To install the new version of FANUC Robotics RCS Module V8.20 Rev H, first uninstall the old versions of RCS Module V8.20 and Virtual Robot Controller V8.20 using the Control Panel. Then open the folder containing RCS V8.20 Rev H and run setup.exe to install with default options. Restart the computer after installation and if issues occur, repeat the uninstall and install steps.
To install the new version of FANUC Robotics RCS Module V8.20 Rev H, first uninstall the old versions of RCS Module V8.20 and Virtual Robot Controller V8.20 using the Control Panel. Then open the folder containing RCS V8.20 Rev H and run setup.exe to install with default options. Restart the computer after installation and if issues occur, repeat the uninstall and install steps.
To install the new version of FANUC Robotics RCS Module V8.20 Rev H, first uninstall the old versions of RCS Module V8.20 and Virtual Robot Controller V8.20 using the Control Panel. Then open the folder containing RCS V8.20 Rev H and run setup.exe to install with default options. Restart the computer after installation and if issues occur, repeat the uninstall and install steps.
a. Go to Control Panel b. Select “Programs and Features” or “Add or Remove Programs” c. Locate FANUC Robotics RCS Module V8.20 i. Select “Uninstall” or “Change/Remove” 1. Click Next to uninstall 2. Click Finish d. Locate FANUC Robotics Virtual Robot Controller V8.20 i. Select “Uninstall” or “Change/Remove” 1. Click Next to uninstall 2. Click Finish e. Restart the computer 2. Open folder that contains RCS V8.20 Rev H a. Double Click setup.exe b. Install with options and settings as normal c. When done Restart the computer 3. If any issue occur re-do steps 1 and 2