Professional Documents
Culture Documents
Synergy Question 2018
Synergy Question 2018
20
following conditions does this indicate?
A. There is a 4-5 minute supply of air remaining in the air cylinder. B. There is approximately 500 psi (3.5 Mpa) of
20
pressure left in the air cylinder. C. The wearer should immediately leave the contaminated area.
D. All of the above.
6. Stability of a vessel is defined as:
AM
A. Vessel will come not back to its initial position when external disturbance is withdrawn;
B. Vessel will come back to its initial position when external disturbance is withdrawn &by suitably shifting of weights;
C. Vessel will float at different position when external disturbance is withdrawn;
EX
D. Vessel will come back to its initial position when external disturbance is withdrawn;
7. Which of the following types of ships are assigned minimum freeboard?
A. Container ship B. Bulk CarriersC. Ore carriers D. Oil Tankers
8. Which of the following takes the weight of the rudder?
Y
A. The steering gearB. The rudder stockC. The rudder carrier bearing. D. The locking pintle.
G
9.The edge of the propeller which cuts the water first, when the ship is driven ahead is known as _______.
A. Face B. Trailing edge C. Leading edge D. Driving edge
ER
10.The mass of a ship without cargo, fuel, stores, water, crew etc that a ship carries is known as:
A. Deadweight B. Lightweight C. Displacement D. Tonnage
11. Purpose of evaporator in domestic refrigeration system
a. To transmit latent heat of evaporation b. To absorb latent heat of fusion
N
12. Centrifugal pump change over for pumping liquid of high specific gravity the discharge at the rated capacity will be
A. Increase B. Decrease C. Same D. Convert 50%
13. When steel components electroplated with chromium are used in corrosive environment
A. Chrome plating prevents corrosion B. Protection to the steel will be preferentially corroded
C. Zinc plating is used on top of chrome plating for corrosion protection D. Thickness of chrome plating to increase
14. ___________ boiler feed pumps is used in modern ships
A. Reciprocating pump B. Heleshaw pump C. Multistage centrifugal pump D. Single stage centrifugal pump
15. Refrigerant compressor will run continuously
A. Too heavy cooling load B. Air in the system C. Insufficient refrigerant D. Any of the above
16. Hot work onboard
A. Switch alarm B. Keep fire extinguisher C. Standby person D. All the above
17. Scale Formation in FWG evaporator side –
A. increase in shell temp B. heat transfer impaired C. production affected D. all
18. Which of the following is an important requirement for proper functioning of sacrificial anode system?
A. Good Insulation between anodes and ship’s hull B. Good electrical continuity between anodes and ship’s hull C.
Providing protection of anodes from being painted over during hull painting
D. Presence of an insulating material between anode and the cathode
19. Purifier leaking bowl opened, cleaned n seal ring changed and put back but still leaking what might b wrong?
A. high tempB. high densityC. disc size not properD. rpm low
20. Increased fuel injection temperature and maintaining recommended viscosity of a new bunkers fuel oil.
A. viscotherm running fineB. Problem in viscothermC. best quality bunkersD. None
21. A ball valve is found leaking in service and needs to be overhauled. What type of repairs can be carried out?
A. The ball and seat can be lapped together B. The ball can be machined while the seat can be replaced
C. Normally both the non-metallic seats get worn out and have to be replaced
D. Normally ball gets damaged and has to be replaced
22. Refer cooling tubes act as self-cooling & expansion by
A. Straight tube B. U tube C. Spring tube
23. Which of the following V/V cannot be overhauled in place without removing piping?
A. Ball Valve B. Diaphragm valve C. Globe valve D. Butterfly valve
24. Copper tubing is used in refrigerant system because
A. It has less internal resistance B. It is cheaper compared to other materials.
C. It is easier to check leaks in copper based system D. None of the above
25. The centrifugal pump r normally
20
A. Positive displacement type B. Rotodynamic C. Screw type D. Gear type
26. Cold and viscous lubricating oil of an auxiliary engine is most likely to cause ___________
20
A. Sudden stopping of the engine B. Difficulty in starting the engine
C. Rhythmic knocking sound from inside the engine D. Drop in RPM of the engine
27. When centrifugal pump is overhauled it was found that shaft sleeve had developed grooves on it and no spare is
available onboard. What action can be taken-
AM
A. order a new spare B. assemble the pump without doing anything and wait for the spare to arrive
C. machine the shaft sleeve on lathe and put back with new packing D. leave the pump as it is
28. Air compressor cooler tube type
A. Spring type B. Floating type C. Fixed tube D. U tube
EX
29. Fuels as produced in a refinery are generally sterile, however, contamination can occur as fuels are
A.stored at the refineryB. stored on the vesselC.transported to the distribution sitesD.All of the above arecorrect.
30. Which of the following can cause exhaust with white smoke in a diesel engine?
A. Water mixed with fuel B. Overload C. Dirty air filter D. Lubricating oil mixed with fuel
Y
31. Which of the following factors affect penetration of fuel droplets during injection?
A. Quality of atomization B. Injection temperature C. Scavenge air pressure D. All of the above.
G
32. Cylinder heads of marine diesel engines are provided with _________ to relieve any excessive pressure within the
combustion chamber
ER
20
A. prime mover speed B. exciter output voltage C. load on the alternator D. number of poles
49. A direct current passing through a wire coiled around a soft iron core is the description of a simple
A. magnetic shield B. electromagnet C. piezoelectric device D. electromagnetic domain
20
50. The amount of voltage induced in the windings of an AC generator depends on
A. the number of conductors in series per winding B. the speed at which the magnetic field passes across the winding
C. the strength of the magnetic field D. all of the above
AM
51. A goods train runs at the speed of 72 kmph and crosses a 250 m long platform in 26 seconds. What is the length of
thegoods train?
A. 230 m B. 240 m C. 260 m D. 270 m
52. A train 110 metres long is running with a speed of 60 kmph. In what time will it pass a man who is running at 6 kmph in the
EX
direction opposite to that in which the train is going?
A. 5 sec B. 6 sec C. 7 sec D. 10 sec
53. A father said to his son, "I was as old as you are at the “resent at the time of your birth". If the father's age is 38 yea”s
now,the son'’ age five years back was:
Y
55. When a plot is sold for Rs. 18,700, the owner loses 15%. At what price must that plot be sold in order to gain 15%?
A. Rs. 21,000 B. Rs. 22,500 C. Rs. 25,300 D. Rs. 25,800
56. A trader mixes 26 kg of rice at Rs. 20 per kg with 30 kg of rice of other variety at Rs. 36 per kg and sells the mixture at Rs.
30per kg. His profit percent is:
N
20
A. 3:7 B. 7 : 3 C. 6:7 D. 7:6
70. A cistern of capacity 8000 litres measures externally 3.3 m by 2.6 m by 1.1 m and its walls are 5 cm thick. The thickness of
the bottom is:
20
A. 90 cm B. 1 dm C. 1m D. 1.1 cm
71. A man purchased a cow for Rs. 3000 and sold it the same day for Rs. 3600, allowing the buyer a credit of 2 years. If the rate of
interest be 10% per annum, then the man has a gain of:
A. 0% B. 5% C. 7.5% D. 10%
AM
72. If Rs. 10 be allowed as true discount on a bill of Rs. 110 due at the end of a certain time, then the discount allowed on the
samesum due at the end of double the time is:
A. Rs. 20 B. Rs. 21.81
SYNONYMS
EX
73. FORAY
A. Maraud B. Contest C. Ranger D. Intuition
74. HESITATED
A. Stopped B. Paused C. Slowed D. Postponed
Y
75. RECKLESS
A. Courageous B. Rash C. Bold D. Daring
G
ANTONYMS
76. EVASIVE
ER
1.There is a cuboid whose dimensions are 4 x 3 x 3 cm. 2.The opposite faces of dimensions 4 x 3 are coloured yellow.
3.The opposite faces of other dimensions 4 x 3 are coloured red. 4.The opposite faces of dimensions 3 x 3 are coloured green.
5.Now the cuboid is cut into small cubes of side 1 cm.
79.How many small cubes will have only two faces coloured ?
A. 12 B. 24 C. 16 D. 12
80. How many small cubes have three faces coloured ?
A. 24 B. 20 C. 16 D. 8
81. How many small cubes will have no face coloured ?
A. 1 B. 2 C. 4 D. 8
82. How many small cubes will have only one face coloured ?
A. 10 B. 12 C. 14 D. 18
83. 835, 734, 642, 751, 853, 981, 532
A. 751 B. 853 C. 981 D. 532
84. 3, 5, 7, 12, 17, 19
A. 19 B. 17 C. 5 D. 12
85. Find out the wrong number in the given sequence of numbers. 582, 605, 588, 611, 634, 617, 600
A. 634 B. 611 C. 605 D. 600
86. 5, 10, 13, 26, 29, 58, 61, (....) find missing no
A. 122 B. 64 C. 125 D. 128
87. Find out the wrong number in the series. 7, 8, 18, 57, 228, 1165, 6996
A. 8 B. 18 C. 57 D. 228 E. 1165
88. Dumping is
A. selling of goods abroad at a price well below the production cost at the home market price
B. the process by which the supply of a manufacture's product remains low in the do’estic market, which batches him better
price
C. prohibited by regulations of GATT D. All of the above
89. Gravity setting chambers are used in industries to remove
A. Sox B. NOx C. suspended particulate matter D. CO
90. The ozone layer restricts
A. Visible light B. Infrared radiation C. X-rays and gamma rays D. Ultraviolet radiation
91. Goa Shipyard Limited (GSL) was established in
A. 1958 B. 1957 C. 1956 D. 1955
92. Brass gets discoloured in air because of the presence of which of the following gases in air?
A. Oxygen B. Hydrogen sulphide C. Carbon dioxide D. Nitrogen
93. When an iron nail gets rusted, iron oxide is formed
A. without any change in the weight of the nail B. with decrease in the weight of the nail
20
C. with increase in the weight of the nail D. without any change in colour or weight of the nail
94. Galvanised iron sheets have a coating of
A. lead B. chromium C. zinc D. tin
20
95. The group of metals Fe, Co, Ni may best called as
A. transition metals B. main group metals C. alkali metals D. rare metals
96. Heavy water is
A. deuterium oxide B. PH7 C. rain water D. tritium oxide
AM
97. The number of moles of solute present in 1 kg of a solvent is called its
A. molality B. molarity C. normality D. formality
98. The metallurgical process in which a metal is obtained in a fused state is called
A. smelting B. roasting C. calcinations D. froth floatation
EX
99.The first metal used by man was
A. iron B. copper C. gold D. bronze
100. The most electropositive elements among the following is
A. Na B. Ca C. K D. Cs
Y
___________________________
G
ER
N
SY