Professional Documents
Culture Documents
Class Test Q Paper HE-I
Class Test Q Paper HE-I
Class Test Q Paper HE-I
Note: The examination is of 2 hour duration carrying 60 marks. All Questions are
compulsory. There is no negative marking.
Name :……………………………………………………………………........
Signature:……………………Date:……………
Page 1 of 6
(c) Lumens
(d) Ampere
24. With the increase in preventive maintenance cost, breakdown maintenance cost
(a) Increases
(b) Decreases
(c) Remain same
(d) Any of the above
25. Which fuel is prepared by heating bituminous coal continuously for 15 to 18 hours in
closed chamber?
(a) Charcoal
(b) Anthracite
(c) Coke
Page 2 of 6
(d) Peat
26. Which is the correct advantage of solid fuels out of given option?
(a) They have low ignition temperature
(b) They produce small amount of smoke
(c) They have higher calorific value
(d) They do not form any clinker
27. Choose the proper disadvantage of solid fuels out of given option?
(a) They produce lot of smoke
(b) They have low ignition temperature
(c) They are high in production cost
(d) They cannot be easily transported
28. In what forms are liquid fuels available in nature?
(a) Light distillate
(b) Petroleum spirit
(c) Petroleum naphtha
(d) Crude petroleum
29. Name the process used to eliminate impurities present in crude oil?
(a) Distillation
(b) Filtration
(c) Sedimentation
(d) Coagulation
30. Which fuel is heavier than petrol but less volatile and it is used as domestic fuel?
(a) Diesel
(b) Distilled fuel
(c) Kerosene
(d) Alcohol
31. Which liquid fuel is used in furnaces of oil fired boiler?
(a) Fuel oil
(b) Petrol
(c) Distillate
(d) Alcohol
32. Which fuels exist in both natural and artificial physical state?
(a) Gaseous fuels
(b) Solid fuels
(c) Liquid fuels
(d) Nuclear fuels
33. Which gaseous fuel is called as town gas?
(a) Natural gas
(b) Coke oven gas
(c) Coal gas
(d) Mond gas
34. Select the incorrect statement from the following option
(a) Water which does not form lather with soap and forms white scum is called hard water
(b) Hard water contains dissolved calcium and magnesium salts in it
(c) In hard water, cleansing quality of soap is depressed
(d) Due to the presence of dissolved hardness-producing salts, the b.p. of water is depressed
35. Select the incorrect statement from the following option
(a) Permanent hardness is due to dissolved chlorides and sulphates of Ca and Mg
Page 3 of 6
(b) It can be removed by mere boiling of water
(c) It is also known as non-alkaline hardness
(d) The difference between total hardness and alkaline hardness gives the non-alkaline hardness
37. In which process of water softening, ion exchange phenomenon takes place?
(a) Lime soda process
(b) Zeolite process
(c) Boiling
(d) Demineralization process
40. To close and open an electric circuit electrical component used is called
(a) switch
(b) plug
(c) socket
(d) extension
Page 4 of 6
43. What is the part of the Bunsen burner that you move to change the type of flame you
produce?
(a) The air hole
(b) The base
(c) The jet
(d) The collar
44. What is the condition for conduction mode of heat transfer between two bodies?
(a) the two bodies must be in physical contact
(b) there must be temperature gradient between the bodies
(c) both a. and b.
(d) none of the above
45. In which mode, does the heat energy transfer between two bodies when they are separated
by some distance and there is no any medium between them?
(a) conduction mode of heat transfer
(b) convection mode of heat transfer
(c) radiation mode of heat transfer
(d) heat transfer cannot takes place with above condition
46. The conduction heat transfer with combination of transfer of material also is called as
(a) material conduction heat transfer
(b) convection heat transfer
(c) solid convection heat transfer
(d) none of the above
49. Dead organisms are transformed into petroleum and natural gas in :
(a) the absence of air
(b) presence of air
(c) presence of light
(d) none of these
Page 5 of 6
(b) HVAC
(c) BTU
(d) CFL
53. Calculate the electricity bill of a small hotel for the month of November 2019 having the
following electric loads: (6 marks)
60 W bulbs 10 Nos. 6 hrs/day
60 W fans 10 Nos. 5 hrs/day
3 kW heater 03 Nos. 4 hrs/day
750 W iron 02 Nos. 3 hrs/day
6 kW boiler 01 No. 3 hrs/day
Assume Cost of electric energy is Rs. 5/- per unit.
Page 6 of 6