Professional Documents
Culture Documents
T568B Wiring Scheme: TX6A Shielded Modular Plug T568B & T568A
T568B Wiring Scheme: TX6A Shielded Modular Plug T568B & T568A
“V” channel
Contact slots Divider post
(Cable end 2) • Align the conductor divider “V” channel with the green pair.
2 BLU
(Cable end 1) • Insert divider posts into the cable. If the cable has an internal
GRN spline, insert divider posts into the brown and orange
ORG
Drain wire quadrants of the spline.
Drain wire
“V” channel ORG
“V” channel
GRN BRN
BLU BRN
“V” channel
(Cable end 1)
Verify
load bar (Cable end 1)
orientation
1
Pins 8
1
Pins 8
(Cable end 1)
• Grip the strain relief collar and insert cable sub-assembly into
9 10 MPT5-8AS
the plug housing. (Fig. 9)
• Push sub-assembly into housing until collar locking tabs
engage the plug housing pocket. Although not required, TX6
PLUS Plug Assembly Tool (CSPT) is available to facilitate this
step.
Plug
housing • Use tool MPT5-8AS to complete plug termination. (Fig. 10)
• Trim or press excess drain wire between the collar latches.
• Push up boot and engage with collar latches.
• Visually check plug. Assembly is complete.
“V” channel
Contact slots Divider post
2 BLU
(Cable end 2) • The “V” channel should be aligned with the orange pair.
• Insert divider posts into the cable. If the cable has an internal
(Cable end 1)
ORG spline, insert divider posts into the brown and green quadrants
GRN Drain wire of the spline.
Drain wire
“V” channel GRN
“V” channel
ORG BRN
BLU BRN
“V” channel
(Cable end 1)
5 (Cable end 2) • Orient load bar with contact slots facing downward.
Verify
(Cable end 1)
load bar
orientation
1
Pins 8
1
Pins 8
(Cable end 1)
g p
(Cable end 2) • Hold the load bar and divider stationary while sliding the strain
8 Drain wire relief collar forward until there is no gap between the collar
Collar barbs Collar latches and divider.
• Ensure the drain wire is routed through the strain collar
guides.
Strain collar • Confirm the cable jacket extends beyond the collar barbs.
guides
Boot position
1
when using • Align pin #1 of cable sub-assembly (cable, load bar, divider,
Pins CSPT and strain relief collar) with pin #1 of plug housing.
8
(Cable end 1)
1 Collar locking
Pins tabs
8
• Grip the strain relief collar and insert cable sub-assembly into
9 10 MPT5-8AS
the plug housing. (Fig. 9)
• Push sub-assembly into housing until collar locking tabs
engage the plug housing pocket. Although not required, TX6
PLUS Plug Assembly Tool (CSPT) is available to facilitate this
Plug step.
housing
• Use tool MPT5-8AS to complete plug termination. (Fig. 10)
• Trim or press excess drain wire between the collar latches.
• Push up boot and engage with collar latches.
• Visually check plug. Assembly is complete.
www.panduit.com/resources/install_maintain.asp Phone:
www.panduit.com 866-405-6654
Page 4 of 4