Professional Documents
Culture Documents
Cultural Centre PDF
Cultural Centre PDF
CULTURAL CENTRE
TO
M/S. DARASHAW & CO. PVT LTD,
CHENNAI.
GS ASSOCIATES
+ 91 - 9840073732
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
PAGE
SL.NO. LIST OF CONTENTS
NO.
1.0 INTRODUCTION 1
1.2 OBJECTIVE 1
1.13 RECOMMENDATIONS 7
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD
COIMBATORE & MADURAI CHENNAI I
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
PAGE
TABLE NO. LIST OF TABLE
NO.
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD
COIMBATORE & MADURAI CHENNAI II
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
1.0 INTRODUCTION
M/S. DARASHAW & CO. PVT LTD is planning to construct Cultural Centre at Rameswaram
in Ramanathapuram district. M/s. GS ASSOCIATES, Madurai, carried out this investigation
and completed field work on 2st February 2020 according to the instructions from Project
in-charge of the project. This report contains the geo technical investigation details of two
Bore Holes of Cultural Centre at Rameswaram in Ramanathapuram District.
1.2 OBJECTIVE
The objective of soil investigation is to ascertain the nature and characteristics of sub-soil
below the ground level at the site and to establish relevant properties for determination of
safe bearing capacity of soil.
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 1
MADURAI CHENNAI
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 2
MADURAI CHENNAI
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
drilling mud. Standard penetration tests, disturbed sampling, field identification of soil &
rock samples, etc., was carried out in these bore holes.
Standard Penetration Test (SPT) was performed on the sub soil. In this test, a standard
split spoon of length about 460 mm and external/internal diameter of 51/35 mm initially
penetrates the soil for 15cm to bypass the expected accumulated sludge at the bottom of
the hole by means of a 63.5 kg (140 lb ) hammer falling freely along a guide from a height
of 760 mm. The total number of blows (N) required, to advance the spoon into the
bore, for another two successive 15cm (a total of 30 cm) is recorded as a measure of
the soil relative density or consistency as given in Table 1.1. SPT was conducted at a depth
interval of 1.5m below the ground level. The fieldwork was carried out under the close
supervision of our engineer in accordance with Indian Standard mentioned earlier.
A) Granular Soil
B) Cohesive Soil
COHESIVE APPROX. RANG
SPT UCS (QU),
SL.NO DESCRIPTION STRENGTH (C), OF MOST. UNIT
N - Value KPA
KPA WT. KN/M3
1 <2 Very Soft 0 to 25 0 to 12.50 14.40 to 16.00
2 02 to 04 Soft 25 to 50 12.50 to 25 16.00 to 17.74
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 3
MADURAI CHENNAI
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
Note: These Values are most Appropriate Values in general. However, the Soil Properties
vary between Sites to site and hence it shall be used only for guidance
1 BH 1 10.00 -- -- 10.00
2 BH 2 10.00 -- -- 10.00
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 4
MADURAI CHENNAI
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
Specific Gravity: This test was conducted in all disturbed soil samples to find Specific
gravity of soil as per IS 2720 (Part 3) : 1980
Sieve Analysis: These test conducted to identify and classify the samples as per IS 2720
(Part 4) : 1985
Liquid Limit: This test conducted in fine-grained soils to find the liquid Limit of the soil
as per IS 2720 (Part 5) : 1985
Plastic Limit: This test conducted in fine-grained soil to find plastic limit of the soil as per
IS 2720 (Part 5) : 1985
Direct Shear Test: This test conducted in coarse-grained soil to find the angle of
shearing resistance of the soil as per IS 2720 (Part 13) : 1986
Unconfined Compression Test: This test conducted in fine-grained soil to find
Cohesion of the soil as per IS 2720 (Part 10): 1995.
BORE HOLE 1
LAYERS DESCRIPTION OF SOIL
0.00m to 6.00m Fine Sand
6.00m to 10.00m Coarse Sand
BORE HOLE 2
LAYERS DESCRIPTION OF SOIL
0.00m to 6.00m Fine Sand
6.00m to 10.00m Coarse Sand
Drilling Stopped at 10.00m below Ground Level
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 5
MADURAI CHENNAI
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
The top layer up to 6.00 m is Fine Sand followed by Coarse Sand up to 10.00m is
considered for Open foundation. The bearing capacity has been assessed as per the IS
6403: 1981. The allowable bearing pressure is calculated as per IS 8009(Part 1)-1976
(Reaffirmed 1998). A factor of safety of 2.5 has been adopted to arrive at the safe bearing
capacity.
Since the structural design was not done for the proposed Cultural Centre, the maximum
column load is not known. Therefore, the bearing capacity for different type of foundations
are recommended. After Structural Design, the depth of foundation will decided by the
structural engineer according to the load & SBC value.
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 6
MADURAI CHENNAI
CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION OF
PROPOSED CONSTRUCTION OF CULTURAL CENTRE @ RAMESWARAM
SUB SOIL INVESTIGATION REPORT
IN RAMANATHAPURAM DISTRICT. CULTURAL CENTRE
1.13 RECOMMENDATIONS
Based on SBC, the recommendation for foundation is submitted for Entrance Arch is
presented in the Table 1.4
Table 1.4 Abstract for SBC Calculations
CONSULTANT CLIENT
GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD 7
MADURAI CHENNAI
TEMPLE STREET
BH1
Name of Work : Conducting Rotary Bore for Sub Soil investigation for Proposed Construction of Cultural
Centre @ Rameswaram in Ramanathapuram District.
Type of Samples
Depth from OGL
Identification)
Representation of
Description of
Soil Profiles
Depth (m)
N - Value - Depth of Penetration SPT
(Visual
(RL)
Soil
Type 15 30 45 N N Value
5 cm Penet of
-1.000 m Coarse Sand 1.50 SPT 21 >55 D
55 Blows
11 cm Penet of 55
-2.500 m Coarse Sand 1.50 SPT >55 D
Blows
9 cm Penet of 55
-4.000 m Coarse Sand 1.50 SPT >55 D
Blows
Name of Work : Conducting Rotary Bore for Sub Soil investigation for Proposed Construction of Cultural
Centre @ Rameswaram in Ramanathapuram District.
Type of Samples
Depth from OGL
Identification)
Representation of
Description of
Soil Profiles
Depth (m)
N - Value - Depth of Penetration SPT
(Visual
(RL)
Soil
Type 15 30 45 N N Value
7 cm Penet of
-1.000 m Coarse Sand 1.50 SPT 19 >55 D
55 Blows
12 cm Penet of 55
-2.500 m Coarse Sand 1.50 SPT >55 D
Blows
8 cm Penet of 55
-4.000 m Coarse Sand 1.50 SPT >55 D
Blows
Specific Gravity
SBC in T/Sqm
Bulk Density
Dry Density
Angle of friction
Cohesion "C" in
Plasticity Index
(t/m )
(t/m )
Depth of Soil Description
Medium Sand
3
Coarse Sand
Plastic Limit
Liquid Limit
Silt & Clay
Fine Sand
Soil (m) (Visual Identification)
(t/cm )
Gravel
2
NMC
(WP)
(WL)
(IP)
(ø)
1.50 Fine Sand 0.00 1.34 42.09 48.26 8.31 9.19 NA NA NA 1.687 1.545 2.70 0.000 27.0 10.14
3.00 Fine Sand 0.00 1.66 42.27 48.02 8.05 9.26 NA NA NA 1.699 1.555 2.70 0.000 27.0 21.59
4.50 Fine Sand 1.23 1.89 41.99 47.83 7.06 9.35 NA NA NA 1.707 1.561 2.69 0.000 27.0 36.33
6.00 Coarse Sand 2.11 32.19 42.17 18.29 5.24 9.42 NA NA NA 1.714 1.566 2.69 0.000 28.0
7.50 Coarse Sand 2.06 32.51 42.53 18.21 4.69 9.61 NA NA NA 1.720 1.569 2.69 0.000 28.0
9.00 Coarse Sand 2.17 33.18 42.82 17.93 3.90 9.85 NA NA NA 1.723 1.569 2.68 0.000 28.0
10.00 Coarse Sand 2.23 33.62 43.15 17.46 3.54 10.21 NA NA NA 1.726 1.566 2.68 0.000 29.0
GS Associates
GEO-TECH ENGINEERING DIVISION
SUMMARY OF LAB TEST RESULTS
Name of Work : Conducting Rotary Bore for Sub Soil investigation for Proposed Construction of Cultural Centre @ Rameswaram in
Ramanathapuram District.
BORE HOLE NO - 2
Specific Gravity
SBC in T/Sqm
Bulk Density
Dry Density
Angle of friction
Cohesion "C" in
Plasticity Index
(t/m )
(t/m )
Depth of Soil Description
Medium Sand
3
Coarse Sand
Plastic Limit
Liquid Limit
Silt & Clay
Fine Sand
Soil (m) (Visual Identification)
(t/cm )
Gravel
2
NMC
(WP)
(WL)
(IP)
(ø)
1.50 Fine Sand 0.00 0.79 42.07 48.51 8.63 9.05 NA NA NA 1.689 1.549 2.70 0.000 27.0 10.17
3.00 Fine Sand 0.00 1.09 42.68 48.27 7.96 9.14 NA NA NA 1.693 1.551 2.70 0.000 27.0 21.42
4.50 Fine Sand 1.53 1.42 42.92 47.83 6.30 9.31 NA NA NA 1.698 1.553 2.69 0.000 27.0 35.89
6.00 Coarse Sand 2.11 32.79 42.53 18.67 3.90 9.37 NA NA NA 1.704 1.558 2.69 0.000 28.0
7.50 Coarse Sand 2.18 33.04 42.69 18.34 3.75 9.63 NA NA NA 1.709 1.559 2.69 0.000 28.0
9.00 Coarse Sand 2.24 33.27 42.81 18.26 3.42 9.82 NA NA NA 1.713 1.560 2.68 0.000 28.0
10.00 Coarse Sand 2.31 33.64 43.04 17.93 3.08 10.16 NA NA NA 1.718 1.560 2.68 0.000 29.0
PROPOSED SITE (RL:5.000)
RL:5.000
4.000
3.000
2.000
6.0 M
1.000
0.000
-1.000
-2.000
-3.000
4.0 M
-4.000
-5.000
BH-1 BH-2
LEGEND
FILLING SOIL
FINE SAND
LONGITUDINAL SECTION FOR COMBINED BORE HOLE
COARSE SAND
SL.NO DESCRIPTION REV.NO DATE DESIGN CONSULTANT :- CLIENT:- NAME OF WORK:- TITLE:-
1 For Submission 0 19.02.2020 GS ASSOCIATES M/S. DARASHAW & CO. PVT LTD., CONDUCTING ROTARY BORE FOR SUB SOIL INVESTIGATION
LONGITUDINAL SECTION FOR
ENGINEERS, HIGHWAY DESIGNERS, VALUERS, GEO-TECH CONSULTANTS COMBINED BORE HOLE
No:12,Pushpanjali Garden, Shenbagaboo Street, CHENNAI. FOR CULTURAL CENTRE AT RAMESWARAM,
Ezhil Nagar, Iyerbungalow, PHONE NO: 044 - 28235951, 52, 53 RAMANATHAPURAM DISTRICT. DWG NO :GSA/DCPL/RMM/CC/02
Madurai - 625014 REV : 0
DATE : 19.02.2020
DESIGNED BY: S.M.D CHECKED BY: M.S APPROVED BY: P.R SCALE : 1:100
SHEET : A4