Professional Documents
Culture Documents
Governor - Adjust: Testing and Adjusting
Governor - Adjust: Testing and Adjusting
Shutdown SIS
Previous Screen
i01823283
Governor - Adjust
SMCS - 1264-025
The only adjustments that can be made to the governor on the engine are the final low idle setting
and high idle setting. Refer to Testing and Adjusting, "Fuel Ratio Control - Adjust" for the
procedure in order to check the settings for the fuel ratio control (FRC).
Note: All other adjustments for the governor (including the FRC) are performed while the
governor is removed from the engine and installed on the 1U-7326 Governor Calibration Bench.
Refer to the Governor Service Manual, SENR6454 for the procedures and the tools that are
required to bench test the governor and adjust the governor.
Note: The following adjustments are performed while the governor is mounted to the engine: unit
injector, fuel timing dimension and unit injector synchronization. These adjustments are located
under the valve cover. Refer to the following topics for more information: Testing and Adjusting,
"Unit Injector - Adjust", Testing and Adjusting, "Fuel Timing Dimension - Adjust" and Testing
and Adjusting, "Unit Injector Synchronization - Adjust".
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 08/04/2020
3126 Marine Engine 6MK00001-UP(SEBP3031 - 27) - Documentation Page 2 of 4
Illustration 1 g00700472
Note: Refer to the engine information plate or Technical Marketing Information (TMI)"Governor
Bench Performance Data" for the correct low idle speed, high idle speed and the fuel setting.
Note: Older governors require a 1U-6672 Rack Adjusting Wrench in order to adjust the low idle
screw. Newer governors require a 1U-7563 Hex Key Wrench (4 mm) and a 6V-9093 Wrench (13
mm) in order to adjust the low idle screw.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 08/04/2020
3126 Marine Engine 6MK00001-UP(SEBP3031 - 27) - Documentation Page 3 of 4
Illustration 2 g00931169
(5) Solenoid
(6) Bolts
1. Align the linkage for plunger (3) with governor linkage (2) .
3. Place the plunger for solenoid (4) in the full energized position.
4. Adjust the linkage for plunger (3) to 4 ± 2 mm (0.2 ± 0.08 inch) past high idle.
5. Release the plunger for solenoid (4) and manually move plunger (4) through the entire
stroke of plunger.
6. Check for binding in the movement. Make adjustments to bolts (6) if binding occurs.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 08/04/2020
3126 Marine Engine 6MK00001-UP(SEBP3031 - 27) - Documentation Page 4 of 4
Copyright 1993 - 2020 Caterpillar Inc. Wed Apr 8 15:23:54 UTC+0100 2020
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 08/04/2020