Download as pdf or txt
Download as pdf or txt
You are on page 1of 4

1 A large insulated sphere of radius r charged with

7 Capacitance of a capacitor becomes


Q units of electricity is placed in contact with a
small insulated uncharged sphere of radius r'and original value if a dielectric slab of ths
3 times its
is then
will now be
separated. The charge on smaller sphere t = d/2 is inserted between
the
(d separation between the plateg Plate
=
thickness
(a)Q(r+ r) (b) Qr - r) dielectric constant of the slabis 8).
The
(d) Qr (a) 6 (b)8
(c) (c) 2 d) 4
r'+T r'+r
i.2 If the electric flux entering and leaving an 8 The potential field of an electric field
enclosed surface respectively is 4 and d. the E =(yi+ x j) is
electric charge inside the surface will be
(a) V = - x + y)+ constant
(a) 2 (b)+
(b) V = Constant
(c)V=-(x + y)+ constant
(c) (d)eol+) (d) V - xy + Constant

9 The capacitance of the capacitor of plate aro


3 A charge (g) and another charge (+ Q) are kept at A and A,(4, <A,)at a distanced
two points A and B respectively. Keeping the
at B, the charge
charge(+Q)fixed (-g)at A is moved
to another point C such that ABC forms an
equilateral triangle of side I. The net work done in
moving thee charge (-q) is
(a) Q4 1 Qg d
47T& D 4TEn l1
(a)o l tA4)
(c) Qql (d) zero 2d d
47t&0
4 Workdone in placing a charge of 8 x 10" C on a (c)ov4,4
d d
condenser of capacity 100 uF is 10Two condensers C, and C2
.

circuit are joined


in a
(a) 16 x 10-2 J (b) 3.1 x 10-26 J as shown in the figure. The potential of point Ais
(c) 4x1010 J (d) 32 x 1032 J Vand that of B is V2. The potential of point Dwill
5 If two conducting spheres are separated be
charged
and then brought in contact
(a) The total energy of the two spheres is D 2
conserved V1
(b) The total charge on the two spheres is
Conserved
(c) Both the total energy and the total charge are
conserved b) +CGy
(d) The final potential is always the mean of the C +C2
original potential of the two spheres (c +C,V,
6 One plate of capacitor is connected to a spring and C +C2
area of both the
plates is A. In steady state, (d G
separation between the plates is 0.8 d (spring was C +C2
unstretched and the distance between the plates 1 A cylinder of radius R and length L is placed in a
15.
was d when the capacitor was uncharged). The
uniform electric field E parallel to the cylinder
forcé constant of the spring is approximately total electric flux for the surface of the
axis, the
( a )e , p e
(b) e p A p
cylinder is
Ad3 d (a) 2rE
E
T +TR
2d (c)
E
(d) zero
The potential at a point x (measured in um) due to 16 A charged ball B hangs from a silk thread S, which
12 ome charged situated on the x-axis is given by makes an angle 9 with a large charged conducting
V(x) = 20/(x* - 4)volt sheet P,as shown in the figure. The surface charge
The electric field E at x = 4 um is given by density o of the sheet is proportional to

(a) cos 0 (b) cot 9 (c) sin 0 (d) tan 0


(alVum and in the -ve xdirection 17 A parallel plate capacitor is made by stacking n
If
bVumandin the -ve x-direction
equally spaced plates connected alternatively.
the capacitance between any two adjacent plates
3
is C, then the resultant capacitance is
(cVum and in the -ve xdirection (a) (n - 1)C (b) (n + 1)C
and in the +ve x-direction (c) C (d) nC
dVum 18Consider
9 the charge
configuration and a spherical +91 92
13A parallel plate condenser with a dielectric of
Gaussian surface as shown in
dielectric constant K between the plates has a
capacity C and charged potentialV
is to a volts. The the figure. When calculating
dielectric slab is slowly removed from between the the flux of the electric field
plates and then reinserted. The net work done by over the spherical surface, the S

the system in this process is AIEEE 2007 electric field will be due to
B
a ) , (K - 1)Cv
(b)Cv(K -1)/K
(c)(K -1)Cv (d) zero (a)2
(b) only the positive charges
14 A battery is used to charge a parallel plate (c) all the charges
capacitor till the potential difference between the (d) +91 and -g1
plates becomes equal to the electromotive force of 19A charged particle q is shot towards another
he battery. The ratio of the energy stored in the
charged particle Q which is fixed, with a speed
v.
apacitor and the work done by the battery willbe
AIEEE 2007 It approaches Q upto a closest distance r and then
returns. If q was given a speed 2v, the closest
(a) 1 (b) 2
1 distance of approach would be
(d)
(
15Two insulating plates are both uniformly charged
in such a way that the potential difference (b) 2r
(a) r
between them is V, -V 20V. (ie, plate 2 is at a
=

The plates are separated by (d)


higher potential).
d 0.1 m and can be treated as infinitely large. An
from rest on the inner surface 20Ametallic shell has a point charge q kept inside its
electron is released
cavity. Which one of the following diagrams
ofplate 1. What is its speed when it hits plate
2?
AIEEE 2006 correctly represents the electric lines of forces?
IT JEE|2003
(e =1.6 x10 C, m, = 911 x 10kg)

(a)
Y

-0.1 m
L
2 (c) (d)
(a) 2.65x 10 ms1 (b) 7.02 x10 ms1
(c) 1.87 x10 ms d) 32 x 101 ms1
resistlance 152 gives full 10
alvanometeer of
A galv
scale
A www ww
21 for a
current ot 2 mA. Calculate the
dection needed to convert it into an
shun
nt resistance 20
of range 5A. 6V
nmeter
(a)0.178Q (b) 0.0020
(c)0.006 2 (d) 52
s of the three wires of same material are in
Mas.
(a) 32 (b) 2
22 lengths in the ratio of
and their
ao Tatio of1:2:3 (c) 6/50 (d) 5/6
a-2: 1. Electrical resistance ofthese wires will be 26 In the circuit shown in figure. The point F is
ratio of
in the grounded. Which of the following is wrong
(a)1:1:1 (b) 1:2:3 statement?
( C9
) :4:1 (d)27:6:1
represents a current-voltage behaviour w
23 The graph
Br
fa
of water voltameter figure spot the correct
explanation.

DT 3V
10V
40
wwww. E

Potential difference (a) D is at 5 V


not obey Ohm's law b) E is at zero potential
a) Electrolytes do
b) Ohm's law is not valid for low voltages (c) The current in the circuit will be 0.5 A
takes place at E and it obeys
c) Dissociation (d) None of the above
Ohm's law there after
27 The deflects full scale for a
galvanometer
Ohm's law is obeyed but only for potential
80
d) potential of 20 mV. A voltmeter deflecting We
fuil
difference than the back emf
larger scale of 5V is to made using this galvanometer.
resistance of n resistors each of
24 The equivalent connected in series is R. If
must connect
same resistance when resistance of 19.92 kM parallel to the
connected in the parallel (a) a
the same resistances are galvanometer
will be
equivalent resistance
(b) a resistance of 19.92k2 in series with the
(b) R/n
a) Rim galvanometer
(d) nR resistance of 20 k2 parallel to the
c) R c) a

25 The effective resistance between points A and B galvanometer


resistance of 20 k2 in series with
(d) a
S galvanometer
R C 2R
A ww www7B 28 The reading of amneter shown in tigure is

2
www.
2R
6 ww

5 ww
(a) R (b) R3
(14V 0.8 2)
c) 2R3 (d) 3R/5
resistances is
24 An infinite ladder network of (a) 6.56 A
shown
2Qresistance as
Constructed with 1Q and (b) 3.28 A
between A and B has
n figure. The 6V battery (c) 2.18 A
etfective
negligible internal resistance then (d) 1.09 A
resistance between A and B is
20
In the circuit in figure the potential difference
29 wwA
across P and Q will be nearest to
www 30
1002 6V 60
48V 10 40
ww- D W
800-oQ
1002 200 oP (a) 5 V (b) 9V
(c) 10.4 VV (d) 11.4 V
. The V -I graph for a conductor at tempe
(b) 6.6 V
36 T and T2 are as shown in the figure, "Th
(a) 9.6 V ne
(c) 4 V (d) 3.2 V T-T is proportional to tetm
A DC milliammeter has a resistance of 12N and
30
current of 0.01 A.
gives a full scale deflection for a T2
To convert it into a voltmeter giving a full scale
deflection 3V, the resistance required to be put in
series with the instruments
(a) 102 Q (b) 2882
(c) 300 2 (d) 4122
31 The length of a potentiometer wire is 5 m. An Current (
electron in this wire experiences a force of
4.8 x 10" N, emf of the main cell used in (b) sin 24
(a) cos 29
potentiometer is (c) cot 20 d) tan 29
(a) 3 V (b) 15 V
(d) 5 V
37 A 6V battery is connected to the terminals ot.
(c) 1.5 V three metre long wire of uniform thickness an
32 In a potentiometer of 10 wires, the balance point resistance of 100 2 The difference of potential
is obtained on the 7th wire. To shift the balance
between two points on the wire separated by a
point to 9th wire, we should
distance of 50 cm will be
(a) decrease resistance in the main circuit (a) 2 V (b) 3 V
(b) increase resistance in the main circuit (c) 1 V (d) 15 V
c) decrease resistance in series with the cell
whose emf is to be measured
(d) increase resistance in series with the cell
whose emf is to be determined
33 In an experiment to measure the internal
resistance of a cell by potentiometer, it is found
that the balance point is at a length of 2 m when
the cell is shunted by a 4Q resistance; and is at a
length of 3 m when the cell is shunted by a 8Q
resistance. The internal resistance of the cell is,
then
(a) 122 (b) 82
(c) 162 (d) 1
34 A voltmeter having resistance of 1800 N is
employed to measure the potential difference
across 200N resistance which is connected to DC
power supply of 50V and internal resistance 202.
What is the percentage change in potential
difference across 200 Q resistance as a result of
connecting voltmeter across it ?
(a) 1% (b) 5%
(c) 10% (d) 20%
35 What is the potential difference between points
A and D of circuit shown in figure?

You might also like