-14S411-BDA 36 1154 9U2Z-14S411-ACA 22
1059 AU2Z-14S411-XA 8 • Module - Air Suspension 1135 BU2Z-14S411-JA 22 • Sensor - Power Steering Pressure
• Glow Plug 1084 AU2Z-14S411-AEA 30 • Sensor - Steering Wheel Position
• Connector - Inline 1113 1U2Z-14S411-AZC 36 • Motor - Windshield Wiper
1060 3U2Z-14S411-HDB 26 1136 1U2Z-14S411-AKB 30 1155 AU2Z-14S411-BRA 22
• Clock 1085 1U2Z-14S411-ACB 30 • Radio • Sensor - Rain
• Switch - Heated Back Light (Rear Defrost) 1114 AU2Z-14S411-BKA 26 • Lamp - Headlamp - High/Low Beam
• Switch - Deck Lid/Hatch Release • Motor - Transfer Case Electronic Shift
• Switch - Message Center • Switch - Heated Seat - LH - Front • Trailer Tow - Vehicle Side 1156 BU2Z-14S411-KA 13
• Switch - Heated Seat - RH - Front • Motor - Windshield Wiper • Motor - Windshield Washer Fluid Pump
• Switch - Moon Roof/Sun Roof
• Lamp - Front Turn • Switch - Windshield Wiper / Washer • Actuator - Door Lock - RH - Rear 1261 CU2Z-14S411-MA 18
• Speaker - Tweeter - RH - Rear • Lamp - Side Marker
1218 3U2Z-14S411-EXB 18 • Handle - Decklid • Coil - Ignition
1181 BU2Z-14S411-ABA 13 • Lamp - Side Marker (Rear Fender) • Lamp - Headlamp - High/Low Beam
• Motor - Rear Window Wiper 1262 1U2Z-14S411-AGB 22
• Indicator - Passenger Airbag Deactivation 1202 BU2Z-14S411-ARA 18 • Pretensioner - Seat Belt (Passenger) • Lamp - Headlamp - Low Beam
(PADI) • Lamp - License • Motor - Air Suspension Compressor
• Actuator - Turbocharger Waste Gate • Sensor - Brake Fluid Level • Trailer Tow - Vehicle Side
• Lamp - CHMSL (Center High Mount Stop • Coil - Ignition • Sensor - Manifold Absolute Pressure • Lamp - Rear Turn
Lamp) • Sensor - Cam Shaft Position (MAP) • Lamp - Side Marker 1264 CU2Z-14S411-KA 18
• Switch - Visor • Sensor - Crank Shaft Position • Sensor - Yaw • Sensor - Knock • Sensor - Occupant Classification
• Sensor - Seat Track Position
1182 BU2Z-14S411-AFA 18 1203 8U2Z-14S411-ACB 38 1219 3U2Z-14S411-DAAC 30 • Sensor - Throttle Position 1265 CU2Z-14S411-NA 34
• Microphone • Sensor - Transmission Range • Switch - Ambient Lighting Dimmer • Sensor - Turbine Shaft Speed • Radio
1183 BU2Z-14S411-AGA 30 • Transmission - Bulkhead • Switch - Door Lock (LH) • Sensor - Water in Fuel
• Switch - Message Center • Switch - Deck Lid / Lift Gate Ajar 1266 CU2Z-14S411-TA 26
• Module - Tire Pressure 1204 1U2Z-14S411-BEB 13 • Module - Fuel Pump Driver
• Radio - Amplifier • Switch - Moon Roof/Sun Roof • Switch - Door Ajar / Interior Lamp
• Lamp - Fog/Driving • Switch - Seat Memory • Switch - Hood Ajar
• Lamp - Front Park 1267 3U2Z-14S411-PKB 28
1184 BU2Z-14S411-AHA 30 • Switch - Lift Gate Glass Ajar • Switch - Adjustable Pedal
• Lamp - Front Turn 1220 BU2Z-14S411-AXA 22 • Switch - Stop Lamp
• Lamp - Overhead Console • Switch - Door Lock (LH)
• Lamp - Front Turn/ Marker • Sensor - Knock • Valve - Vapor Management
1185 BU2Z-14S411-AJA 34 • Lamp - License • Switch - Door Lock (RH)
• Lamp - Reverse 1221 BU2Z-14S411-BDA 13 1244 AU2Z-14S411-BMA 14 • Switch - Heated Back Light (Rear Defrost)
• Camera - Reverse Park Aid
• Switch - Gear Shift Select/Neutral Safety • Lamp - Running Board • Squib - Airbag (Passenger) • Pretensioner - Seat Belt (Passenger) • Switch - Power Sliding Rear Window
• Lamp - Side Marker 1222 BU2Z-14S411-BEA 13 • Switch - Power Window - Driver
1186 BU2Z-14S411-AKA 13 • Lamp - Stop/Park 1245 BU2Z-14S411-BLA 14 • Switch - Power Window - LH - Rear
• Speaker - Tweeter - LH - Front • Pretensioner - Seat Belt (Driver) • Motor - Power Window - LH - Front • Switch - Power Window - Passenger
• Lamp - Under Hood • Squib - Airbag (Passenger)
• Speaker - Tweeter - LH - Rear • Motor - Power Window - RH - Front (Front)
• Speaker - Tweeter - RH - Front 1205 3U2Z-14S411-KMB 18 1223 BU2Z-14S411-BFA 13 • Switch - Power Window - RH - Rear
• Sensor - Cam Shaft Position 1246 BU2Z-14S411-RA 14
• Speaker - Tweeter - RH - Rear • Squib - Airbag (Passenger) • Switch - Seat (driver)
• Switch - Seatbelt • Sensor - Delta Pressure Feedback EGR • Sensor - Speed • Switch - Traction Control
• Sensor - Fuel Tank Pressure Transducer 1224 BU2Z-14S411-BGA 13 1247 1U2Z-14S411-JB 18
1187 BU2Z-14S411-ALA 30 • Squib - Airbag (Passenger) 1268 CU2Z-14S411-RA 14
• Module - Air Suspension 1206 3U2Z-14S411-ZBB 30 • Lamp - Headlamp - High/Low Beam • Sensor - A/C Evaporator Temperature
• Motor - Power Seat Track 1225 BU2Z-14S411-BHA 13 1248 3U2Z-14S411-BXB 33
1188 BU2Z-14S411-AMA 13 • Sensor - Rain • Airbag - Side Curtain 1269 CU2Z-14S411-SA 14
• Motor - Heater/AC Blower (Front) • Switch - Ignition • Solenoid - Engine Variable Timing
1207 5U2Z-14S411-ABC 26 • Pretensioner - Seat Belt (Driver)
1189 BU2Z-14S411-ZA 36 • Pretensioner - Seat Belt (Passenger) 1249 3U2Z-14S411-BYAC 26 1270 CU2Z-14S411-VA 30
• Switch - Courtesy Lamp - Liftgate • Sensor - Side Impact • Lamp - Dome
• Module - Reverse Park Aid (RPA) • Switch - Deck Lid/Hatch Release • Switch - Center Stack (Multipurpose)
• Squib - Airbag (Driver) • Lamp - Storage Compartment - Cargo • Switch - Hazard Warning
1190 3U2Z-14S411-EFAB 13 • Switch - Deck Lid/Lift Gate Ajar • Squib - Airbag (Passenger) • Motor - Heater A/C Mode Door
• Switch - Heater A/C Temp Control • Switch - Traction Control
• Terminal - Rear Window Defroster Grid • Motor - Heater/AC Blend Door
• Switch - Message Center 1226 BU2Z-14S411-BJA 13 • Motor - Heater/AC Inlet Door 1271 3U2Z-14S411-CGC 14
1191 BU2Z-14S411-AEA 22 • Switch - Power Liftgate • Squib - Airbag (Passenger) • Switch - Hazard Warning • Sensor - Cam Shaft Position
• Motor - Seat Recline 1208 8U2Z-14S411-CB 34 1227 BU2Z-14S411-BKA 13 • Switch - Heated Seat • Sensor - Crank Shaft Position
• Motor - Steering Column Adjust • Connector - Inline • Switch - Heater A/C Blower (Rear)
• Sensor - Side Impact 1272 3U2Z-14S411-RGB 30
1192 BU2Z-14S411-ACA 18 • Squib - Airbag (Driver) • Switch - Speed Control
1209 BU2Z-14S411-ASA 28 • Switch - Power Mirror
• Lamp - Courtesy - Door • Squib - Airbag (Passenger) 1250 CU2Z-14S411-CA 14
• Motor - Power Window - LH - Front 1273 9U2Z-14S411-ADB 22
• Lamp - Map • Motor - Power Window - LH - Rear 1228 BU2Z-14S411-BMA 13 • Solenoid - Engine Variable Timing
• Sensor - O2 (HEGO/ EGO)
1193 3U2Z-14S411-DCAB 13 • Motor - Power Window - RH - Front • Airbag - Side Curtain 1251 CU2Z-14S411-DA 14
• Element - Heated Seat • Motor - Power Window - RH - Rear • Solenoid - Engine Variable Timing 1274 BU2Z-14S411-BCA 14
1229 BU2Z-14S411-BNA 14
• Lamp - CHMSL (Center High Mount 1210 3U2Z-14S411-ZUB 13 • Valve - Vapor Management
Stop Lamp) • Deployable Steering Column 1252 CU2Z-14S411-FA 22
• Motor - Power Window - LH - Rear • Module - Variable Speed Blower Control- 1275 CU2Z-14S411-AKA 14
• Lamp - Fog/Driving • Motor - Power Window - RH - Rear 1230 BU2Z-14S411-BPA 14
• Lamp - Side Marker (Rear Fender) ler • Actuator - Turbocharger Waste Gate
• Sensor - Output Shaft Speed • Airbag - Side Curtain
• Mirror - Sideview • Squib - Airbag (Passenger) • Resistor - Blower Motor (Front) 1276 CU2Z-14S411-ALA 30
• Sensor - Turbine Shaft Speed • Switch - Heater / A/C Blower (Front)
• Sensor - Crash (Engine Compartment) • Connector - Inline
• Speaker - Tweeter - LH - Front 1211 1U2Z-14S411-GB 18 1231 3U2Z-14S411-DVAB 14
1253 6U2Z-14S411-KB 8 1277 CU2Z-14S411-UA 14
• Speaker - Tweeter - RH - Front • Lamp - CHMSL (Center High Mount Stop • Heater - Fuel
• Sensor - Oil Temperature • Capacitor - Ignition/Radio • Solenoid - Fuel Volume Regulator
1194 9U2Z-14S411-AKB 22 Lamp)
• Lamp - Front Cornering/Turn 1232 BU2Z-14S411-ATA 22 1254 1U2Z-14S411-BSB 14 Control
• Sensor - Catalyst Monitor • Lamp - Front Turn
• Sensor - O2 (HEGO/ EGO) • Sensor - Manifold Pressure/Intake • A/C Compressor Clutch 1278 CU2Z-14S411-ABA 34
• Lamp - Front Turn/ Marker Temperature • Capacitor - Ignition/Radio
• Lamp - Park/Turn/Stop • Message Center
1195 BU2Z-14S411-ADA 13 • Connector - Inline • Module - Driver Information
• Lamp - Storage Compartment - Trunk • Lamp - Rear Turn 1233 BU2Z-14S411-AZA 30 • Lamp - Fog/Driving
• Lamp - Reverse • Module - Front Interface
• Module - Air Suspension • Motor - Trunk Striker
1196 BU2Z-14S411-AVA 33 • Lamp - Stop • Sensor - Knock
• Lamp - Overhead Console • Lamp - Stop/Park 1234 BU2Z-14S411-BAA 39 • Sensor - Speed
• Relay - Park Lamp • Module - Anti-Lock Brake System • Solenoid - Canister Vent
1236 3U2Z-14S411-FKAE 18 • Solenoid - Torque Control Coupling
• Lamp - Headlamp - High/Low Beam
47 WPT Number/Service Number Index 47
WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page WPT# Service # Page
• Lamp - Park/Turn
1279 CU2Z-14S411-ADA 36 1299 3U2Z-14S411-NBB 26 1317 CU2Z-14S411-BCA 18 • Sensor - Intake Manifold Runner Control 1364 DU2Z-14S411-AGA 14
• Lamp - Headlamp - High/Low Beam • Connector - Inline • Actuator - Turbocharger Waste Gate • Sensor - Manifold Absolute Pressure • Sensor - Fuel Filler Door
• Module - Heated Seat (driver) • Element - Heated Seat (MAP) • Switch - Fuel Filler Door
• Module - Transfer Case Shift Control • Inverter - DC to AC 1318 CU2Z-14S411-BDA 34 • Valve - Transmission Fluid Warmer
• Radio • Sensor - Manifold Pressure/Intake
• Lamp - CHMSL (Center High Mount Stop Temperature
1280 CU2Z-14S411-AEA 26 Lamp) 1365 DU2Z-14S411-YA 35
• Camera - Reverse Park Aid 1319 DU2Z-14S411-GA 22 • Sensor - Turbine Shaft Speed • Module - Seat
• Lamp - Courtesy - Footwell • Element - Heated Seat • Sensor - Turbo Intake Pressure/ Tempera-
1281 CU2Z-14S411-PA 18 • Lamp - License ture 1366 3U2Z-14S411-MBB 31
• Sensor - Fuel Rail Pressure • Lamp - Park/Turn/Stop 1320 DU2Z-14S411-RA 36 • Switch - Sliding Door Contact • Actuator - Door Lock - LH - Front
• Lamp - Top Finish Panel • Connector - Inline • Actuator - Door Lock - LH - Rear
1282 CU2Z-14S411-XA 14 • Motor - Adjustable Pedal • Mating Connector WPT-1321 1340 AU2Z-14S411-NB 14
• Actuator - Door Lock - RH - Front
• Fuel Injector • Switch - Gear Shift Select/Neutral Safety • Sensor - Crash (Engine Compartment) • Actuator - Door Lock - RH - Rear
• Switch - Multifunction 1321 DU2Z-14S411-SA 36
1283 CU2Z-14S411-ACA 32 • Connector - Inline 1341 CU2Z-14S411-AXA 18 • Module - Liftgate
• Clockspring 1300 3U2Z-14S411-VBB 14 • Mating Connector WPT-1320 • Sensor - Headlamp Leveling • Switch - Door Ajar/Interior Lamp
• Sensor - Output Shaft Speed • Switch - Door Lock (LH)
1284 CU2Z-14S411-AFA 18 • Sensor - Speed 1322 3U2Z-14S411-CSAB 14 1342 CU2Z-14S411-GA 37 • Switch - Door Lock (RH)
• Coil - Ignition • Sensor - Turbine Shaft Speed • Lamp - Dome • Module - Adaptive Cruise Control • Switch - Sliding Door Contact
• Solenoid - Air Suspension • Lamp - Dome/Map 1343 DU2Z-14S411-ABA 22 1367 3U2Z-14S411-BHB 18
1285 CU2Z-14S411-AMA 24 • Module - Radio Power Antenna
• Module - Variable Speed Blower Control- 1301 CU2Z-14S411-ANA 18 • Module - Warning Chime/ Beltminder • Mating Connector WPT-750 • Lamp - Headlamp - High/Low Beam
ler • Sensor - Front Park Aid (FPA) • Solenoid - Brake Shift Park Interlock • Motor - Engine Cooling Fan • Relay - Flasher
1286 CU2Z-14S411-APA 35 1302 CU2Z-14S411-ARA 14 • Speaker - Reverse Park Aid (RPA) 1344 DU2Z-14S411-AEA 27 1368 DU2Z-14S411-AHA 14
• Connector - Inline • Fuel Injector 1323 3U2Z-14S411-FAB 22 • Motor - Power Window - LH - Front • Switch - Backup Lamp
• Module - Wiper Control • Pump - Fuel Injection • Motor - Heater/AC Blend Door • Motor - Power Window - LH - Rear
• Motor - Power Window - RH - Front 1369 AU2Z-14S411-JB 18
1287 CU2Z-14S411-YA 18 • Solenoid - Fuel Volume Regulator Control • Motor - Heater/AC Inlet Door • Sensor - Cam Shaft Position
• Clockspring
• Module - Power Steering
1398 EU2Z-14S411-CA 37
• Transmission - Bulkhead
1399 EU2Z-14S411-LA 37
• Module - Gear Shift
1400 9U2Z-14S411-CC 19
• Monitor - Crankcase Ventilation
• Sensor - Air Suspension
• Sensor - Front Park Aid (FPA)
• Sensor - Occupant Classification
• Sensor - Reverse Park Aid (RPA)
• Switch - A/C Compressor Clutch Cycling
• Switch - A/C High Pressure
1404 EU2Z-14S411-VA 37
• Mirror - (Mating connector WPT-1279)
1445 FU2Z-14S411-VA 39
• DPS6 Transmission
(12A581 Harness Connection to TCM)
4771 3U2Z- 14S411-NVB 19
• Switch - Gear Shift Select/Neutral Safety
5361 3U2Z-14S411-SVB 15
• Cigar Lighter
• Sensor - Cam Shaft Position
• Speaker - Reverse Park Aid (RPA)
Service Parts Warranty Summary: Parts Sold Over the Counter
Ford and Motorcraft® Parts
IMPORTANT: This is a summary of warranty highlights. For more information, the seller will refer to the
Ford Warranty & Policy Manual. Ford Motor Company offers a limited warranty on new Ford and Motorcraft®
parts sold to U.S. customers through an authorized Ford-Lincoln Dealership or Ford Authorized Distributor.
The authorized seller warrants that any new Ford or Motorcraft® part sold by the authorized seller that is found
to be defective in factory-supplied material or workmanship will be repaired, replaced or exchanged at Ford’s
discretion. Unique warranty coverage may apply. Customer should return part to seller with original dated receipt
for purchase verification.
LABOR REIMBURSEMENT:
• Fleet and Installers are eligible for labor reimbursement limited to $150.
• Fleet & Installer warranty parts and labor reimbursement requests must be supported with documentation:
o Repair order to include Vehicle Identification Number (VIN) & repair date.
o Steps taken to determine cause of warranted concern with diagnostic results.
o Labor amount is calculated using the fleet or installer hourly cost of labor multiplied by the
time required to complete the repair.
o Labor time is to be supported by published time standard.
WARRANTY LIMITATIONS
• This warranty does not cover parts that fail due to abuse, misuse, neglect, alteration, impact, accident, racing or the use
of non-Ford parts, or parts installed in vehicles other than those listed in Ford authorized catalogs, including other Ford
Motor Company brands, or parts that are replaced as a part of normal maintenance.
• To the extent allowed by law: loss of time, inconvenience, loss of use of the vehicle, commercial loss and consequential
damages are not covered.
• There is no other express warranty on Ford Motor Company-supplied replacement parts, except such obligation as Ford may
have assumed in its FCSD Warranty and Policy Manual or other warranty statements issued by the Dealer/Distributor.
• Any implied warranty of merchantability or fitness for a particular purpose is limited to the duration of this warranty.
Some states do not allow the exclusion or limitation of consequential or incidental damages or limitations on how long an
implied warranty lasts; therefore, the limitations and exclusions may not apply to you. This warranty gives you specific legal
rights. You may also have other rights that vary from state to state.
IMPORTANT: This is a summary of the warranty highlights. For more information, the seller will refer to the Ford Warranty & Policy Manual.