Professional Documents
Culture Documents
Analog & Digital Electronics (Analog, Digital, Communication, Microprocessor) 1
Analog & Digital Electronics (Analog, Digital, Communication, Microprocessor) 1
Q. 1
HOME
Consider the op-amp shown in the figure below:
MY TEST
BOOKMARKS
The input bias current for proper operation of the internal differential amplifier stage of op-amp is
MY PROFILE FAQ Have any Doubt ?
REPORTS A 20 μA
BUY PACKAGE
B 25 μA
Correct Option
ASK AN EXPERT
Solution :
(b)
C 30 μA
D 5 μA
QUESTION ANALYTICS
Q. 2
Which of the following are the advantages of an instrumentation amplifier made up of op-amps?
(i) High input impedance
(ii) High CMRR
(iii) Low output offset
(iv) Low output impedance
FAQ Have any Doubt ?
Solution :
(d)
QUESTION ANALYTICS
Q. 3
Solution :
(b)
QUESTION ANALYTICS
Q. 4
A V/Hz
B V-sec
C V/sec
Correct Option
Solution :
(c)
(c)
D Hz
QUESTION ANALYTICS
Q. 5
A certain op-amp has open-loop differential voltage gain of 105 and common-mode gain of “–14 dB”. The CMRR of the op-amp
is
FAQ Have any Doubt ?
A 86 dB
B 96 dB
C 114 dB
Correct Option
Solution :
(c)
D 134 dB
QUESTION ANALYTICS
Q. 6
In the ideal op-amp based circuit shown in the figure below, the value of the current I0 is
A 0A
B 1 mA
C 2 mA
Correct Option
Solution :
(c)
D 4 mA
QUESTION ANALYTICS
Q. 7
An op-amp with a slew rate of 0.314 V/μsec is used to build an amplifier of gain 10. If the input to this amplifier is a sinusoidal
voltage with a peak amplitude of 1 V, then the maximum allowable frequency of the input signal for undistorted output is
FAQ Have any Doubt ?
A 5 kHz
Correct Option
Solution :
(a)
B 50 kHz
C 150 kHz
D 175 kHz
QUESTION ANALYTICS
Q. 8
C
Correct Option
Co ect Opt o
Solution :
(c)
QUESTION ANALYTICS
Q. 9
A 1 and 2 only
B 2 and 3 only
C 1 and 3 only
C 1 and 3 only
D 1, 2 and 3
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 10
The output of a two input logic gate is 0, when all the inputs are logic 1. The gate is either
FAQ Have any Doubt ?
A a NAND or an AND
B a NAND or an X-OR
Correct Option
Solution :
(c)
C a NOR or an X-NOR
D an AND or an X-NOR
QUESTION ANALYTICS
Q. 11
Solution :
(d)
QUESTION ANALYTICS
QUESTION ANALYTICS
Q. 12
A full subtracter
B full adder
Correct Option
Solution :
(b)
C odd parity detector
D comparator
QUESTION ANALYTICS
Q. 13
A 1 and 2 only
B 2 and 3 only
C 1 and 3 only
Correct Option
Solution :
( )
(c)
A combinational circuit does not have any storage elements.
D 1 and 2 only
QUESTION ANALYTICS
Q. 14
The output Qn of a J-K flip-flop is 1. It changes to 0 when a clock pulse is applied. The inputs Jn and Kn, before the application
of clock pulse, are respectively
FAQ Have any Doubt ?
A 0 and x
B 1 and x
C x and 1
Correct Option
Solution :
(c)
D x and 0
QUESTION ANALYTICS
QU S O CS
Q. 15
A 010000.....
B 011011.....
C 010001.....
D 010101.....
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 16
i i i
A increase noise margin
Solution :
(b)
QUESTION ANALYTICS
Q. 17
Which of the following statements are true with respect of a synchronous ripple counter?
1. Higher speed
2. Less severe decoding problem
3. More circuitry
FAQ Have any Doubt ?
A 1 and 2 only
B 2 and 3 only
C 1 and 3 only
D 1, 2 and 3 only
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 18
Match List-I with List-II and select the correct answer using the codes given below the lists:
A a
B b
C c
Correct Option
Solution :
(c)
D d
QUESTION ANALYTICS
Q. 19
B
Correct Option
Solution :
(b)
QUESTION ANALYTICS
Q. 20
A 10 V
B 8V
C 1V
D 4V
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 21
Q
A A1 = – 11, A2 = – 10
B A1 = 11, A2 = – 10
C A1 = 9, A2 = – 10
D A1 = – 9, A2 = – 10
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 22
With reference to the message signal m(t) = 5cos(1000πt), match List-I (Type of modulation) with List-II (Bandwidth of
modulated signal) and select the correct answer using the codes given below the lists:
A a
B b
B
Correct Option
Solution :
(b)
C c
D d
QUESTION ANALYTICS
Q. 23
Select the correct one of the following statements with reference to a message signal m(t) = Amcos(2πfmt).
FAQ Have any Doubt ?
Solution :
(d)
(d)
QUESTION ANALYTICS
Q. 24
A RF amplifier
B Mixer
C IF amplifier
D Amplitude limiter
Correct Option
Solution :
(d)
Amplitude limiters are used in FM receivers but not AM receivers.
QUESTION ANALYTICS
Q. 25
The autocorrelation function of a white noise is a
FAQ Have any Doubt ?
A step function
B delta function
Correct Option
Solution :
(b)
For a White noise,
Power spectral density is constant for all frequencies.
Auto-correlatoin function is a delta function.
C constant
D Gaussion function
QUESTION ANALYTICS
Q. 26
A 2 kHz
B 4 kHz
Correct Option
Solution :
(b)
C 6 kHz
D 8 kHz
QUESTION ANALYTICS
Q. 27
What are the number of machine cycles n, and the types of machine cycles carried out for PUSH B?
FAQ Have any Doubt ?
Solution :
(b)
Machine cycles of PUSH B instruction are shown below:
Op-code fetch → 6 T-states
Memory write → 3 T-states
QUESTION ANALYTICS
Q. 28
In 8085 microprocessor the value of the most significant bit of the result following the execution of any arithmetic or Boolean
instruction is stored in
FAQ Have any Doubt ?
Solution :
(c)
The most significant bit represents the sign of the number. Therefore, it is stored in the sign status flag.
Q. 29
In 8085 microprocessor, after the execution of RST 5 instruction, the program control shifts to
FAQ Have any Doubt ?
A 0030 H
B 0005 H
C 0028 H
Correct Option
Solution :
(c)
D 0024 H
QUESTION ANALYTICS
Q. 30
Consider a memory chip with 1024 bytes storage connected to a 8085 chip address lines (or any microprocessor with 16
address lines) as below. What is the range of memory address?
FAQ Have any Doubt ?
A 0000 H to 03FF H
B 8000 H to 83FF H
Correct Option
Solution :
(b)
C F000 H to F3FF H
D 0000 H to FFFF H
QUESTION ANALYTICS
Q. 31
Solution :
(d)
Program-counter is a 16-bit register used to store the address of next instruction to be fetched by the microprocessor.
QUESTION ANALYTICS
Q. 32
Assertion (A): For an ideal operational amplifier, the common mode gain is infinite.
Reason (R): Ideal operational amplifier has infinite common mode rejection ratio.
FAQ Have any Doubt ?
A a
B b
C c
D d
D d
Correct Option
Solution :
(d)
The common mode gain of an ideal op-amp is zero and CMRR is infinite.
QUESTION ANALYTICS
Q. 33
Assertion (A): When all inputs of NAND gate are shorted to get one input, one output gate, it becomes an inverter.
Reason (R): When all inputs of a NAND gate are at logic ‘0’ level, the output will be at logic-1 level.
FAQ Have any Doubt ?
A a
B b
Correct Option
Solution :
(b)
The reason does not mention the condition of all inputs being ‘1’ and output to be ‘0’.
C c
D d
QUESTION ANALYTICS
Q. 34
A a
B b
C c
D d
Correct Option
Solution :
(d)
A demux can be used as decoder if the input lines treated as enable and the select line as the input.
QUESTION ANALYTICS
Q. 35
A a
Correct Option
Solution :
(a)
Sequential is defined by feedback and synchronous is decided by clock.
B b
C c
D d
QUESTION ANALYTICS
Q. 36
Assertion (A): It is not possible to design a current source using operational amplifier.
Reason (R): Operational amplifier is a voltage-controlled voltage source.
FAQ Have any Doubt ?
A a
B b
C c
D d
Correct Option
Solution :
(d)
QUESTION ANALYTICS
Q. 37
Assertion (A): The DMA technique is more efficient than the Interrupt-driven technique for high volume I/O data transfer.
Reason (R): The DMA technique does not make use of the Interrupt mechanism.
FAQ Have any Doubt ?
A a
Correct Option
Solution :
(a)
The DMA technique does not make use of the interrupt mechanism, that’s why it is more efficient than the interrupt-driven
technique for high volume I/O data transfer.
B b
C c
D d
QUESTION ANALYTICS
Q. 38
Assertion (A) : DPCM system is more preferable when the samples of message signal are highly correlative.
Reason (R) : In a DPCM system, the difference between adjacent samples is quantized rather than individual samples.
FAQ Have any Doubt ?
A a
Correct Option
Solution :
(a)
For highly correlative samples, the difference between the amplitudes of adjacent samples is very small and in DPCM, the
difference between adjacent samples is quantized rather than individual samples. Hence, DPCM is more preferable when
the samples of message signals are highly correlative.
B b
C c
D d
QUESTION ANALYTICS