Professional Documents
Culture Documents
Wired Tracker GPS Installation
Wired Tracker GPS Installation
Note: The wired tracker device (GPS) must be installed by an authorized technician, or at least a person with
electrical accessories knowledge. The installation of the tracker device and any accessories requested by the
client shall be carried out by either client or a client third party. Therefore, TrackingUSA LLC will not be liable for
any loss or damage whatsoever, arising directly or indirectly, as a result of any negligence or failure of client or
such third party in installing the product or accessories, client agrees that any damage sought for any such
negligence or failure shall be solely against such third party, as applicable. Client covenants and agrees at its sole
cost and expense to protect, defend, indemnify, release and hold TrackingUSA harmless from and against any and
all Losses imposed upon or incurred by or asserted against the Contractors and directly or indirectly arising out of
or in any way relating to the installation of the tracker device or any damage caused to the vehicle as a result of
its use or operation.
Installation instructions:
3) The technician must identify the cables to which he will connect using a voltmeter or tester before
connecting the cables. We recommend that you do not skin cables using the existing connectors
for this function. In case of peeling the cable and splicing, we recommend isolating the cable
correctly with a good insulating tape, and tightening the tape with a plastic seal to prevent the
tape from taking off over time.
4) Once the equipment is connected, the lights will begin flashing rapidly (up to 2 times x seconds)
and after a time (maximum 5 minutes), the 3 lights should flash very slowly (once every 3
seconds), indicating that the GPS is now ready to work. For the first time, it is recommended that
the vehicle is outside, since from inside a garage or shed, there may be difficulties for the
equipment to take the necessary signals to start operating.
5) We advise that the GPS is installed inside the board, hidden, that is not accessible by the driver
of the vehicle, and avoiding that it is under any metallic material (it should be as high as possible
and that between the equipment and the sky there is nothing metallic). Neither is it desirable that
there be any metal within 30 cm of the equipment.
6) We recommend that you use a security seal to secure the equipment and prevent it from
moving or falling.