Professional Documents
Culture Documents
How To Measure Your Cadet at Home
How To Measure Your Cadet at Home
How To Measure Your Cadet at Home
1. Wrap the tape around the widest point of the head, just (Use one of the following methods) Dominant hand (e.g. if right-handed measure the right hand)
above the ears (Figures 1A and 1B). Method 1 (recommended) 1. Starting under the hand (Figure 7A), wrap the tape around
MEASURING INSTRUCTIONS
2. Take the measurement on the forehead, near the temple 1. Take a pair of dress pants that have a waistband and that fit the hand, excluding the thumb and across the top of the
(Figure 1B). well when fastened. Do NOT use low-rise pants. knuckles (Figure 7B).
The comfort and fit of your uniform depend on The measurement is the number that lines up with the edge of 2. Lay the pants flat on a table, with the waistband fully 2. Holding the tape in place, instruct the person to clench his
accurate sizing. the tape (Figure 1C). fastened. or her fist, and allow the tape to adjust itself to fit
3. Measure the distance from one side seam to the other snugly rather than tightly (Figure 7B).
The following instructions are designed to help you 1 2 3 4
5 6 7 8 9 (Figure 4A). The measurement is the number
obtain precise body measurements that will be used 4. Double the number of inches 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
that lines up with the edge 1 2 3 4 5
6 7 8 9
1 2 3 4 5 6 7
1
8 9
by our system to recommend your garment sizes. recorded to obtain the waist of the tape (Figure 7B).
FIGURE 1C measurement. FIGURE 7A FIGURE 7B
BASIC GUIDELINES FIGURE 1A FIGURE 1B
- Have your measurements taken by another person. FIGURE 4A
NECK Method 2 FOOT
It is almost impossible to take accurate measurements (Use one of the following methods) 1. Wrap the tape around the body (NOT over the pants), at
by yourself. Method 1 (recommended)
Method 1 (recommended) waist level (Figures 4B and 4C). The tape must be parallel
- Wear a tight-fitting top and a pair of lightweight pants to the floor and fit snugly rather than tightly against
1. Take a dress shirt (with collar and buttons) that fits you well Use the foot measuring device provided by Logistik; follow
that fit well and have a regular waistband. the body.
the indicated instructions. If the device is not available use
when the top button is fastened. Back Front
You should NOT wear low-rise pants. The measurement is
- Remove your belt and jewellery, including your watch,
2. Unbutton the shirt and place it flat on a table, with the collar method 2.
open (Figure 2A). the number that lines 86
87
88
89
90
94
95
96
97
100
101
FIGURE 6B
102
103
FIGURE 2A
FIGURE 2B
FIGURE 4B FIGURE 4C
pinned or tied back. on paper. Measure the widest
- Remove your shoes and wear socks that you normally HIPS part of the drawing to get the
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
FIGURE 2D
that lines up with
take the larger measurement. the bottom HEIGHT
- Do NOT augment the measurements taken. Logistik's of the edge of the (Use one of the following methods)
sizing system and garment designs already provide ample tape (Figure 2D). Method 1 (recommended)
room for ease of movement. 90°
Standing with back against a wall, heels together
- Measurements for all parts except feet are in inches. CHEST 1. Place a flat, rigid tool (e.g. wooden ruler) on top of
Please do foot measurements in Millimeters. Round up 1. Wrap the tape under the arms, around the widest part of the head to form a 90° angle with the wall.
to the neasrest half inch, and nearest milimetre. the chest, just under the shoulder blades (Figure 3A). The 2. Place the leading edge of the tape at this spot and
tape must be parallel to the floor and snug, though not measure the distance in a straight line to the floor.
NEED HELP? tight. Back Front
Method 2 (approximate to within 1 inch or 2.5 cm of
Contact your corps or squadron
The measurement
accuracy)
is the number that
Arms stretched out sideways at shoulder height
lines up with the
These instructions are also available on our website. 4
1. Place the leading edge of the tape at the tip of the
edge of the tape
middle finger of one hand and measure, in straight
(Figure 3B).
line, the distance across the back to the tip of the other
FIGURE 3A FIGURE 3B
hand's middle finger.
TOUR DE TÊTE TOUR DE TAILLE CIRCONFÉRENCE DE LA MAIN
1. Passez le ruban autour de la tête, à l'endroit le plus fort, (Veuillez utiliser l’une des deux méthodes suivantes) Main dominante (ex. : main droite pour les droitiers)
juste au-dessus des oreilles (Figures 1A et 1B). Méthode 1 (recommandée) 1. Passez le ruban sous la main (Figure 7A), puis revenez sur
INSTRUCTIONS DE MESURE
2. Prenez la mesure sur le front près de la tempe (Figure 1B). 1. Prenez un pantalon habillé, avec une bande de taille, le dessus en excluant le pouce et en passant sur les
La mesure correspond au chiffre aligné avec le début du ruban qui vous va bien lorsqu'il est attaché. jointures (Figure 7B).
Le confort et l’ajustement de votre uniforme sont (Figure 1C). Ne prenez PAS un pantalon à taille basse. 2. Tout en maintenant le ruban bien en place, demandez à la
étroitement liés à l’exactitude des mensurations que 2. Posez le pantalon à plat sur une table, la taille bien personne de fermer la main et laissez le ruban s'ajuster
vous fournissez. 1 2 3 4
5 6 7 8 9 attachée. sans trop serrer ni laisser trop de jeu (Figure 7B).
3. Mesurez la distance d'une couture de côté à l'autre La mesure correspond au chiffre
Les instructions qui suivent vous aideront à obtenir des (Figure 4A). aligné avec le début du ruban 1 2 3 4 5
6 7 8 9
1 2 3 4 5 6 7
1
8 9
mesures précises qui seront utilisées par notre système FIGURE 1C 4. Multipliez par deux cette mesure 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
(Figure 7B).
pour suggérer la taille des vêtements que vous FIGURE 1A FIGURE 1B pour obtenir le tour de taille. FIGURE 7A FIGURE 7B
commandez.
TOUR DE COU PIED
(Veuillez utiliser l’une des deux méthodes suivantes) Méthode 2 FIGURE 4A
INSTRUCTIONS DE BASE 1. Passez le ruban autour du corps (PAS par-dessus le Méthode 1 (recommandée)
Méthode 1 (recommandée)
- Faites prendre vos mesures par une autre personne. 1. Prenez une chemise habillée (avec un col et des boutons) qui pantalon), à la hauteur de la taille (Figures 4B et 4C). Utilisez l'instrument de mesure de pied fourni par Logistik et
Il est pratiquement impossible de prendre correctement vous va bien lorsque le bouton du col est attaché. Le ruban doit être parallèle au sol et bien ajusté sans suivez les instructions qui y sont indiquées.
vos propres mesures. 2. Déboutonnez la chemise et posez-la à plat sur une table, trop serrer le corps. Dos Devant
- Portez un haut assez moulant ainsi qu'un pantalon qui le col bien ouvert (Figure 2A). La mesure correspond Méthode 2
vous va bien, en tissu mince et léger, et à taille régulière. 3. Mesurez la distance entre le centre de la boutonnière et au chiffre aligné avec
Tracez le pied avec une
86
87
88
le début du ruban
90
93
94
95
-
96
Enlevez votre ceinture et vos bijoux tels montre, bagues, (Figure 4C).
97
99
100
FIGURES 2A
101
FIGURE 6B
FIGURE 2B
102
bracelets et colliers.
103
105
FIGURE 4B FIGURE 4C
- Videz vos poches. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18
INSTRUCTIONS POUR LA PRISE DES MESURES Vous devriez pouvoir insérer un doigt dans le « V » ainsi avec le début du
formé, entre le ruban et le cou (Figure 2D). ruban (Figure 5B).
- Ne serrez pas trop le ruban et ne laissez pas trop de jeu. La mesure correspond
- Ne faites PAS d'estimation. Si la lecture donne entre deux au chiffre aligné FIGURE 2C FIGURE 5A FIGURE 5B
avec le bas du
FIGURE 2D
traits sur le ruban, prenez la mesure la plus grande.
- N'augmentez PAS les mesures que vous prenez. début du ruban
Le système de tailles de Logistik et la confection des (Figure 2D). GRANDEUR
vêtements tiennent déjà compte des marges nécessaires à (Veuillez utiliser l’une des deux méthodes suivantes)
l'aisance des mouvements. Méthode 1 (recommandée)
TOUR DE POITRINE
- Les mesures de toutes les pièces sauf les pieds sont en Tête et dos contre un mur, les talons collés ensemble
90°
pouces. Veuillez faire des mesures de pied en millimètres. 1. Passez le ruban sous les bras, autour de la partie la plus 1. Placez un outil plat et rigide (ex. : règle de bois)
Arrondissez au demi-pouce le plus proche et au millimètre forte de la poitrine, juste sous les omoplates (Figure 3A). sur la tête pour former un angle de 90° avec le mur.
près. Le ruban doit être parallèle au sol et bien ajusté sans trop 2. Placez le début du ruban à cet endroit et mesurez
serrer le corps. en ligne droite la distance jusqu'au plancher.
BESOIN D’AIDE ? La mesure correspond Dos Devant
Méthode 2 (fournit une approximation à plus ou moins
Contactez votre corps ou escadron
au chiffre aligné
avec le début du un pouce ou 2,5 cm)
ruban (Figure 3B). Bras en croix à la hauteur des épaules
1. Placez le début du ruban au bout du majeur d'une
4