Professional Documents
Culture Documents
Sensor de Movimiento
Sensor de Movimiento
6HQVRUGH
0RYLPLHQWRDXWLOL]DU
663
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
Contents Page
1. Use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1
2. Technical characteristics . . . . . . . . . . . . . . . . 1
3. Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
4. Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
5. Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
6. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
7. Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
8. Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
9. Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
10. Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
11. Standards and certifications . . . . . . . . . . . . 8
12. Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . 8
2. Technical characteristics
Voltage: 110 - 240 V~ LEARN LED
Frequency: 50/60 Hz
No-load power consumption: 0.6 W
Output via normally open contact connected to the phase
Wiring: 2 x 2.5 mm2 LEARN button
Number of terminals: 4
Terminal type: screwless Terminal prog.
Stripping length: 8 mm
Weight: 200 g 270° sensor/PIR
Impact resistance: IK04 sensor Detection LED
Penetration by solid and liquid matter: IP55
Usage temperature: - 25°C to + 45°C 360° sensor/PIR Light level
Storage temperature: - 25°C to + 70°C sensor cell
1 2 3 4 5 6 7 8
230 V~ 2000 W 8.5 A 1000 VA 4.3 A 1000 VA 4.3 A 10x(2x36 W) 4.3 A 250 W 1A 250 W 1A 250 W 1A 500 VA
2.1 A
110 V~ 1000 W 8.5 A 500 VA 4.3 A 500 VA 4.3 A 5x(2x36 W) 4.3 A 125 W 1A 125 W 1A 125 W 1A 250 VA
1 - Halogen bulbs 8 - Contactor
2 - ELV halogen, compact fluorescent and fluorescent bulbs with 9 - Motor
separate electronic ballast
3 - ELV halogen, compact fluorescent and fluorescent bulbs with
separate ferromagnetic ballast
4 - Fluorescent tubes
230 V~ 500 VA 2.1 A
5 - Compact fluorescent bulbs with built-in electronic ballast
110 V~ 250 VA max. I max. ≤ 2.1A
6 - Compact fluorescent bulbs with built-in ferromagnetic ballast
7 - LED bulbs U ≤ 30 V= 2.1 A max.
1/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
3. Dimensions
87
90
Ø:
143.5
4. CONNECTION
4.1 Wiring with auxiliary control:
8.5 A
max.
2
PB
100 m max.
S1 S2 SN
100 m max.
Contents 2/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
4. CONNECTION (continued)
4.3 Wiring for a single load connected in parallel
S1 S2 SN
8.5 A
max.
PB
100 m max.
S1 S2 N B
0 047 04
N B
4 126 02
PB
S- S+
S- S+
8.5 A
L 4
max.
L 4
100 m max.
With this wiring, the configuration tool must be on "Pulse" (see paragraph 8. Settings).
5. Removal
1 2
Contents 3/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
X2
IP55
X2
Attention:
SNAP
Break the tabs to allow water to
drain away.
SNAP
IP 55
1
6.2 Recommended light exposure
2.5 m
3.5 m
2
2.5 m
3.5 m
180°
3
120°
45°
Contents 4/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
7.1 More than one sensor and more than one load
The products can be synchronised in two steps:
- one long press (>1s) all the sensors (S) switch to the ON state
-o
ne short press all the sensors (S) inversion of OFF to ON or ON to OFF
IP 55
L1 OFF S1 OFF L1 ON S1 ON
PB
L2 OFF S2 OFF <1s L2 ON S2 ON
Ln OFF Sn OFF Sn ON
Ln ON
0 489 72
L1 ON S1 ON L1 OFF
PB S1 OFF
Sn ON Ln OFF Sn OFF
Ln ON
L1 OFF
L1 ON S1 ON PB S1 OFF
Sn OFF Sn ON
Ln OFF Ln ON
IP 55
L1 ON S1 ON PB L1 OFF S1 OFF
>1s
S2 OFF + L2 OFF S2 OFF
L2 OFF
<1s
Sn OFF Ln OFF Sn OFF
Ln OFF
S1 ON L1 ON S1 ON
L1 ON PB
L2 OFF S2 OFF >1s L2 ON S2 ON
Sn OFF Sn ON
Ln OFF
Ln ON
Contents 5/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
Modes
Walk-through Activate/
Active
mode Deactivate
S1 ON S1 OFF
PB Manual on/Auto
Inactive
Activate/
S2 ON S2 OFF off Deactivate
L ON <1s L OFF
Initial PIR Not modifiable −
Detection
Sn ON Sn OFF
system
Maintain PIR Not modifiable −
Contents 6/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
Activate/
mode
Regulation Active −
Deactivate
Light
Auto Auto - 1275 lux −
contribution
Height
Advanced mode: 2.5 m
alibration: The ambient light level measured with a luxmeter
C
must then be transmitted to the sensor (see data sheet
Cat. No. 0 882 30).
egulation: Automatic switch-off of the load 10 minutes after the
R
light level threshold is exceeded with an additional safety threshold
(to avoid lights switching off at the wrong moment).
m: 3 0 4
Light contribution: Quantity of additional lux brought in by the load
being switched on.
When the light contribution parameter is set to "Auto" (value 0) on
configuration tool 0 882 30, the sensor automatically calculates the light
contribution.
a: 3m 0 4m
Contents 7/8
PIR lighting management sensor - Outdoor version Cat. No(s): 0 489 33
Attention:
Always test before using other special cleaning products.
m: 3 0 5 10 15
11. Standards
Directive: CE
Installation standard: NFC 15-100
Product standards: IEC 60669-2-1
Environmental standards:
b - European Directive 2002/96/EC:
WEEE (Waste Electrical and Electronic Equipment).
- European Directive 2002/95/EC:
RoHS (Restriction of Hazardous Substances).
- Regulations: ERP (public buildings)
ERT (workplace buildings)
a: 3m 0 5m 10 m 15 m
IGH (high-rise buildings)
12. Troubleshooting
Contents 8/8