Professional Documents
Culture Documents
Engine Support1 PDF
Engine Support1 PDF
Engine Support1 PDF
D
LA
Question asked (9):
What type of heat exchanger is shown in the illustration?
Selected answer (score 0):
Don't know
Correct answer:
Plate
On a fire patrol at night you see smoke coming from a closed cabin door. What action
should you take first?
Selected answer (score 0):
Don't know
AR
Correct answer:
Activate the nearest fire alarm button and advise bridge of the location of the fire.
Page 1/12
Wrong answer summary
D
It is important that the rotation direction is correct to avoid dry running.
LA
While trying to deballast a double bottom tank problems are encountered getting suction
on the ballast pump, a centrifugal pump mounted above the tank top. What action can be
taken to solve the problem?
Selected answer (score 0):
Don't know
Correct answer:
Prime the pump with seawater from the main inlet valve.
failure.
IA
Correct answer:
the atmosphere via the atmospheric line
Page 2/12
Wrong answer summary
D
Over tightening of the gland packing.
LA
Question asked (3548):
What will happen when the ship arrives in Rotterdam?
Selected answer (score 0):
Don't know
Correct answer:
The ship will receive fuel and diesel oil bunkers
Correct answer:
Adjustable wrench
Page 3/12
Wrong answer summary
D
Fasten seat belts
LA
What is a hydrostatic release unit?
Selected answer (score 0):
Don't know
Correct answer:
A unit which automatically releases the liferaft/lifeboat at a depth of approx 4 metres.
Correct answer:
All the answers are good
Page 4/12
Wrong answer summary
D
Carry out a right or left hand search and proceed carefully, feeling the area in front with
the foot and using the back of the free hand to check the area around.
LA
Question asked (10515):
Give the meaning of the following symbol
Selected answer (score 0):
Don't know
Correct answer:
Area protected by halon
If conditions permit, which is the best way to board a liferaft which is floating close to the
ship?
Selected answer (score 0):
Don't know
AR
Correct answer:
Use a rope ladder close to the raft to climb down and board
Page 5/12
Wrong answer summary
D
8
LA
When must personal protective equipment be worn
Selected answer (score 0):
Don't know
Correct answer:
At all times when identified as a control method with risk assessment
Correct answer:
Voyage itinerary and departure and arrival times.
Page 6/12
Wrong answer summary
D
Notify Deck Officer and Engineer Officer in charge. The loop for the smoke detector
should be isolated while work is done and normal precautions for hot work taken including
permit to work.
LA
Question asked (32355):
Why should boiler sootblowers normally only be operated in the correct sequence?
Selected answer (score 0):
Don't know
Correct answer:
PA
To ensure soot is cleared progressively from the bottom tubes to the top and toward the boiler uptakes.
Correct answer:
Inform the Officer of the watch immediately so that arrangements can be made to replace
the leaking glass.
IA
information relating to the hazards associated with the chemicals involved in this task?
Selected answer (score 0):
Don't know
Correct answer:
The material safety data sheets supplied with the chemicals.
M
Page 7/12
Wrong answer summary
After cleaning some machinery components at sea, the engine watch rating is instructed
to dispose the small amount of dirty diesel oil which is left. How should the dirty oil be
disposed?
Selected answer (score 0):
Don't know
Correct answer:
Put it straight into the dirty oil tank for incineration at the next opportunity.
D
Question asked (32522):
The engine rating on watch finds the level of the diesel engine jacket water header tank
LA
well below normal. After topping up the tank and checking around the engine, a leak is
found. What action should be taken?
Selected answer (score 0):
Don't know
Correct answer:
happened.
The engine room rating has been assisting with ballast operations during a period of
engine room watch duty. Ballast operations have stopped for a couple of hours while
stores are being taken. What action should the rating take during this break in
G
operations?
Selected answer (score 0):
Don't know
Correct answer:
N
Stop all of the ballast pumps and close all of the ballast valves as soon as operations are
stopped. Ballast lines should always be closed except when they are being used.
IA
Page 8/12
Wrong answer summary
During maintenance work at sea an engine room rating is moving a heavy component to
the workshop using a chain block attached to an overhead trolley on a rail. Part way
through the operation the rating is asked by the engineer to go immediately to the store
for some equipment. What should the rating do?
Selected answer (score 0):
Don't know
Correct answer:
Continue with the moving operation until the component is properly secured in the
D
workshop before going to the store for the equipment.
LA
Question asked (32608):
An engine room rating notices that the guard on a running pump is hanging loose due to
a missing bolt on the support bracket and it is catching the shaft coupling. What is the
best action to take as a repair method?
Selected answer (score 0):
Don't know
Correct answer:
PA
Inform the watchkeeper so that the pump can be stopped and a new bolt can be fitted to
permanently fix the guard in place.
Check the bolts are correctly tightened before informing the engineer so that the flange
faces can be cleaned and re-jointed if necessary.
IA
Page 9/12
Wrong answer summary
Most maintenance and repair tasks carried out onboard ship require a permit to work
which will include a full risk assessment. Where would an engine room rating find out
about the precautions that are required for a particular task?
Selected answer (score 0):
Don't know
Correct answer:
Ships Safety Management Manual (ISM Code procedures)
D
Question asked (32624):
A bilge strainer is blocking up during bilge pumping operations which is causing delays as
LA
the pump frequently loses suction and has to be primed. What action should be taken to
remedy the situation?
Selected answer (score 0):
Don't know
Correct answer:
stops.
Page 10/12
Wrong answer summary
D
If I saw a person falling overboard I would shout repeatedly, "Man overboard"
LA
What are the lists called that give the position and task during a lifeboat drill for all
persons on board the ship?
Selected answer (score 0):
Don't know
Correct answer:
The Muster List
Don't know
Correct answer:
Start heart compression and artificial respiration
Page 11/12
Wrong answer summary
D
Prominently marked and easily accessible
LA
PA
G
N
IA
AR
M
Page 12/12