Professional Documents
Culture Documents
Codigos de Luces C9 Reh
Codigos de Luces C9 Reh
Codigos de Luces C9 Reh
Previous Screen
Welcome: r440arm
Product: INDUSTRIAL ENGINE
Model: C9 INDUSTRIAL ENGINE REH
Configuration: C9 Industrial Engine REH00001-UP
i02890874
"Diagnostic" Lamp
Use the "DIAGNOSTIC" Lamp or Caterpillar Electronic Technician (ET) in order to determine the
diagnostic flash code.
Use the following procedure to retrieve the diagnostic codes if the engine is equipped with a
"DIAGNOSTIC" lamp:
1. Turn on the ignition system. The engine does not need to be started in order to view codes. The engine
does not need to be running while the ignition switch is in the ON position.
When the ignition key is in the ON position, the lamp is checked for proper operation. If there
are any active codes except for Code 34, the codes are displayed at this time.
Note: The "DIAGNOSTIC" lamp will illuminate for five seconds. The lamp will stay on if there is an
active diagnostic code.
2. The Active Diagnostic codes will always be flashed. There is no toggle switch that will shut off the
lamp.
3. The "DIAGNOSTIC" lamp will flash in order to indicate a two-digit code. The sequence of flashes
represents the system diagnostic message. Each digit of the two-digit code is determined by counting
the number of flashes. The lamp flashes at a rate of two times per second. The lamp will pause for one
second between digits. The lamp will pause for two seconds between codes.
Table 1 indicates the potential effect on the engine performance with active flash codes. Table 1 also forms a
list of Electronic diagnostic codes and descriptions.
Table 1
Diagnostic Flash Codes for C9 Engine
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/fulltext/fulltextheaderinfoframeset.jsp&calledpage=/si… 1/3
1/1/2020 C9 Industrial Engine REH00001-UP(SEBP4132 - 87)/Basic Search
Event
Intermittent Battery
51 X X X X X
Power to the ECM
Personality Module
52 X X X X X
Fault
The following
parameters must be
56 X X X
checked: Customer
and System
Incorrect Engine
59 X X X X
Software
Event for High
61 X X X X
Coolant Temperature
Event for Low
62 X X X X
Coolant Level
Low Fuel Pressure
63 X X X X
Event
Even for High Inlet
64 Manifold Air X X X
Temperature
Fault of Cylinder 1 or
72 X X X
Cylinder 2
Fault of Cylinder 3 or
73 X X X
Cylinder 4
Fault of Cylinder 5 or
74 X X X
Cylinder 6
(1) Shut down the Engine: Operate the engine cautiously. Get immediate service. Severe engine damage may result.
(2) The operator should go to the nearest location for service.
(3) The operator should investigate the problem at a convenient time.
(4) The Diagnostic Flash Codes reduce the effectiveness of the Engine Monitoring feature.
(5) These Diagnostic Flash Codes may affect the system only under specific environmental conditions such as engine start-up at cold
temperatures, etc.
Copyright 1993 - 2020 Caterpillar Inc. Wed Jan 01 2020 13:25:38 GMT-0500 (hora de Ecuador)
All Rights Reserved.
r440arm
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/fulltext/fulltextheaderinfoframeset.jsp&calledpage=/si… 3/3